I bought a Yoder YS480 three years ago. I still use my cheaper pellet grill for everyday smokes, but I use the Yoder when I want to get serious. It does a beautiful job on baby back ribs (can do up to 8 racks laying flat on the grate) and I have smoked two complete turkeys at a time. The only time I have had a problem after 2 1/2 years of smoking was caused by a failed temperature probe. I got a new probe, installed it in a few minutes, and was back up and smoking again.
Editor-in-Chief Sean McCoy is a life-long outdoorsman who grew up hunting and fishing central Wisconsin forests and lakes. He joined GearJunkie after a 10-year stint as a newspaperman in the Caribbean, where he learned sailing and wooden-boat repair. Based in GearJunkie's Denver office, McCoy is an avid trail runner, camper, hunter, angler, mountain biker, skier, and beer tester.
When you have owned your smoker grill for 5-6 years you start wondering if owning a new one would be the best idea. This might happen because you are facing problems with your machine and not getting the desired result. The first and primary advice in this situation remains to clean up your grill thoroughly. Open up each and every part then proceed to doing a thorough cleaning. Most of the problems like temperature inconsistency or jamming will get solved this way.
Grilla Grills are not only great with their puns, but also great with their products. Since we compiled a list of top 10, getting rid of this product from our review was a very difficult choice. Silverbac Pellet Grill, along with several others from our honorable mentions list, has been tied with our advanced pick. Therefore, we were forced to place this on our honorable mentions list. With its traditional barrel-shaped design and astounding colors, they’d look nice in your backyard should they be your top choice.
This presumably has the most exact temperature perusing of any grill right now available. Accompanying a cookbook, a simple get together, and a decent outline, the PG24 is definitely justified even despite the cash. I enjoyed the decision of a wood screw framework rather than a suction framework, since it spares cash on pellets, and manages temperature better. For those needing to get into pellet grilling, this would be an astounding decision.
The Sense-Mate feature is another one of the best additions to this smoker: it is a thermal sensor system that monitors and reads the internal temperature of the grill within 5ºF of the actual temperature! Once you set your desired temperature using its digital controls, the Sense-Mate technology reads and monitors the temperature, while displaying it on the LCD display. Sense-Mate makes sure that heat is kept at a constant temperature, so whether you are cooking at 150ºF or 550ºF, you can rest assured that your meats will be evenly cooked.
Multi-position Controller - A step up from 3-position controllers, multi-position controllers feature a knob with temperature settings that go from 180°F to 420°F in 25° increments and may have an LCD display. In addition to more settings, these controllers offer more temperature control. However, they also run on fixed cycles and can only maintain about +/-20°F in ideal conditions—in cold windy weather they are less accurate and reliable. Some versions of these controllers have inputs for meat probes that can monitor food temperatures.
The completed transaction enhances Vista Outdoor's position within one of the camping market's most attractive categories, complementing its already broad portfolio of 50 brands in shooting sports and outdoor recreation. Wholesale dollar sales in the camping category grew at a 6% Compound Annual Growth Rate (CAGR) from 2010 to 2015 (source: Sports & Fitness Industry Association). Camp Chef's sales growth has been fueled by a strong product development pipeline and user-friendly products.
It doesn't matter if you're talking about pellet grills, pop songs, or pizza, everyone always wants to know which is the best. While that might seem like a fairly straight forward question, there is no simple one-word answer. Is the best pellet grill the most popular one made by the best-known brand? Is it the most expensive one with the most advanced features and high-end bells and whistles? Is it the one that offers the best combination of price and performance? Really, the answer depends on you, your means, and your needs. Or, put another way, maybe the question shouldn't be what's the best pellet grill? but what's the best pellet grill for you?
Overall, I think you would be happy with the smaller smoker / grill. I really like what Green Mountain grills has done with the Davy Crockett model, and that is the unit I have personally. That said,Rec-Tec makes a great product, and some people prefer the cart stand it comes with rather than the fold up legs that Green Mountain grills uses on the Davy Crockett modeling. Either choice would be good for you if you are looking for a smaller unit. I am of course speaking about the mini version of the Rec-Tec. The larger version is excellent as well.
With over 375 reviews, this product had an impressive review rate. On its first 22 days, it got its first 10 positive reviews. Ten days after, it got its 2nd set of 10 positive reviews, and its 3rd set of 10 positive reviews after seventeen days. Online reviews have shown that, just like us, customers have been satisfied with the overall performance of this smoker from Traeger.
So which pellet smoker is worth your hard-earned dough? We've put together a list of the ones we think make the cut, organized from lowest to highest price. Sorry for the sticker shock—even a low-priced pellet smoker will cost more than many grills, and our first selection lists at $333. These motorized, digitally controlled devices just plain cost more, but believe you me, they are worth it! And all of these selections have won the AmazingRibs.com Best Value Gold or Silver Medal.
Your choice of the pellet can also dictate how much cleanup you’ll have to deal with (even though generally 10 pounds of pellets can produce at most half a cup of ash, but this varies from pellet variant to pellet variant). Just be warned that when the temperature is high, there’s not much smoke happening, so you need to smoke out your meats at lower temperatures to get that smoky flavor.
In reading through the comments section, it seems the recommendations have shifted over time. As it stands today, which smoker would you go with and why: GMG Jim Bowie, Traeger Pro 34, or the RecTec? I like the cooking space of the Traeger Pro 34, but the other 2 seem to have more bells and whistles. I’ve been smoking about 5yrs, so not a pro but not a beginner. Currently have a 10+ year old Traeger Lil Tex elite hand-me down that is ready to give up the ghost. Would appreciate your thoughts!
Hey Tom! First, thank you so much for commenting on this article. I hope it’s proved useful to you and helping you make your pellet smoker buying decision. I took a look at the smokers you mentioned in your comment, and they appear to be similar in build to those made by Yoder. I can verify that Yoder does exceptionally good work with both the build quality and the heavy gauge steel Construction of their smokers. I don’t know much about the manufacturing practices of the smokers you mentioned. I do like the fact that their controller automatically dropped down to a warming temperature after your food reaches the programmed temperature setting. That’s a feature that I’ve only seen in higher-priced pellet grills like the Memphis Pro Series that I talk about in this article. However, more grills are starting to utilize this in the programming aspect of their controllers. In any case it’s a great feature. To be honest with you I’m not sure that the auger mechanics are going to be all that different between smokers. I’m sure there are differences, but I don’t feel that they are dramatic enough to offer a distinct selling Advantage for the manufacturer. If you haven’t looked at them yet, you might consider taking a look at the Traeger Pro Series pellet grills. You can’t find it on Amazon, but you can find them at different retailers listed on the main Traeger site. A friend of mine has one major competitions using the pro series models.
The Pit Boss Company manufactures an extra-large pellet grill with 700 square inches of cooking surface. It closest competitor in pellet smoker largeness is the 7-year veteran known as Rec-Tec. It has probably one of the largest cooking surfaces (or the largest at that) in the pellet grill and smoker industry. It approaches grilling with the idea that sometimes bigger really is better, at least in terms of cooking more meats at the same time.
Camp Chef is the company that perfected the pellet grill formula that Traeger made up, hence its introduction of an effective pellet auger that dispenses pellets only when needed and a large capacity hopper that reduces the need for pellet refills (that people find really annoying). It’s economical in terms of fuel rationing even though the griller itself is quite expensive.
Decided that moving these beasts was a little challenging so I bought a Backwoods Party 10 years ago and loved it. But basically have about worn it out. And as I got older I don’t enjoy getting up at 2 AM and then having to get up every couple of hours, after the 45 minutes of getting it ready at 2 AM, to check it and feed it. I also bought a smaller lightly used Open Range, The Good One. Used their recommended method the first time I cooked with it and hated the Q off of it so bad most of it was wasted, wife hated it too and the son ate most of it. It was extremely ash/strong smoke flavored!
With the traeger, rec-tec or cam chef smokers all seem to burn 1-2lbs per hour. But for a long 18hr brisket it seems like I will have to continue to use pellets the whole time to keep the heat in range over over 200 which will mean I am using almost a 20-40lb bag depending on the time year per smoke. This is even more expensive than the bradley seems even with the wasted briquette. IS this correct or is there something I am missing?
Hello John. Thank you for your comment and questions here! In short, you will not get the same smoke profile on a pellet smoker that you do with your BGE or PBC. That said, I do think there are some ways to mitigate this. Yes, I do feel the Smoke Tube and Mojo Cubes add smoke flavor that is detectable. Fred at Mojo Bricks does good work, and I recommend his products without reservation. This said, I have been happy with the smoke level I see in the pellet smokers I’ve used. Starting low does and ramping up later is a technique I’ve used with success when extra smoke is desired. The Rec-Tec grill gets high reviews across the board. I have no hesitation backing them, along with Green Mountain Grills. Both are made in China, but the companies have great customer service support and strong user communities. I believe each has a well-contributed Facebook group or two.
The Vulcan is a Picnic Time original design The Vulcan is a Picnic Time original design and the ultimate tailgating cooler and propane barbecue set in one. Don't be fooled by other similar looking items on the market. Only Picnic Time's Vulcan features a PVC cooler that conveniently nests inside the compartment that houses the portable propane BBQ. ... More + Product Details Close
Even if you’ve got a meat thermometer at home, it’s not a bad idea to pick up a smoker with one built in. This is because the built in thermometers send their readings straight to the smokers computer and it automatically adjusts how it’s cooking based not just on how hot it is inside, but how this affects what you’re cooking. Now, unless you’re Gordon Ramsey you probably can’t tell what’s going on inside that turkey you’re cooking, so this is obviously a major plus.
Now comes the best part about pellet smokers: they can conveniently do all these three. Coming with a large cooking space and a lid, the top rated pellet smokers would allow you to keep them open or closed, depending on what results you are looking for. With a dedicated space for putting your charcoal, you can use it as a charcoal grill, smoker or a barbecue. Or you can use it like a kitchen oven using the direct fire from the firepot. Finally, it does what it was made for – pellet smoking. Using small hardwood pellets running over the firepot in a corner, this smoker uses a fan to distribute the heat and smoke throughout the grilling area. This indirect heat ensures that the food is slow-cooked and smoked over long periods of time.
Take your outdoor cooking to the next level with the Camp Chef Pellet Grill and Smoker. Designed with the home griller in mind, built-in features simplify the process of smoking. The included digital temperature readout takes the guesswork out of the cooking process. An advanced digital temperature chip gives a more steady smoke and temperature, eliminating large temperature swings and giving a more consistent cooking temperature. Our patented Ash Can Cleanout System makes clean up the easiest out there. The Pellet Grill and Smoker features range from innovative digital smoker controls to dual temperature sensors. Discover the real secret of award winning BBQ cooks, low and slow smoking.
Louisiana Grills was one of the first companies to muscle in on Traeger's one-brand show. The smallish CS 450 is one of its more popular models. In 2014, Louisiana upgraded all of its pellet smokers to include digital touch-pad controllers with integrated meat probes. Set it and forget it; the thermostat will maintain cooking temperature just like your indoor kitchen oven does. As a safety feature, the meat probe can be set for your desired target temp. When the internal meat temp rises to within 10°F of the target, the controller automatically drops the smoker down to 170°F (77°C) to avoid overcooking.
Sometimes, the ideal pellet is something that costs a little over $1 for quality but you can still save money by buying them in bulk (like in 40 pound bags). Half a pound of pellets per hour is consumed on the smoke setting that’s about 175° Fahrenheit. Meanwhile, you can burn 2.3 pounds of pellet within an hour by setting the temperature at 450° Fahrenheit (this is an average on many of the pellet smokers mentioned above).
One final word of caution when it comes to pellet pricing. If you see a price on pellets that seems too good to be true, there’s probably a reason for it. If the pellets you got an amazing deal on creates twice as much ash, doesn’t burn as well, generates wild temp swings and ends up ruining a $65 brisket were they worth it? What about if that flame out or temp swing cost you a whole pit full of meat and ruined the family reunion the next day? We are all for saving money as much as anyone, but perspective is key here. We are in no way saying that great pellets cannot be had for pennies per pound, but we are definitely saying, that if those pennies saved are not on a proven brand that you can trust then it’s probably not a bet worth taking.
Aside from durability, a well-built pellet grill has another significant advantage: It will perform better. High-quality materials and good construction allow the grill to retain heat better, making it more efficient and providing better pellet consumption, even in cold weather. Furthermore, it's unlikely that a brand offering a cheaply made grill invested much time designing it to maximize airflow or engineering a control board that can hold a tight temperature.
Heating pellets, meanwhile, can consist of a variety of woods, including softwoods like pine, which contains resin that infuses food with a bitter unappetizing taste. Because it doesn’t really matter what’s in heating pellets, so long as they burn, they can also include bark and leaves and other impurities that can adversely affect food flavor and possibly pose a health risk if ingested. Because less care goes into the production of heating pellets and they're not guaranteed to be 100% pure hardwood, heating pellets are significantly less expensive than BBQ pellets, making them appealing to budget conscious shoppers. However, resist the temptation to save a few bucks and never use heating pellets in a pellet smoker.
As you can see from the image of a Traeger Pellet Grill above, pellets move from a hopper (left) via an auger to a burn pot (far right). The rate at which the pellets are fed into the hopper is dictated by your Pellet grill’s thermostat. Extra fuel in the form of oxygen is blown over the burn pot to increase the burn rate and help regulate a nice, steady, and efficient burn. The lower your temp, the more smoke is created.