It also has the standardized dial-in digital control with LED readout (not to the point that it has WiFi like the Green Mountain Grills Davy Crockett Pellet Grill, but still quite convenient). However, it’s rated low on this list because of poor quality control. Too many customers ended up with bad Pit Bosses that have inconsistent temperature control (going all the way to 615° Fahrenheit).

Some cheaper models, such as the Brinkmann, have a controller with only three settings, Low, Medium, High (LMH), and there is no temperature probe in the oven to create a feedback loop. We do not recommend these units. You actually have less control over temp than you do on a gas or charcoal smoker. The whole reason to buy a pellet grill is because it is set-it-forget-it and it hits a temp and holds it regardless of the ambient air temp outside, winter or summer. On these LMH controllers, the temp fluctuates widely and it cannot correct itself for the weather. They just aren't as smart as a digital device. Whether you're smoking a few slabs of ribs on a scorching summer day, or six pork butts during a blizzard, the three position controller only knows auger on and off times for Low, Medium, and High. It has no information on the temperature inside the cook chamber.
My brother said his Traeger blanket saved pellets in cold weather, so after talking to him I decided to order one. Used it for the first time today. The blanket went on easily & fit the grill perfectly. The temps this a.m. was below 0 when the meat started smoking. So far so good! The grill hasn't extinguished itself, a problem we always had when cooking in the cold, the temp of the grill is cooking like it does in the summer, & the meat is smoking beautifully. If you Traeger in cold winters this accessory is a must have!

Hey Chris, IMHO the Blazing Pellet Smoker looks like a solid unit. There’s a good review of it here. I think between the units I might give them a run. Yoder makes quality stuff, and if made in the USA is important to you, they fit as do the Blazings. All this said, if you’re basically using the pellet smoker like a Cambro, you could opt to save a little money and go with the Rec-Tec. Good customer service and solid following.

At present, I am sponsored by and continually use pellets produced by CookinPellets.com. There are two versions of pellets – the Perfect Mix (Hickory, Cherry, Hard Maple, and Apple Woods) and 100 Percent Hickory. In each of these versions, CookinPellets uses all wood, no bark, no filler woods like oak or alder and no flavor oils. Just 100% of what is on the bag. I get consistently great flavor using these two varieties of pellet smoker pellets from CookinPellets.com, and I think you’ll enjoy them very much as well.


Thank you so much for the kind words! I think you would be very happy with a smaller pellet grill / smoker. The wording changes depending on how you are using the device. For instance, if you are cooking at low temperatures you will get a stronger smoke profile then if you burn a pellet smoker / grill at its higher temperature range. One thing you could do for steaks is cook them at the higher range thus being able to get a sear much like you would on a direct heated Grill service, for instance on your Weber. Another option would be to cook the steak in the reverse see your method, by bringing it up to temperature at a lower smoker setting and adding some smoke flavoring that way, then removing it and bringing the smoker up to its higher settings so you can finish off the steak with some of the effect you would achieve on direct flame. I normally do this by bringing the steaks up to about 15 degrees below where I want them to finish. Then, I finish them off at the higher temperature to where they are about 5 degrees below my target. This usually means a few minutes on each side but I use a Thermapen to be sure.
Traeger Pellet Grill is the best pellet grill for outdoor cooking. It is a combination of several other cooking devices like oven, grill etc. It runs on fuel. This grill costs between $400-$700. You can search on amazon to get the current price of that product. You may search in different review website for details expert review on Traeger Pellet Grill. Whenever you buy this grill, please make sure it has folding legs.

If you can use an indoor slow cooker If you can use an indoor slow cooker you can easily amaze everyone with authentic smoked recipes. This Stainless Steel Double Grid Electric Water Smoker from Meco includes a 5.5 Qt. hydration pan to fill with beer juice wine soda sake water or other beverage so your smoked delicacies stay ...  More + Product Details Close


Another “set it and forget it” pellet grill, the Camp Chef allows you to set the temperature controls for up to a range of 500 degrees F, and leave it to do the regulating. With its efficient auto-dispensing pellet hopper and digital temperature controls, the pellet grill sets, maintains and adjusts the desired temperature for even cooking each time. With consistent and fuss-free temperature control, you’ll sure to have the most perfectly grilled foods.

Auger Making Weight Noises: It’s usually indicating a problem with the motor that’s responsible for rotating the augers. Under such circumstances, you would be left with no other choice than to replace the motor completely. Since the motors and augers are usually packaged together, this can get quite expensive. In such scenarios, it’s better to let it make noises and run for as long as it would serve you before going to replace it. However, once that problem occurs, you’d often find the auger not feeding the pellets at the expected rate and thus, the desired temperature might not be reached in some cases.
Joe Traeger first introduced the concept of Pellet Grill in 1980’s. Pellet grills are a rage amongst backyard grillers because they can grill, roast and smoke all in one. Since it uses indirect electric heat, there are no chances for it to burn into flames, unlike a gas grill. It is the perfect cooking appliance for a novice chef, looking to experiment with different dishes. Which is actually one of the primary reason for its unbelievable popularity.
One of the most common problems people encounter with pellet grills is abnormal temperature fluctuations—the controller is set to 250°F, but the grill is dropping to 200°F then climbing to 325°F. Usually people assume that it's a mechanical issue and either the controller or RTD probe need to be replaced. However, very often the problem is far simpler and the solution far easier.
Instead of logs, the pellet smoker is fed with food-grade cylinders of wood pellets that are an inch long and ¼-inch wide and are made of compressed hardwood sawdust. According to the best pellet smoker reviews, pellet grills are easy to use because it’s easier to maintain its temperature because of these sawdust pellets that are subjected to great heat and high pressure, which ignites lignin (natural wood glue).

I was so excited to get this grill for the weekend. It was easy to assemble and get going. It has a great place for me to keep my bbq tools and a front rack to set stuff down so I am able to easily put things on and off the grill. We made steak and lobster tails and they could not have turned out better and it came with a cookbook to know exactly how to do it!
As far as size goes, bigger is usually better when it comes to pellet grills. A large hopper means a longer time you can cook without needing to refill your fuel source. A bigger grill size means more room for a variety of meats or side dishes. Look for at least 700 sq inches of cooking space (that can include the upper rack as well – remember, pellet grills work like convection ovens.)
You need some temperature control in your grilling system: Even though most propane and charcoal grills include a temperature gauge, they’re not precise. Because the pellet Traeger grill works more like an oven, cooking at a precise temperature setting is a lot easier to do. It’s not quite as precise as the oven in your kitchen, but the Traeger system’s temperature control is surprisingly accurate most of the time. Some manufacturers of low cost pellet grills only offer low, medium, or high temperature settings.
I think a lot of reviewers here don't have enough experience in pellet grilling to recognize how many features are packed into this unit for the money. I'm not going to talk about the usual advantages of pellet grilling in general in this review (i.e., clean flavor, "set and forget", less ash,). Instead, I'm going to focus on what makes this one uniquely better than the other grills in it's class.
Now, jump ahead to my actually trying to get my Traeger replaced.  Per the email, I called Traeger customer service expecting the same service I received right after Christmas.  NOPE!    I spoke with Frank (Carson) I believe.  He did everything from accuse me of shutting my grill off and turning it back on incorrectly (impossible since I was in the house) to not cleaning my grill.   Neither of which were correct.    He basically made me feel like my grill was unsafe!  His attitude was HORRIBLE!  He was rude and condescending.   A nightmare to work with!

The single biggest advantage though, especially for beginning outdoor chefs, is that when you’re paying this much, damn near everything is automatic. As an example, if we look at our number one choice, the Camp Chef PG64 pellet smoker, literally everything can be controlled by the built in systems, so I could grab a friend who’d never cooked anything more complicated than boxed mac and cheese over, give em a five minute masterclass and be confident that the automatic systems would do most of the heavy lifting when it came to getting everything right.


Now, the best pellet grills come with more advanced features like auto-ignition using igniting rods, Wi-Fi Support, automatic turn on/off, and much more. One of the key safety features added by pellet smokers (designed by Green Mountain Grills), is a cooling fan to cool off the grill after it has been turned off. Even the shape of the body has been changed to have peaked lids so that it can accommodate turkeys and other kinds of roasts. Some come with multiple levels of racks for warming and cooling.

Hi Dan, I had a Bradley some years ago and the quality of the smoke is somewhat comparable to that of a pellet unit. As I said in my earlier post, compressed sawdust does not create the wood flavor that permeates the meat— no matter what pellet you use. I recently bought a Lang reverse flow, and on my first cook the difference was spectacular. My nephew went to the trouble of adding a full size wood burning firebox to his pellet stove as an experiment. He piped the smoke from the firebox into the pellet unit while making some ribs and the results were obvious. The next day he was out looking for a new smoker. Wood burners are a lot of work compared to a pellet unit, as you say, so I understand your reluctance. Many like vertical units that burn charcoal with wood chunks. These units are much easier to manage than a stick burner and give good results. All I can say is that the first time you make BBQ in your backyard with a wood unit, you will know you made the right choice. There are many good BBQ forums that discuss these points. Good Queing to you.
The cooking process is made a lot more convenient with this smoker. To start cooking, all you need to do is flip the Traeger on/off switch, and you’re good to go. Then, you can simply set your desired temperature through the digital controls. Enjoy your time and relax while you leave the unit to do everything else. With its efficient temperature control system and automated auger with an induction fan, heat remains constant throughout the cooking process. You’ll have evenly-cooked foods that have that mouth-watering smoky flavor in no time.
Overall, I think you would be happy with the smaller smoker / grill. I really like what Green Mountain grills has done with the Davy Crockett model, and that is the unit I have personally. That said,Rec-Tec makes a great product, and some people prefer the cart stand it comes with rather than the fold up legs that Green Mountain grills uses on the Davy Crockett modeling. Either choice would be good for you if you are looking for a smaller unit. I am of course speaking about the mini version of the Rec-Tec. The larger version is excellent as well.
This will work using one burner only on the stove when connected to our RV exterior grill connection port. Our camp chef portable stove has one large and one standard burner. It would only operate on the standard burner due to the low pressure regulated on the RV piping system. Be prepared to break out the standard propane tank & regulator hose set if you plan on running a two or three burner camp chef stove. Rating is 4 stars due to the price and short length at $35 price tag, it could have been longer.
REC TEC Grills was born in Augusta, Georgia in 2009 by lifelong friends Ray Carnes and Ron Cundy. The pair made it their commitment to build high quality grills and sell them at reasonable prices. But that was only the beginning of their story. The rest of the promise was to treat everyone like family and provide them with world-class customer service. With those two fundamentals in place, the REC TEC Family was born and the REC TEC Lifestyle started to flourish. Your feedback as members of the REC TEC Family and your living the REC TEC Lifestyle has helped this family grow and become that special bond that binds us all together. Thank you to all of our current and future REC TEC Family members. It just would not be the same without you all.

I purchased a Traeger Lil Tex 22 yesterday. I “grilled” a whole chicken. It overshot the temperature by nearly a hundred degrees which wasn’t a bad way to crisp up the bird but I was afraid it was going to melt itself down so I shut it down. I was up by 5 this morning to smoke a pork butt for pulled pork sandwiches. My wife’s family is coming over for dinner tonight and time being a concern I fired up the “smoker”. It snowed 12 inches last night so the next hour I was shoveling my walks. Imagine my surprise when I checked on the Traeger and it had shut itself off . The meat was colt to the touch. I read through the instructions to make sure I started it up correctly and I did. I removed the meat and restarted the smoker. It smoked for awhile then quit. The temperature never got above 140. I called Traeger technical support twice and each rep gave me a different answer as to why it wasn’t working. After 3.5 hours I gave up on the Traeger for a more conventional method. I purchased the Traeger for the the set and walk away feature. It let me down!! It is 34 degrees outside today so I will wait until it warms up to try again. Should it fail me again I will sell it for scrap! So far I am not impressed. My wood smoker takes time but it is reliable.


So, there they are: my pellet grill review of 2016-2017.These information are surely going to help you from going nuts when trying to purchase your own pellet grill. These pellet grill review will give you a clear straight forward understanding of the best and most conventional features in pellet grills in the market today. Now that you are all set thanks to the pellet grill review, go grab yours, call some friends over and have a great weekend!
Camp Chef has already been mentioned several times on this list. It's a venerable company that makes up in quality what it lacks in the name recognition of a Traeger or Weber. Their Deluxe Pellet Grill is built to reach and hold ideal temperatures for smoking. An internal system syncs pellet delivery to temperature instead of simply feeding in fuel when it begins to run out. This ensures a clean, consistent cooking experience. A removable ash can makes clean-up a snap as well.
Kevin- I’m in the process of researching to get my husband a grill for Christmas. I’m torn between the 820 you mentioned above and the Traeger Pro Series. As far as I can tell they are basically the same except that you get a larger cooking area on the pit boss for the same price you pay for a small cook space in a traeger. I would like to spend around $600 on the grill but would possibly go up to $800 and want 500 sq in cook space or greater. Which do you prefer? Pit Boss, Traeger or another brand?
The best thing about pellet smokers is that unless you’re buying the absolute cheapest models, there are no bad choices. In this list for under $500, you’ll find pellet smokers and grills perfectly suited for dropping a few burgers at home use like the Traeger Junior Elite, for throwing in the back of the van and using anywhere like the Green Mountain Davey Crockett, or for cooking whole turkeys when you have ten people round on Thanksgiving, like the Camp Chef Smokepro.
The Champion Competition Pro Wood Pellet Grill and Smoker by Louisiana Grills takes outdoor cooking versatility to all new heights. A total cooking area of 3432 sq. in. (8718 sq. cm) and fully integrated multi-chamber smoking cabinets, the Champion Competition Pro is designed to be a show stopper. With direct and indirect flame grilling in the main barrel, hot smoking in the lower smoke cabinet, and cold smoking in the upper smoke cabinet, the Champion Competition Pro is the ultimate grill for the outdoor barbecue enthusiast. This grill revolutionizes grilling in three different ways: the digital control center and lid thermometer allows for precise temperature control of a dynamic range of 60°F-600°F (15°C -177°C) for grilling and smoking, the use of all-natural hardwood pellets allows you to enjoy the amazing wood flavor with the single push of a button, and a programmable meat probe that works together with the digital control center to regulate temperature.
I cannot comment on the quality or Function of the Grills as I never received mine. I order a Texas Elite 34 at the Minnesota State Fair on Aug. 23rd for $899 with a few extras and was told this was the lowest price ever (Not True). They did not tell me about the pro series which I found later. They said it would be delivered within 7 days. 2 weeks later no grill so I called customer service just asking on when I would get the grill. They could not find my order and did not believe I ordered one... They said I had to email them my receipt as they could do nothing on the phone.
Wood pellets that are tailored for pellet stoves or fireplaces usually contain tree barks and binding agents such as glue. When used in pellet smokers, these wood chips can expel some harmful chemical substances infused with the food. But since the dawn of Traeger pellet smokers, different manufacturers have been producing food-grade wood pellets to be used in pellet smokers.
Not all people and culture will be able to truly understand our love for barbecue here in the USA. For them, it might just be a cooking activity while for us, it’s a tradition – a ritual to celebrate the summers (and occasionally the winters). As long as this love for grilling stays with us, which will be, we’re going to continue to expect more and more from the grill manufacturers.

Whether it's smoking a rack of ribs or grilling a wood-fired pizza, to even baking a homemade apple pie, do it all with Traeger's 6-in-1 versatility. No matter what you grill, smoke, bake, roast, braise, or BBQ, it all gets flavored with amazing Traeger wood-fired taste. Don't settle for a grill that can only grill or smoke when you can do it all with a Traeger.
Hey Rob! First, I really appreciate you reaching out. That’s what The BBQ Beat is for! To your question, I own a Davy Crockett Tailgate Model pellet smoker and really like it. Full disclosure, it was given to me by the company to test and Jason Baker of GMG said I could just keep it. But, I get a good number of products to review sent to me and a whole lot of them don’t make it onto the blog. I’d rather “omit” than “detract” – keep things positive sharing the stuff out there that I can get behind.
Turn it on to "Smoke" mode and use the P settings, or cook mode by selecting a temperature. When you select smoke or a temp setting you start the ignition sequence. The fan, igniter and auger motor turn on. The fan stays on until the smoker is turned off. The auger motor continuously delivers pellets to the red hot igniter rod in the firebox for two minutes under normal conditions. Then the igniter rod shuts off and the pellet fire burns with only the assistance of the auger and the fan.
It doesn’t matter what it is that you’re buying, you want to get the best bang for your buck and not pay more than you have to. We all have this same mentality when it comes to making a purchase. This is why when we see price tags that indicate something is “on sale’, we immediately think we are getting a good deal. But is that really the case? The answer is no. When it comes to buying your new pellet grill “on sale” from a distributor or retailer, it means that they are essentially reducing the markup that you have to pay. Aside from the rare instances where a retailer is selling a product as a loss leader where they are intentionally losing money on a product to get you into the store and buy other more profitable products, you will still be paying more money in the end than what the manufacturer would price the grill at if they were to sell it to you directly.
Third name to make it to my list of the best pellet grill review is The REC TEC Wood Pellet grill. It has a trademark Smart grill Technology, which maintains precise temperature. This amazing pellet grill has a whopping 702 square inch cooking area, and a 40 pound capacity pellet hopper. It is made out of high quality stainless steel. It comes with a drip pan.

Hey Eric! Man, thank you for the kind words. While I don’t post every day, I do try to make what I share with you guys as informative as possible. To that end, your words mean a lot. Now, the pellet release option is a great feature to have on any pellet smoker. In cases where you don’t have one, I suggest using a small shop vac you use just for pellet removal. Works great. But the quick release chute option saves a ton of time and effort for sure. Not what I’d call a deal breaker if a pellet smoker you like doesn’t have one. However, I’d like to see it become standard on pellet smokers for sure!
In addition to providing savings, using an oak base also creates consistency. Different types of wood have different densities, burn at different rates, and produce different amounts of heat and smoke. For instance, cherry burns faster than hickory, so using 100% cherry you’d go through more pellets than if using 100% hickory. The addition of oak allows every flavor to burn at a similar rate and with a similar heat output, providing consistency from cook to cook.
160ºF up to 500ºF temperature range for slow smoking to grill (25,000 BTU). Stainless Steel meat probe measures internal food temperature. Simple Ash Cleanout System (patented).Smart Smoke Technology. Stainless Steel fire box. Digital controller automatically maintains cooking temperature. Grease Management System. Blue LED digital temperature display..Bottom utility rack. Large, heavy wire grilling area dimensions: 19.5" x 22". Included warming rack provides (570 sq. in. total cooking surface).
Over time, as other companies started entering the scene, the designs saw some massive improvements. Later, the firepots were brought closer to the hopper, reducing the distance the pellets had to travel to reach it. This move reduced the probability of a pellet jam. Later, more features began to be added to these grills to further improve the reliability, safety, and convenience.
Many other features, like its automatic control and built-in meat probe have made us select this smoker as the top one in our pellet smoker review. And the most amazing fact is the price. In the price range (see the price here), we never thought that we could get all these features and benefits. We took all the top smokers into considerations like the Rec Tec smokers, but this PG24 by Camp Chef can beat all through its performance and affordability.
My traeger has had some good moments but it very unreliable.  I really do not enjoy cooking with it.  I have no confidence in the temp readings and the smoke control.  Every time I open the lid the temp drops like 200 degrees.  I'll smoke at the "smoke" setting but as soon as I turn it to 225 it spikes to like 300-500 degrees. Wtf?  I thought this POS was supposed to be a set it and forget it type smoker.  Very unreliable.  Temp fluctuates so much and if there is even a slight breeze the temps just go up and down up and down.  The pellet feeder is garbage.  It will all the sudden just start smoking like crazy because the pellets have jammed into the burner.  Completely ridiculous smoker.  I use it still but only when I can sit and watch the feeder.  The guys comment below is true about the feeder always just using the middle pellets.  I always have to check it and push the pellets to the center.  Some simple engineering would change this. Never again will I purchase a traeger. There are much better options out there and better price.
The Silverbac and the Silverbac original models of the Grilla Grills come with a good build. It has a stainless steel burn grate and a stainless steel firebox with a rugged exterior. It is painted with a high-temperature powder coating on a heavy-duty steel body. The seams are welded, caulked and powder coated for a three-layer weather resistance. Its lid and all the internal components are made of stainless steel, greatly improving this product’s life.
When it comes to construction, few companies can beat Traeger. Its grills come with construction features like cast-iron grates with a clear and nontoxic coating that prevents food from sticking to the grill and fireboxes made from a similar material. Though Pit Boss grills feature similar elements, many look flimsy, and most will not keep up with your grilling and smoking demands.
We have already mentioned this product in our review once and we’re talking about it again. Whenever you are thinking of Green Mountain Grills, Daniel Boone should always be your first choice; it’s simply the best among the GMG products. Due to having other products at much lower prices with the same features, we could not include Daniel Boone in this review. We have, however, included the Davy Crockett in our review as our Budget Pick.
Hey Jay – Yoder makes a great product. Price not being an option, I’d probably go MAK, Memphis Pro (I go back and forth between the two personally!), then the Yoder. I’ve heard good things about the Louisiana pellet grills, just haven’t featured them here so haven’t done a lot of in-depth research. I’m inclined to rate it below the ones I just mentioned – but not by tons. I will say that if American Made is a factor, MAK, Memphis, and Yoder are a go there.

I recently purchased a a Smoke Hollow pellet grill from Sam’s. Seems like quality is good and it was recommended by a friend. Temperature control has issues. I called for customer service a couple of times and they sent a new thermostat. Still can’t get temperature to to hold at setting. Am I missing something? Told to start and let preheat for 10 minutes and then move to desired temperature. Tried setting new thermostat at 190 and let it go for 15 minutes and it was back at 230 when I checked it. Any suggestions?
A FOLLOW UP: Traeger has agreed to send me replacement parts for the defective ones and I don't have to return them. However I am not returning the grill. I tried to cook a prime rib and a Boston butt. The grill randomly turned off three times and it had the "mini-explosion" others have talked about where the unit actually has an explosion within the housing lifting off the lid a couple inches and making a loud boom. This is not only a potential safety issue, but the "set and forget" is simply not true. It turned off within an hour after setting the temperature at 225 and leaving it unattended for an hour. This is not what I expected or wanted. Sorry Traeger quality is not what it is cranked up to be and certainly not worth the premium pricing they charge for their name. DON'T BUY THIS IF YOU EXPECT TO GET A GRILL THAT WORKS AS ADVERTIZED.
For example, many grills use and charge for collaborating with a software application on it. I, personally, think this is an absolutely silly feature to include on a pellet grill. Yes, it does start on and off from your phone and change temperatures while you are at Switzerland enjoying Swiss cheese on a lake, but really, is it even logical? I mean, pellet grills have already made the cooking experience as easy as a dream, the least you can do is set the temperature by the click of a button on the appliance yourself! You can’t possibly be that lazy!
Like other grills, pellet grills list cooking area two ways: primary cooking area, which refers to the main cooking grate, and total cooking area, which is the main cooking grate plus any secondary racks. However, since pellet grills are primarily indirect cookers, there really is no difference between cooking on the main rack or the upper rack&em;the temperature should be the same. Therefore, a smaller pellet grill with a primary grid of 450 square inches and an upper rack of 125 square inches may be a better option than a larger grill with only a 500 square inch primary grid.
I purchased a Traeger Lil Tex 22 yesterday. I “grilled” a whole chicken. It overshot the temperature by nearly a hundred degrees which wasn’t a bad way to crisp up the bird but I was afraid it was going to melt itself down so I shut it down. I was up by 5 this morning to smoke a pork butt for pulled pork sandwiches. My wife’s family is coming over for dinner tonight and time being a concern I fired up the “smoker”. It snowed 12 inches last night so the next hour I was shoveling my walks. Imagine my surprise when I checked on the Traeger and it had shut itself off . The meat was colt to the touch. I read through the instructions to make sure I started it up correctly and I did. I removed the meat and restarted the smoker. It smoked for awhile then quit. The temperature never got above 140. I called Traeger technical support twice and each rep gave me a different answer as to why it wasn’t working. After 3.5 hours I gave up on the Traeger for a more conventional method. I purchased the Traeger for the the set and walk away feature. It let me down!! It is 34 degrees outside today so I will wait until it warms up to try again. Should it fail me again I will sell it for scrap! So far I am not impressed. My wood smoker takes time but it is reliable.
×