Hey Charlie – I’d leave that grate wide open if you want maximum heat. If the grates are only over the burn pot, then you can do sort of a two zone cook (indirect vs direct heat) by putting a thicker steak, chop, or piece of chicken on the ‘non direct’ side to get up to a temp that’s 15 or 20 degrees lower than your target. Then, finish off over the burn pot area. Just one idea.
This cooker is still the best value for the dollar for pellet grills I have been looking again for a larger rig, but haven't found one better. If you are looking for an entry level pellet grill this is the one you want. Don't be discouraged by the reviews that talk about leaking smoke or not sealing well because it does leak smoke everywhere. Look at the pic I attached to my review you can see it for yourself it does, but isn't it silly to buy a smoker that doesn't smoke. If you ever go to a BBQ competition you will see most of their smokers leak smoke also.
The great part about this smoker is that it is fairly light-weight, weighing in at 69 lbs, and its legs double as handles: all you have to do is fold the legs up and carry the smoker wherever you need to! Furthermore, this smoker comes with a 12V connector that you can plug into the cigarette lighter of your car, and a 12-foot alligator clips that you can connect to your car’s battery if necessary. You can take this smoker anywhere!
Just like your kitchen oven, a pellet grill must keep a consistent temperature in order to produce great food. To get tender brisket, the temperature needs to stay as close as possible to 250°F for the entire 12-plus hours its cooking. A pellet grill’s ability to do that is largely determined by its control board, which is essentially the brains of the pellet grill. There are different types of controllers, and their precision and consistency varies. Most can hold a consistent temperature in ideal conditions, but not all controllers can maintain a tight temperature in the cold, wind, and rain.
If you are looking for the perfect spacious grill for home cooking, then this Traeger grill is yours for the taking. This is the most sold and famous model of Traeger grill in the market currently. It uses different kinds of hardwood pellets to smoke, grill, braise, bake, roast and barbecue different flavored dishes. Besides, it has a compact design that saves on storage space. It is built to last with sturdy steel construction with a powder coat finish. Additionally, it has a non-stick surface that makes it easier to clean and maintain the grill grates. Moreover, it is 418 square inches, enough for 16 burgers, 5 racks of ribs and 4 whole chickens.
The small burn pot is covered with a large deflector plate that absorbs the heat and spreads it out below the cooking surface making them essentially wood-fired convection ovens. Flare-ups are a thing of the past. You need to keep the plate clean because it is right below the food and if you leave sauce and grease on there, it can smolder and leave soot on your food. Carbon buildup will also diminish its heat transmission.
From among these 65 products, we have selected the top class pellet smokers out there shortlisting 18 of the best candidates. Then, we have conducted a secondary research and compared their features against each other to find the best 10. Finally, we have compiled this review list of top 10 best rated pellet smokers considering their features, reviews, ratings, review frequencies and how great they were when we tested them out during BBQ parties.

However, with a pellet smoker, you can ensure that new pellets are being fed into the fire automatically, ensuring that it burns for longer and while it burns, it imparts with its flavors. It doesn’t need to be soaked and fed into a burning pile of coal to work. Above that, sawdust, when separated by the heat and being burned, gets a larger surface area to burn with and thus sends out a bigger burst of flavor per pellet.
PG24 by Camp Chef has a weight of 124 lb with a pellet hopper that has 20-pound capacity. That’s so large, you won’t need to worry of getting more before your meal is done. This approach allows you to have the ultimate cooking experience. When the temperature drops, one wood pellet is released. This convenience can’t be found in other grill types, like gas or charcoal.
With the upcoming and already existing new features, you can achieve an easier and much better smoking experience than ever before. Always look for features that can help bring out the real taste of food, and give you more control and convenience. Keep visiting this page because we will always be the first ones to bring you the newest and the best news about the innovations in grills and smokers.
From the models and brands that I have reviewed here, I highly recommend the REC TEC 680 Wood Pellet Grill as the best pellet smoker. This comes with a grill technology, which gives you more convenience, whether you are a novice or an experienced grill master. If you have found this article to be helpful, please share it with your friends and family and help them make the right decision.
Central to all pellet cookers is a digital controller similar to the controllers on modern indoor ovens. You select a temp you want, and there is an LED display that tells you the actual temp. Some of the controllers also are programmable so you can cook at a certain temp for a determined time. Some have leave-in meat probes that can dial back the ovento a holding temp when the meat hits its mark.
Standard shipping via common carrier "Threshold Delivery" is included in the quoted price. "Threshold Delivery" includes placement inside your front door or garage. Delivery can only be made inside the front door on the ground floor of multi-level housing. Carrier will call or email to set up a delivery appointment. Please include a daytime phone number in the shipping information at the time of check out and please monitor your emails for an opportunity to set your delivery appointment. Deliveries are made between the hours of 8 AM to 5 PM, Monday through Friday, and will be scheduled as a 4 hour window. Extraordinary delivery requirements may necessitate an additional fee to the carrier. NOT INCLUDED: Placement in your room of choice, removal of packing materials and assembly are NOT included.

CAMP CHEF: for over 25 years Camp Chef has been making quality cooking gear for all of your outdoor cooking needs. Our products include Outdoor Cookers, Emergency preparedness stoves, Pellet Grills, Smokers, Pizza Ovens, Cast Iron Dutch Ovens, Flat Top Grills, Griddles, Fire Pits, Outdoor Movie Screens, and many more. Camping, Catering, Tailgating, Hunting, Dutch Oven cooking or even just on your deck at home. Cooking is our passion.
The Texas Elite 34 pellet grill is a fairly basic pellet grill that still gives you lots of versatility: you can grill hot and fast, or smoke low and slow, you can bake, braise, roast, or bbq all sorts of food to juicy perfection! Just like an oven, you set the temperature and the Integrated Digital Elite Controller keeps the temp within +/- 20 degrees F for as long as you need it!
Camp Chef's Woodwind Pellet Smoker is a quality smoker and super searing grill wrapped up in one. As I mentioned above, though pellet smokers are often referred to as pellet grills, most have a limited grilling capability at best. To fill this gap, in 2017, Camp Chef introduced its optional LP gas Sear Box, which can be added to any of its current SmokePro pellet smokers. Woodwind is a package deal that comes standard with the Sear Box and sells for about $50 less than a SmokePro with the optional Sear Box. As a bonus, Camp Chef is one of the few brands on the market with an ash-removal system that deposits ash in a cup under the smoke box for easy disposal.
We’re people like you, people who love outdoor cooking—the food, the fun, the time with family and friends. We’ve turned that passion into expert knowledge and an unmatched selection of BBQ and grilling products. Any question, big or small, we can help. From your first click to your next call, whether you’re interested in backyard BBQ or an outdoor kitchen, we have what you need and same-day ship nearly every order from our huge in-house inventory.
In addition, due to the wood pellets used in the Traeger grill, it is easy to cook different food products even pies, something that is impossible with charcoal or propane fired grills like the big green egg grill and the camp chef grill, respectively. Moreover, it is hard to get consistent results with the big green egg grill, as some food might come out good while others will just burn. It is a great challenge to use the big green egg grill.
I have used a pellet smoker for about five years, and looked at, or used, many different brands. I have added auxiliary smoke generators, and tried almost every way possible to create authentic BBQ on a pellet smoker— It can’t be done. When the vendors, or users, refer to subtle smoke they mean virtually no wood flavor. Do yourself a favor and try a simple test: go to a really good BBQ joint, or BBQ competition; try some of their Q and then compare it to pellet meat. There is no comparison. I wanted the pellet unit to produce good Q in the worst way because of the ease. You cannot duplicate the smoke created in a wood, or wood/charcoal firebox with compressed sawdust. It pains me to say it but it is true.
Though the Memphis Pro works great as a high heat, sear, and direct flame grill, I chose to do some IBP ribs and a couple all natural pork loins I picked up from the store. I won’t go into too much detail on the pork loin and rib prep here, suffice it to say that I was very impressed with the smoke output I got from this unit, which I filled with a full compliment of CookinPellets Perfect Mix Pellets.
Igniter: An igniting rod, heated up to a red hot level, ignites wood pellets as they fall inside the firebox. A cooling fan blows air into the pellet smoker from behind the pellet auger to prevent heat backdraft, while the fan underneath the firebox fans the flame – distributing heat evenly throughout the smoker. This heat is used to smoke and slow cook food in the smoker to give it the best flavors possible.
I bought a Yoder YS480 three years ago. I still use my cheaper pellet grill for everyday smokes, but I use the Yoder when I want to get serious. It does a beautiful job on baby back ribs (can do up to 8 racks laying flat on the grate) and I have smoked two complete turkeys at a time. The only time I have had a problem after 2 1/2 years of smoking was caused by a failed temperature probe. I got a new probe, installed it in a few minutes, and was back up and smoking again.
I watched the Traeger infomercial on T.V. Seemed easy enough. Ha! QVC ran a similar infomercial on their channel, seemed really easy. Ha! Like a fool and his money are soon departed, I jumped in and bought one. When it came in the mail, I started to assemble it. What a joke! No instructions came with it to tell me where the nuts and screws went. Called the manufacturer. The lady said they had many complaints with the QVC orders, she would email me a copy of the instructions. Well I finally put it together. Performed the (curing and start up method). Bought a nice pork shoulder and started grilling. It is interesting that both infomercials say set the temp and WALK AWAY!!! What a joke, I sat and watched the grill like a hawk for 3 hours, everything was good. I figured I would go eat lunch, ha! What a mistake. When I came back (20 min.) the grill had turned itself off and had an error on the screen.
Cleaning/Maintenance: The grease catcher on this flat top is pretty decent. It is located on the bottom left hand side and all the oil/grease gets caught without anything dripping elsewhere. I usually wipe the grease catcher's orifice down with a paper towel to ensure it does not get clogged up over time. Other flat-top grills have either grease catchers that drip onto the leg of the grill or have them in the back of the flat top which is a little inconvenient getting to. As for cleaning after every use, I use a stainless steel scrapper/chopper to wipe the grill clean after I am done cooking. I scrape everything down into the grease catcher. For saucy foods or foods that might stick to the flat top, I use water when the grill is still hot to scrape it off and send it to the grease catcher. Afterwards, I put a little bit of oil onto the flat top and spread it all over using paper towels to maintain the seasoning before putting the cover on. Total clean-up time and re-seasoning takes roughly 3 minutes.
Pick an item that is anything but difficult to clean and store. Stay away from massive units on the off chance that you don’t need your grill to stick around in the kitchen when not being used. You may likewise need to pick one that your space can suit. And afterward, search for a model that can be effortlessly cleaned and that accompanies a deplete framework and an oil/dribble plate/gatherer.
The initial design by Mr. Traeger consisted of a “classic” drum barrel shaped grill design with a chimney on top. Instead of the firebox, the grill contained a pellet hopper. It used a fan to distribute the heat evenly over the pellets. Unlike the modern pellet grills, the original design didn’t include any auto-ignition features and the pellets had to be lit manually.
Have you reviewed at all the Grilla Silverbac? If so, does it not make your list because it isn’t as good a quality as those you have picked? I mean, when I look online for reviews of those who have bought them I haven’t found anyone disappointed with theirs, but perhaps they haven’t been out as long to have a track record? I’m so confused at this point as to which to buy with PID or no PID (some say smoke does better without one), thickness of metal, etc.
Number two when cooking with charcoal (yes plain Kingsford is good stuff if you do it right, a lot of the cheaper brick and cheaper lump can put some weird twangs in your food) brick or lump can produce quality high temp steaks or slow & low bbq! To add some nice flavor add some wood, but do your homework! I think Clark ‘Smokey’ Hale has one of the best books ever for the grill and Q master, “The Great American Manual on Grilling and BBQ or something like that. Last I saw you can grab a used one on Amazon for a few cents and some shipping. The most prolific thing I read in there that so many miss, is burn your wood and your charcoal to where it is literally a coal of gray ash covered glowing ember. Do that and you will find a new flavor in your cooking! Problem is so many places think heavy smoke is great, as they are trying to imitate cold smoke flavors! They are not the same! All this talk I see here about, “I want heavy smoke flavor.” I can tell you if you burn your wood and your charcoal (and I feel even lump needs to be well on it’s way to gray ash covered or you get bitter smoke even though many say not necessary) to a red ember with gray ash covering 80 to 90% minimum preferably completely covered your flavor profile will change. Many supposedly good bbq restaurants I have been in serve something with a bitter or ash flavor, which I find much less enjoyable.
I purchased a Traeger Lil Tex 22 yesterday. I “grilled” a whole chicken. It overshot the temperature by nearly a hundred degrees which wasn’t a bad way to crisp up the bird but I was afraid it was going to melt itself down so I shut it down. I was up by 5 this morning to smoke a pork butt for pulled pork sandwiches. My wife’s family is coming over for dinner tonight and time being a concern I fired up the “smoker”. It snowed 12 inches last night so the next hour I was shoveling my walks. Imagine my surprise when I checked on the Traeger and it had shut itself off . The meat was colt to the touch. I read through the instructions to make sure I started it up correctly and I did. I removed the meat and restarted the smoker. It smoked for awhile then quit. The temperature never got above 140. I called Traeger technical support twice and each rep gave me a different answer as to why it wasn’t working. After 3.5 hours I gave up on the Traeger for a more conventional method. I purchased the Traeger for the the set and walk away feature. It let me down!! It is 34 degrees outside today so I will wait until it warms up to try again. Should it fail me again I will sell it for scrap! So far I am not impressed. My wood smoker takes time but it is reliable.
When the grill was delivered on or about Nov 23, it was damaged.  The Grill Barrell had a dent in it, caused by a hole punched in the box during UPS delivery.  We didn't immediately put the grill together, so a couple of days went by, and then we began the assembly.  I called Traeger Customer Service and they told me to disassemble the grill, put it back in the same box and packing and return it to them.  I tried on about five telephone calls and emails to explain that we did not have the box, the packing or the UPS return postage.  Traeger then sends UPS to my brothers house 3 times to pick up a grill that they would not send packaging for, nor would they send any packing materials.  They wanted my brother to tear the grill down, electronics and all and return the dented  grill body, but they'll only send a good body when they get the damaged body.  So meanwhile, we have a grill minus a body waiting on Traeger to send us a new one.
Is it customer support? I ordered a grill cover(made by a outside vendor in Kansas as well) for my YS640. It ended up with a small leak. I called Don, and by the end of the week I had a brand new one. Also, I was getting ready for my first cook on my brand new YS640, and I invited the whole family over for baby back ribs. I called Joe, and he talked with me on the phone for 20 minutes explaining how the grill worked, what temp to set the pit at, when to rotate the ribs and even which ribs will need to be rotated. Joe was spot on! Best ribs I have ever had!!!
From the second I ordered the YS640 to the day it arrived the service and dialogue with ATBBQ was first rate. They actually care about the customers service experience! One word of caution for anyone thinking about buying this beast. Make sure you have someone strong to help you unload it off the pallet! My neighbor was amazed at the heft and build quality!
The cleanout for both the pellets and ash is a huge perk to the grill. The patented “Easy Ash Cleanout” does not require the user to take apart the grill. Instead, they simply have to twist and dump the container. The 18lb pellet hopper is similarly an easy cleanout. The stainless steel also makes it easier to clean the grill because of the steel’s properties.
I have ate a few peoples cooking that have won at the Royal, Houston and Memphis in May. They have all had one thing in common, I didn’t put one drop of sauce on them and they had not been sauced on the Q before serving! The restaurant Cackle and Oink is just a ways from where we live and the owner Aaron Vogel is there regularly. I have tasted all his sauces and they are very good, but the 3 times I have been there, his sauces never touch my ribs and brisket! Aaron does say, if you like this you need to try my competition food (which I will at one of the competitions he is in locally). None of the KCBS, Houston or Memphis in may winners Q had even a hint of ash or bitter smoke flavor. They also had a very light smoke profile. They also all say they cook over well burned down wood.
One option is to put a griddle or a frying pan on the grill, high heat, get it blistering hot, add just a little oil to prevent stickling, and sear by conduction on the metal. It should only take two to three minutes per side. This is a good technique for reverse seared meats. You start them indirect, low and slow, with a little smoke, and then Maillard the outside in a hot pan or on a griddle. No, it's not cheating. It's making food better.

Louisiana Grills was one of the first companies to muscle in on Traeger's one-brand show. The smallish CS 450 is one of its more popular models. In 2014, Louisiana upgraded all of its pellet smokers to include digital touch-pad controllers with integrated meat probes. Set it and forget it; the thermostat will maintain cooking temperature just like your indoor kitchen oven does. As a safety feature, the meat probe can be set for your desired target temp. When the internal meat temp rises to within 10°F of the target, the controller automatically drops the smoker down to 170°F (77°C) to avoid overcooking.
The seventh pellet grill to achieve its place in our pellet grill review is the YOYO wood pellet grill and smoker. It is a 679 square inch griller (1 cooking surface) with 2 level cooking levels surface. This pellet grill weighs 170 pounds. It maintains temperature from 180 degrees to 475 degrees Fahrenheit. Another feature of this pellet grill is that, it has a digital thermostat controller and comes with the assembly tool kit included.
One of the most outstanding features of this smoker is its digital thermostat controller. It is also small enough to be used for family gatherings but large enough to be used for tailgating parties. With it’s 292 in.² of cooking space, you can cook a lot at one time. The entire cooking surface is 15 x 20″. It is made from steel and has a porcelain coated grilling grate.
First impression was this thing isn't built like a mass produced unit, it's more like something you would expect from a master fabricator. The assembly instructions were incredibly detailed, and the way it was packaged made it really easy. It takes a little time to get temp steady for low smoking, but once it's there it seems to be pretty steady. So far absolutely impressed with everything about this cooker, and made in the USA!!!
I had to cancel my order today. I called this morning, however no one at their office could provide a satisfactory answer or response to my order. I actually was asked to provide a second copy of the invoice pink slip which I had already done so. Very disappointed with your company's sales rep that sold me the smoker at the Timnath Colorado store location. She guaranteed that the grill would be shipped out in three days and I would receive it before Easter, my daughter's birthday weekend for a party.
I am currently using a Bradley Smoker, which is basically an electric oven with a smoke generator that makes tons of smoke, using special Bradley Smoker pucks (of compressed saw dust). A tall cylinder hold a stack of pucks, and the smoke generator pops a new puck into the oven every 20 minutes or so (when the pucks are about 80% burned). Managing temps is not as difficult as a stick burner, but nothing like advertised with these pellet burners (like the Rec Tec).
×