I am currently using a Bradley Smoker, which is basically an electric oven with a smoke generator that makes tons of smoke, using special Bradley Smoker pucks (of compressed saw dust). A tall cylinder hold a stack of pucks, and the smoke generator pops a new puck into the oven every 20 minutes or so (when the pucks are about 80% burned). Managing temps is not as difficult as a stick burner, but nothing like advertised with these pellet burners (like the Rec Tec).
But even with their indirect heat, wood pellets do something gas can’t; they give your meat that natural, smoky flavor you expect from wood. They don’t create as much smoke as wood or charcoal, so the flavor is not as intense, you swap that intensity for convenient cooking. The smoke they do create is clean and easy to control. And the hotter you burn pellets, the cleaner they burn, letting you crank up the heat when you don’t need smoke.
Turn it on to "Smoke" mode and use the P settings, or cook mode by selecting a temperature. When you select smoke or a temp setting you start the ignition sequence. The fan, igniter and auger motor turn on. The fan stays on until the smoker is turned off. The auger motor continuously delivers pellets to the red hot igniter rod in the firebox for two minutes under normal conditions. Then the igniter rod shuts off and the pellet fire burns with only the assistance of the auger and the fan.
PID Controllers - The most sophisticated type of pellet grill controller, PID controllers use complex algorithms to achieve and maintain the desired temperature within a few degrees. They, too, feature LCD display and one-touch buttons for setting the temperature in 5° increments. However, unlike controllers that use fixed cycles, a PID controller continuously measures the grill’s temperature then adjusts its cycle, adding pellets when necessary to hold the correct cooking temperature throughout the cook. Because they’re more sophisticated, PID controllers can accommodate programmable meat probes that have the ability to automatically lower the grill’s temperature when food is done.
*Big R strives for accuracy in our advertising, but errors in pricing, photography, and/or description may occur. Big R reserves the right to correct any such errors. Photography is for illustration purposes only and may not reflect actual product. Big R reserves the right to limit quantities ordered and the right to accept or decline any E-Commerce order.
Got my Camp Chef Smoke Pro SE four days ago. My son and I put it together, it is a two person job because it's heavy. Seasoned it and smoked two chickens that turned out awesome! Today I have hamburgers on. Smoking on low smoke for half an hour, take them off and crank it to 450 put em back on and grill till done. Easy to use. Very happy so far. Just hoping it holds up!
I brought my YS640 to Mexico on a friends recommendation, he was right. I takes the complexity of smoking away but this is not the reason why I got it. We live in south of the Sonoran desert and we are over the 100F most of the year, its almost impossible to stay close to your smoker to watch the fire and temperature. Plus, wood is not as easy to get in the desert. Since I got it, I have been selling food on Sundays, I was sold out since day one. Flawless food time after time. I am planning to get the old time offset cooker to smoke in the winter just for fun. There is really no need for it.
With modern advances in the outdoor cooking appliances due to their high demands, you too can cook up a great BBQ spread now with the help of a pellet grill! Gone are the days of overcooked and burned steaks. With the pellet grill on your backyard, you can BBQ to standards that even pit masters will approve. So today I will be giving you a 101 class on pellets grills, also including a list that will provide you with some great pellet grill review so that you can make the right decision when deciding to purchase one for you and your specific needs.
Thank you so much for this very informative post!! My husband and I just bought the Traeger Select Elite Pellet Grill On Cart yesterday as a somewhat impulsive buy on a Costco shopping trip. It was the last day in the road show so I figured we could always return it if we have buyer’s remorse. Having no past experience with pellet smokers/grills, I am doing my due diligence in researching the reputation of this company and comparing to others in the market. The selling point for us with this particular Traeger grill was the ability to convert this to a built in unit by simply taking off the right side shelf. The sales rep at Costco had a picture of one that his parents had built into an attractive brick surround and we liked the option, however, after reading your post and several other sites, I am finding that Traeger may not be the best investment comparatively and with a purchase this expensive, long-term quality is extremely important to us. In staying within the same price range, I am very interested in the Rec-Tec and it’s stainless steel build. My question is, do you know if the Rec-Tec or another pellet grill @ the $1000 price point can be made to look “built-in” and if so, are there any dangers or potential problems with this.

Louisiana Grills was one of the first companies to muscle in on Traeger's one-brand show. The smallish CS 450 is one of its more popular models. In 2014, Louisiana upgraded all of its pellet smokers to include digital touch-pad controllers with integrated meat probes. Set it and forget it; the thermostat will maintain cooking temperature just like your indoor kitchen oven does. As a safety feature, the meat probe can be set for your desired target temp. When the internal meat temp rises to within 10°F of the target, the controller automatically drops the smoker down to 170°F (77°C) to avoid overcooking.
In some ways, it’s surprising that something so small could be the culprit behind so many problems on a hi-tech cooker like a pellet grill. Then again, pellets are your grill’s fuel and using bad pellets is like using subpar charcoal in a kamado, and it can cause the same problems—too much ash is produced, making it hard to hold a steady temperature and snuffing out the oxygen supply to the fire.
When looking at a pellet grill also consider the material its made from. A majority of pellet grills on the market are made from painted steel. However, the quality of that steel and the paint can vary. A good high-temp powder coat paint can stand up to high heat without blistering or flaking. This is essential, because once the steel is exposed, it will rust. Even if the grill body is painted well, you have to look inside. The fire pot and diffuser plate have the potential to corrode and are two of the most common parts that need replacing. With some painted steel grills, such as Traegers®, you can can upgrade the grill and hopper lids to stainless steel, as well as the firepot, diffuser, and drip pan.
In addition, due to the wood pellets used in the Traeger grill, it is easy to cook different food products even pies, something that is impossible with charcoal or propane fired grills like the big green egg grill and the camp chef grill, respectively. Moreover, it is hard to get consistent results with the big green egg grill, as some food might come out good while others will just burn. It is a great challenge to use the big green egg grill.
I'm a certified BBQ Judge and found the following; The new portable Traeger Ranger seems to be not well thought out. All the cooking directions are for the large units and over cook everything in the smaller unit. All the pellet smoke is wasted, it is drawn out the back vent and very little ever reaches what you're cooking. They have a grease bucket on the back that is supposed to catch the grease but doesn't, Grease coats the inside of the bbq and runs down the sides and out of the grill landing on whatever you have the grill on. I've been using this Traeger Ranger since June 18, 2018.
My traeger has had some good moments but it very unreliable.  I really do not enjoy cooking with it.  I have no confidence in the temp readings and the smoke control.  Every time I open the lid the temp drops like 200 degrees.  I'll smoke at the "smoke" setting but as soon as I turn it to 225 it spikes to like 300-500 degrees. Wtf?  I thought this POS was supposed to be a set it and forget it type smoker.  Very unreliable.  Temp fluctuates so much and if there is even a slight breeze the temps just go up and down up and down.  The pellet feeder is garbage.  It will all the sudden just start smoking like crazy because the pellets have jammed into the burner.  Completely ridiculous smoker.  I use it still but only when I can sit and watch the feeder.  The guys comment below is true about the feeder always just using the middle pellets.  I always have to check it and push the pellets to the center.  Some simple engineering would change this. Never again will I purchase a traeger. There are much better options out there and better price.
The Green Mountain Grills Davy Crockett smoker lets you get more than what you paid for. At a surprisingly low price, you get to have tons of great features that are sure to elevate your BBQ experience. For its price, we were quite surprised to see that it satisfied most of the features on our review. We tested over fifty products, and even the expensive ones were no match for this product. In terms of value per dollar, this product deserves the top spot.

With over 375 reviews, this product had an impressive review rate. On its first 22 days, it got its first 10 positive reviews. Ten days after, it got its 2nd set of 10 positive reviews, and its 3rd set of 10 positive reviews after seventeen days. Online reviews have shown that, just like us, customers have been satisfied with the overall performance of this smoker from Traeger.
With that said, we can guarantee that all of the grills on this list are designed from the best quality materials and design elements to ensure that it not only lasts the test of time, it is safe to use, easy to set up, and also designed to cook the best meals possible. With that said, let’s talk about a pillar that has added to the quality criteria, the material design.
***Update: 11/2014: It's been a year now and I still adore this little grill. I've got a kamado and 3 different kettles and this is by far the most convenient and easy to use. The smoke rings this guy puts on a brisket are amazing and the flavor is the perfect balance of wood flavor without overpowering the meat. I've researched about 15 different pellet grills and I still can't find a better value than what this grill offers

Multi-position Controller - A step up from 3-position controllers, multi-position controllers feature a knob with temperature settings that go from 180°F to 420°F in 25° increments and may have an LCD display. In addition to more settings, these controllers offer more temperature control. However, they also run on fixed cycles and can only maintain about +/-20°F in ideal conditions—in cold windy weather they are less accurate and reliable. Some versions of these controllers have inputs for meat probes that can monitor food temperatures.
Keep your Pellet Grill and Smoker fired up Keep your Pellet Grill and Smoker fired up with Camp Chef’s Premium Hardwood Pellets. Made of 100% natural hardwood these food grade pellets are an excellent way to add that unique smoky flavor. Choose from 4 distinct flavors. Smokehouse Hickory impart a rich and smoky bacon-like flavor to all meats ...  More + Product Details Close
×