Bigger isn't necessarily better, especially if you're just paying for space you never use. The best pellet grill is the one that suits your needs. For an average size family, a pellet grill with a primary cooking area of 450-500 square inches should be sufficient. Singles and couples can go smaller, while larger families and those who like to entertain should consider larger pellet grills.

This maker of top-quality wood and pellet grillers is the company spearheading the digital revolution in the pellet smoker industry like its digital controller that manages pellet flow to control internal temperature and WiFi that connects your phone to the grill, allowing you to use it to control your grill for good measure. It’s the more gimmicky of the different pellet grill makers.
A pellet grill is an outdoor cooker that runs on electricity. It uses wood pellets as fuel to cook as well as smoke and flavor the meats. A pellet grill is a combination appliance of grills, smoker, oven and more. It can be used to sear, smoke, grill, roast and even bake! A pallet grill can be used to cook almost all types of meats and proteins. It also accommodates larger quantity and size than a normal indoor appliance. This is what makes a pellet grill so special, its versatility and convenience of use.
Thank you for a very comprehensive review and all the helpful advice. I would like to know your thoughts about having the burn pot in the center area as in the Rec-Tec, or on the side. My only interest is smoking, not grilling, and I prefer even heat throughout the cooking chamber. How much difference does the location of the burn pot make? Thank you very much.
It comes with some unique features, such as its proprietary “Sense-mate” technology that uses a thermal sensor to monitor the ambient temperature. If used in a cold weather, this grill fires up the turbo mode so you won’t have to wait for it to heat up before you start using it. It comes with “fan-only” mode to blow off the ash and automatically clean the grill once it has been shut off.
Wood pellets are an all natural product. No petroleum products in them, no fillers, chemicals, or binders. They are an excellent source of smoke flavor and compact energy, 8,500 BTU per pound. No hot coals, no flareups. There is also very little ash: 10 pounds of pellets will produce about 1/2 cup of ash. All the rest is converted to energy and combustion gases. I clean out the bottom of the ones I tested after about 10 cooks. At high temps there is very little smoke, at low temps the pellets smolder and produce superb but understated smoke flavors. Click here for more about pellets.

The Green Mountain Grills Davy Crockett is a versatile, wood-pellet grill that is intended for portability. Regardless of its weight, it’s about as minimized as you can get, and takes care of business. Contrasted with more costly wood pellet barbecues, it appears to hold its own on performance, while the one of a kind Wi-Fi usefulness needs some finish.
I have owned my YS640 for about 9 months now. Before I bought this I researched smokers/grills for about 2 years because I had very little experience with them & cooking in general. With the help of a few good websites I have produced some great food. There is a ton of room to cook on & the heat stays pretty much where you want it. Only a few issues I have had is that where the stack mounts to the side of the grill it drips. I did have a scratch on mine from the shipper & when I called about it I was sent a can of matching high temp paint very quickly. One thing that I like the most about this smoker is it is heavy. You can tell that this thing was built to last.
Bigger isn't necessarily better, especially if you're just paying for space you never use. The best pellet grill is the one that suits your needs. For an average size family, a pellet grill with a primary cooking area of 450-500 square inches should be sufficient. Singles and couples can go smaller, while larger families and those who like to entertain should consider larger pellet grills.
So which pellet smoker is worth your hard-earned dough? We've put together a list of the ones we think make the cut, organized from lowest to highest price. Sorry for the sticker shock—even a low-priced pellet smoker will cost more than many grills, and our first selection lists at $333. These motorized, digitally controlled devices just plain cost more, but believe you me, they are worth it! And all of these selections have won the AmazingRibs.com Best Value Gold or Silver Medal.
PID Controller–PID Controllers (Proportional Integral Derivative) are devices that most of the grill manufactures don’t fully utilize yet. They can be found as a separate device attached to the grills if you’re handy enough, but all the manufacturers aren’t fully considering them yet. Using a PID controller, you can accurately maintain the temperature while cooking and ensure that the food is cooked automatically to perfection without much supervision.
This smoker is one totally awesome product. It is more that just a smoker, it is a true convection oven, we have baked bread in it! As for being able to hold the temp for low and slow, wonderful. The beef that I smoked was delectable. I just this week smoked 10 venison loins at the same time; it took 1 hour for the most tender, delicious venison I have ever tasted!
In true Yoder fashion the 640 is not a fancy cooker with lots of shiny things, bells and whistles. Don't mistake that for poor craftsmanship, the Yoders are all built to the highest quality standards. They just happen to be more muscle car than sports car. Big, bad ass, built to last American muscle car that will blow the doors off the competition on your back deck or on the comp trail.

Hey Jennifer, I think a pellet grill/smoker would make a great addition to your cooking arsenal. You can get a pellet smoker up to 450 degrees in about 10 or 15 minutes. The following article gives you a good idea of what you might do to reverse sear a nice thick steak using a pellet smoker. note, that this method employs the use of GrillGrates, which you can find easily on Amazon. Here’s the article:http://blog.greenmountaingrills.com/rib-eye-reverse-seared/


Not all people and culture will be able to truly understand our love for barbecue here in the USA. For them, it might just be a cooking activity while for us, it’s a tradition – a ritual to celebrate the summers (and occasionally the winters). As long as this love for grilling stays with us, which will be, we’re going to continue to expect more and more from the grill manufacturers.
There are several types of grills and these are charcoal, gas, wood, electric smokers, open fire grill, and pellet grill. Each of them offers different benefits. In terms of comparison, pellet grill is still superior because it is the combination of all such grills. You can use it to smoke that way charcoal grill does. You enjoy the wood flavor of wood grill using pellets, and it is also electrically and electronically-operated.

Auger Making Weight Noises: It’s usually indicating a problem with the motor that’s responsible for rotating the augers. Under such circumstances, you would be left with no other choice than to replace the motor completely. Since the motors and augers are usually packaged together, this can get quite expensive. In such scenarios, it’s better to let it make noises and run for as long as it would serve you before going to replace it. However, once that problem occurs, you’d often find the auger not feeding the pellets at the expected rate and thus, the desired temperature might not be reached in some cases.


You want your smoker to retain heat and to maintain a constant temperature. If you purchase something that’s inexpensive, yet made with a thin metal, you’re going to regret it because you’re going to be constantly fighting with the temperature. You could purchase the best smoker pellets, but if you don’t have a high quality smoker, it is all for not.
I did a lot looking around at pellet smokers before buying the ys 640. This thing is amazing! I have been cooking BBQ for about 15 years. I owned a Gator pit entertainer which is made in Houston Texas (stick burning pit) and I currently own a $25,000 Ole Hickory Pit EL-EDX which can cook 700 lbs of BBQ at once. I wanted something smaller to cook for family. The ys 640 turns out PERFECT Q every time! The amount of smoke is just right. Plenty of smoke flavor without over smoking which is very easy to do in my other pit. This is an EXCELLENT product which I strongly recommend.
The great part about this smoker is that it is fairly light-weight, weighing in at 69 lbs, and its legs double as handles: all you have to do is fold the legs up and carry the smoker wherever you need to! Furthermore, this smoker comes with a 12V connector that you can plug into the cigarette lighter of your car, and a 12-foot alligator clips that you can connect to your car’s battery if necessary. You can take this smoker anywhere!

If you have faced or currently face the problem with common things like pellet feed jamming or wear and tear of your smoker, then replacing the exact component will solve your problem. Thus, without changing your whole smoker you can continue with some $40 – $50 changes. It might seem complicated for you if you face a problem with your digital control system. Adding the element of professional knowledge will help tremendously. Solving problem with $150 is much better than spending $500, right?

Hey Mike, thanks for touching base. It’s always a pleasure to connect with you, man! If you have the space, I’d go with the JB. You can always cook under your pellet smoker’s capacity, but you can never cook more than it will hold! As such, you can always find use for the extra room in the JB. It’s like the umbrella and the rain scenario – bring one and you’ll never need it. Go out without one, and it’ll pour on you! Holding temp and managing the cook is the same for each of these GMGs. You’ll have smooth going with both, I’m sure. If you are cooking in very cold temps, you might want to consider the thermal blanket GMG puts out. Helps a bit re: getting to / maintaining temp. Some folks use it all the time as they feel it keeps more smoke in the chamber. As you know, nearly all pellet smokers produce a bit less smoke than your barrel smoker will. Hope this helps, bro! Thanks for your comments!
Most old-timers will tell you that a buildup of soot and grease will improve the taste of your food. This does not prove true, in fact, it’s not good for you and can even be dangerous. At Grills Forever we want your grilling experience to be the best and safe. Therefore, before any cooking session, always clean your grill to optimize its performance and prevent any off-flavors. Check the grease pans or collectors before smoking because the collector could be full and overflow, starting a fire. If there is a grease chute then clean it for sure.
In some ways, it’s surprising that something so small could be the culprit behind so many problems on a hi-tech cooker like a pellet grill. Then again, pellets are your grill’s fuel and using bad pellets is like using subpar charcoal in a kamado, and it can cause the same problems—too much ash is produced, making it hard to hold a steady temperature and snuffing out the oxygen supply to the fire.
Thank you all for a great site and an informative discussion. I am a newbie to smoking and presently have a charcoal grill for when I have more time and a gas grill for a fast meal. Its time to replace my gas grill so I am looking at alternative options. Is a pellet grill overkill, or a timely expedition, if I want to grill a couple steaks or chicken breasts during week nights? I’d also be interested in smoking larger hunks of meat (and ribs!) less often, but am wondering if a pellet grill can cover both? How long does it take a pellet grill to get to temp (e.g. 450°)? With the indirect heat, can you get char marks on your meat? Thanks in advance for the info!
This is the single main advantage of a pellet smoker. Unlike charcoal, gas or wood fired smokers you don’t need to do anything with fuel except make sure it’s full when you start. This means no more having to go back and check fuel levels, no fluctuating temperatures, no spending ten minutes setting up charcoal and getting it at the right temperature, and no random heat variance giving you oddly cooked food ’cause you set it all up wrong.
The wifi functionality displays both the temperature of both the grill and meat probe, using the same on your smartphone app you can tweak it according to your needs. The App also lets you set up profiles which you can configure once and use in the future as well. This adds a great accessibility feature that none of the big smokers have comparatively.
An electric smoker and a pellet smoker, according to the reviews, both allow you to set the temperature and walk away. However, the flavor that you’re going to get from a pellet smoker is a lot stronger as compared to an electric one. Pellet smokers allow you a little bit more versatility than an electric smoker, whereas electric smokers are better at maintaining and controlling the temperature inside the cook box.
Hey Rob! First, I really appreciate you reaching out. That’s what The BBQ Beat is for! To your question, I own a Davy Crockett Tailgate Model pellet smoker and really like it. Full disclosure, it was given to me by the company to test and Jason Baker of GMG said I could just keep it. But, I get a good number of products to review sent to me and a whole lot of them don’t make it onto the blog. I’d rather “omit” than “detract” – keep things positive sharing the stuff out there that I can get behind.
You like the idea of cooking different types of foods on the grill: If you’re someone who wants to grill food other than meat, the Traeger grilling system gives you this option. With the precise temperature control of the Traeger, cooking things like fruit pies can be a successful endeavor, something you wouldn’t dare try with a propane-fired grill.
Pellets are available from a number of sources because they are popular for use in home heaters, so if you are worried that you will be buying a gizmo that might be worthless someday if the pellet supply runs out, it is unlikely. As more and more pellet grills appear, and word of their excellence spreads, sources for pellets will become numerous. I've even heard of a few Home Depot's carrying them. The bad news is that I have tried several brands and I always return to BBQr's Delight. They seem to have the least sawdust, so they are less likely to clog the auger, and they have a higher percentage of the flavor wood on the label.

Remember, you are paying for every little feature, attachments and details on any product. So do not end up paying you inheritance for a feature that you are probably never going to use. Instead, invest on a pellet grill that caters to your needs and has features that will actually enhance your experience when using it. So do not, I repeat: do not, fall for fancy marketing features that sound too drastic.
I had an American made Traeger for 6 years and after it rusted out I was looking something built for the long haul. The YS 640 is it. Built like a tank it will hold up for years and the extra steel helps retain the heat. Temperature control is spot on and recoverey after opening the lid is amazing. I thoroughly researched all my options and I could not be happier. I cooked steaks the other night in 40 degree weather and had no issues whatsoever. The grille grates are a must and leave beautiful lines. Before you buy anything else, investigate what the other cookers are made of. There really is no comparison.
Hey Charlie – I’d leave that grate wide open if you want maximum heat. If the grates are only over the burn pot, then you can do sort of a two zone cook (indirect vs direct heat) by putting a thicker steak, chop, or piece of chicken on the ‘non direct’ side to get up to a temp that’s 15 or 20 degrees lower than your target. Then, finish off over the burn pot area. Just one idea.
Hello John. Thank you for your comment and questions here! In short, you will not get the same smoke profile on a pellet smoker that you do with your BGE or PBC. That said, I do think there are some ways to mitigate this. Yes, I do feel the Smoke Tube and Mojo Cubes add smoke flavor that is detectable. Fred at Mojo Bricks does good work, and I recommend his products without reservation. This said, I have been happy with the smoke level I see in the pellet smokers I’ve used. Starting low does and ramping up later is a technique I’ve used with success when extra smoke is desired. The Rec-Tec grill gets high reviews across the board. I have no hesitation backing them, along with Green Mountain Grills. Both are made in China, but the companies have great customer service support and strong user communities. I believe each has a well-contributed Facebook group or two.
Another video I thought it’d be cool to show you guys is one that features BBQ Diva as she shares her thoughts about how Fast Eddy’s Pellet smokers work with BBQ Ribs. You’ve likely read the Diva Q DIY BBQ Sauce post we highlighted here. And no doubt you know about Danielle’s work with the now famous BBQ Crawl television series. Without question, she’s one of BBQ’s greatest treasures. Check out what she says here about Fast Eddy’s. The video starts out with Ed Maurin showing you the recipe he used for the World BBQ Championship Perfect Score Ribs in 2000 – using both baby backs and spares. Diva chimes in near the end with her take on how these ribs taste.
×