I believe the little Green Mountain Davy Crockett is the best portable pellet smoker currently on the market. Surprisingly, many of the portables out there still have an antiquated LMH controller, while Davy Crockett employs Green Mountain's advanced digital touch-pad controller, with an integrated meat thermometer that lets you check internal meat temp with the flick of a switch. Furthermore, it includes adapters to run the electronics from your car battery or cigarette lighter. And Green Mountain is aggressively—ahem, hello, price cut—promoting its WiFi capabilities, which enable you to monitor Davy Crockett from your smartphone or laptop.
I have several smokers I have used over the years. I have dialed in everyone I own over a course of trial and error. They all get great results, but require me to tend them all throughout the cook. I wanted a smoker that I could easily get to the desired temp, maintain the temp, provide good smoke flavor, and have the size to do a small or large cook, and not need me to be tending it throughout the cook. The learning curve on this smoker is super easy if you know all your temps, your first cook will give you the results your looking for. I was a little worried that I was not going to get the smoke flavor with a pellet smoker, but my brisket turned out amazing, very tender, the smoke ring was perfect. When I was searching for a new smoker I was a little shy of the Yoder based on the price, but when you figure in the ability to grill as well this became a better alternative. The quality is top tier, this is built to last a long time. I'm so glad I went with the Yoder YS640 no regrets.
The Ortech has two knobs. The large one, the "Cook Control" has settings for: Off, Smoke, 180, 225, 250, 275, 300, 325, 350, 375, and High. One smoker manufacturer says that the "Smoke" setting is about 160°F and "high" is about 525°F, but both can vary due to ambient temperature, humidity, fuel type and quality of the smoker. Another knob, a teensy weensy knob to the right of the LED screen looks more like a push button. Labeled "SMOKE" and called the "Smoke Control Knob", it is meant to turn, not push, and it controls the pellet feed rate with auger on/off sequences indicated by "P settings". The P settings range from P0 to P15.
An attractive option for many people are stainless steel pellet grills, which are rust-resistant, more durable, and easier to maintain. While pellet grills made from commercial-grade 304 stainless steel are the most desirable, they come at a higher. However, there are also some pellet grills made from 430 stainless steel, which is more affordable and still incredibly durable.
REC-TEC, also known as Rec Tec, has been in business for more than 7 years. Its pellet grill offers up to 702 square inches of the cooking surface real estate, beating out the Pit Boss and its 700 square inches by (only) about 2 inches of extra space. Its grills can also calibrate themselves in 5° increments and its pellet hopper is capable of holding 40 pounds of pellets (no constant refills required).

A portable offering from Green Mountain Grills, the Davy Crocket is the most affordable pellet grill on our list, and the only one with WiFi capability. It’s compact, weighs only 57 pounds, and has folding legs so you can pack it up and bring it camping, tailgating, or to the beach. That’s something you can’t do with the Traeger Pro 22, and something we’re really excited about.


First impression was this thing isn't built like a mass produced unit, it's more like something you would expect from a master fabricator. The assembly instructions were incredibly detailed, and the way it was packaged made it really easy. It takes a little time to get temp steady for low smoking, but once it's there it seems to be pretty steady. So far absolutely impressed with everything about this cooker, and made in the USA!!!

Your choice of the pellet can also dictate how much cleanup you’ll have to deal with (even though generally 10 pounds of pellets can produce at most half a cup of ash, but this varies from pellet variant to pellet variant). Just be warned that when the temperature is high, there’s not much smoke happening, so you need to smoke out your meats at lower temperatures to get that smoky flavor.


Turn it on to "Smoke" mode and use the P settings, or cook mode by selecting a temperature. When you select smoke or a temp setting you start the ignition sequence. The fan, igniter and auger motor turn on. The fan stays on until the smoker is turned off. The auger motor continuously delivers pellets to the red hot igniter rod in the firebox for two minutes under normal conditions. Then the igniter rod shuts off and the pellet fire burns with only the assistance of the auger and the fan.
The Pit Boss Grills 340 Wood Pellet Grill is a great grill with dial-in digital control and led read-out. Pellets are 100% natural hardwood. This grill has got an automatic start and cool down. It’s heavy duty with 16 gauge steel construction. It’s easy to assemble. It’s a little expensive. However, other grills are more expensive and seeing that I would recommend this to anyone.
*Big R strives for accuracy in our advertising, but errors in pricing, photography, and/or description may occur. Big R reserves the right to correct any such errors. Photography is for illustration purposes only and may not reflect actual product. Big R reserves the right to limit quantities ordered and the right to accept or decline any E-Commerce order.
I had hung my hat on the Yoder and had even contacted the factory and a couple of distributors in the DFW area. Then I did my usual, search craigslist and see if anyone is moving and selling their unit. Low and behold a Memphis Pro!!! Story was brand new, bought for a built in and now cannot use it now. Brand new but you may not have a warranty though. Price… wait for it! $1600!!! You got to be kidding! Scam?? Ok well I will contact him. Surprisingly he had it advertised for a few weeks and only had a few contacts but none serious. Ok, I will come look and if you can plug it in and show me the controller works I will take it. Called the factory and they were quite responsive. They said we probably won’t warranty the controller because we don’t know the history but it will depend on the failure. Everything else we will cover. So right before Thanksgiving headed to Dallas and it basically all looked brand new, plugged in and it did everything you could do without burning pellets.

Ok, so where do I start..... Last September or so, I bought my Traeger at the local Costco during one of the Traeger road shows. I heard wonderful things about them. Did the research, they are pricey, but decided to take the plunge and plop down the $750.00 for a new grill and a couple of bags of pellets. Assembly was way harder than the Traeger rep told me it would be. It took me about 4 hours start to finish to get it assembled. Once assembled, I did all the break in "burning" and we made our first meal, a whole chicken. I have to admit, it truly was yummy! Then over the next couple of months we made 4 or five other meals with it and we we actually very happy with the results. Then came the holidays...... We made one of the Ham recipes from a Traeger cookbook. About half way through the process I looked outside to see my grill totally engulfed in flames. I shut the grill down and fortunately salvages most of the ham for Christmas dinner. The grill itself was about 60% destroyed. I called Treager the next day just to find out what happened. The customer service guy way REALLY nice. He said, "Don't worry. We stand behind our product 100%." Wow was I impressed! He told me he would email me instructions on how to make a claim. He even told me he would send me a new thermometer ( my Christmas present one was destroyed by the fire). He did everything as promised! Now, jump ahead to my actually trying to get my Traeger replaced. Per the email, I called Traeger customer service expecting the same service I received right after Christmas. NOPE! I spoke with Frank (Carson) I believe. He did everything from accuse me of shutting my grill off and turning it back on incorrectly (impossible since I was in the house) to not cleaning my grill. Neither of which were correct. He basically made me feel like my grill was unsafe! His attitude was HORRIBLE! He was rude and condescending. A nightmare to work with! I did not get my grill issues resolved until I spoke with his boss Andrew. Way more than I felt was necessary. Fast forward to today. Finally got my new Traeger running again. Had an issue with the smoker temperature. So I called the toll free Traeger customer service line. Low and behold, who answers my call at Traeger customer service? Frank! He is still nasty and ended the conversation with "Hopefully you do not burn your grill up again!" Nice guy! Dude, being a smart aleck didn't exactly earn you any points. You should be ashamed of your self! Bottom line: Love my Traeger. But customer service person Frank is HORRIBLE to work with! Everyone else there is so nice. Why on earth do they keep someone who is supposed to be helping customers, when he has such a horrible and nasty disposition. I will keep my Traeger but hope I NEVER have to speak with Frank again. One star for him!

Retail pricing for the Traeger Grills Pro Series pellet smokers come in at $799 for the 22 in. and $999 for the 34 in. At this time, they’re available only through approved Traeger retail locations. If you’re in the Central Florida area, Whiskey Bent BBQ Supply in Lakeland, FL is a Platinum Traeger Dealer. Otherwise, you can find a list of approved Traeger dealers via their network locator page.
Ok, so where do I start..... Last September or so, I bought my Traeger at the local Costco during one of the Traeger road shows. I heard wonderful things about them. Did the research, they are pricey, but decided to take the plunge and plop down the $750.00 for a new grill and a couple of bags of pellets. Assembly was way harder than the Traeger rep told me it would be. It took me about 4 hours start to finish to get it assembled. Once assembled, I did all the break in "burning" and we made our first meal, a whole chicken. I have to admit, it truly was yummy! Then over the next couple of months we made 4 or five other meals with it and we we actually very happy with the results. Then came the holidays...... We made one of the Ham recipes from a Traeger cookbook. About half way through the process I looked outside to see my grill totally engulfed in flames. I shut the grill down and fortunately salvages most of the ham for Christmas dinner. The grill itself was about 60% destroyed. I called Treager the next day just to find out what happened. The customer service guy way REALLY nice. He said, "Don't worry. We stand behind our product 100%." Wow was I impressed! He told me he would email me instructions on how to make a claim. He even told me he would send me a new thermometer ( my Christmas present one was destroyed by the fire). He did everything as promised! Now, jump ahead to my actually trying to get my Traeger replaced. Per the email, I called Traeger customer service expecting the same service I received right after Christmas. NOPE! I spoke with Frank (Carson) I believe. He did everything from accuse me of shutting my grill off and turning it back on incorrectly (impossible since I was in the house) to not cleaning my grill. Neither of which were correct. He basically made me feel like my grill was unsafe! His attitude was HORRIBLE! He was rude and condescending. A nightmare to work with! I did not get my grill issues resolved until I spoke with his boss Andrew. Way more than I felt was necessary. Fast forward to today. Finally got my new Traeger running again. Had an issue with the smoker temperature. So I called the toll free Traeger customer service line. Low and behold, who answers my call at Traeger customer service? Frank! He is still nasty and ended the conversation with "Hopefully you do not burn your grill up again!" Nice guy! Dude, being a smart aleck didn't exactly earn you any points. You should be ashamed of your self! Bottom line: Love my Traeger. But customer service person Frank is HORRIBLE to work with! Everyone else there is so nice. Why on earth do they keep someone who is supposed to be helping customers, when he has such a horrible and nasty disposition. I will keep my Traeger but hope I NEVER have to speak with Frank again. One star for him!
Have you reviewed at all the Grilla Silverbac? If so, does it not make your list because it isn’t as good a quality as those you have picked? I mean, when I look online for reviews of those who have bought them I haven’t found anyone disappointed with theirs, but perhaps they haven’t been out as long to have a track record? I’m so confused at this point as to which to buy with PID or no PID (some say smoke does better without one), thickness of metal, etc.

I brought my YS640 to Mexico on a friends recommendation, he was right. I takes the complexity of smoking away but this is not the reason why I got it. We live in south of the Sonoran desert and we are over the 100F most of the year, its almost impossible to stay close to your smoker to watch the fire and temperature. Plus, wood is not as easy to get in the desert. Since I got it, I have been selling food on Sundays, I was sold out since day one. Flawless food time after time. I am planning to get the old time offset cooker to smoke in the winter just for fun. There is really no need for it.
Hello John. Thank you for your comment and questions here! In short, you will not get the same smoke profile on a pellet smoker that you do with your BGE or PBC. That said, I do think there are some ways to mitigate this. Yes, I do feel the Smoke Tube and Mojo Cubes add smoke flavor that is detectable. Fred at Mojo Bricks does good work, and I recommend his products without reservation. This said, I have been happy with the smoke level I see in the pellet smokers I’ve used. Starting low does and ramping up later is a technique I’ve used with success when extra smoke is desired. The Rec-Tec grill gets high reviews across the board. I have no hesitation backing them, along with Green Mountain Grills. Both are made in China, but the companies have great customer service support and strong user communities. I believe each has a well-contributed Facebook group or two.
I store it in the Camp Chef cover. It takes about a minute to pull the cover off, install the gas cylinder and side tables, move it into cooking position on my deck, and light the burners. It doesn't take much longer to clean up. After getting the griddle back up to high temperature for cleaning, the active work of squirting, scraping and wiping down takes just a couple of minutes. After cool down, removing the gas tank and side tables (which fit nicely on top of the griddle for storage) and putting the cover on takes another a minute.
If you get it that BBQ is more than burning hotdogs on a propane grill, you could likely benefit from The BBQ Beat podcasts. Kevin interviews the best Pitmasters in the country. They share their knowledge, stories, and experiences. There is something to be learned in each podcast. So if you're serious about your bbq, check out these podcasts. They are time well spent.

When you have owned your smoker grill for 5-6 years you start wondering if owning a new one would be the best idea. This might happen because you are facing problems with your machine and not getting the desired result. The first and primary advice in this situation remains to clean up your grill thoroughly. Open up each and every part then proceed to doing a thorough cleaning. Most of the problems like temperature inconsistency or jamming will get solved this way.


Meanwhile, it also has a 15-pound pellet capacity comparable to Camp Chef SmokePro (not as large but big enough to eliminate continuous wood pellet refills) and folding legs for better portability. However, certain users who’ve already bought their own REC TEC Grills Mini Portable Pellet Grill have complaints about it, like inconsistent heat distribution of the grill and poor quality control (certain grills break down easily).
The Rec Tec Bull is built for serious smoking. The stainless steel chamber doesn't have paint that will chip or peel, and the built-in Wi-Fi technology allows you to monitor your cook from anywhere in the house. And with two meat probes you'll have more flexibility when cooking different types of meals. The 40-lb. hopper and interior LED are features the backyard pros will love.
Moving on from the orangish-red looks of the predecessor RT-680, this newer model has a black hood, with stainless steel built. It is 2.5” taller than the RT-680 and has 2 stainless steel bull horn handles on the outside that will have you falling in love with its built. Everything from the towel rings, the controller shelf, the hopper lid to the spill-proof bucket hook is stainless steel and even the smallest of details like the laser cutout of “Rec Tec Grills” on the side will never fail to impress.
The unique TRU-infrared technology cooks meat in an even way and helps to retain moisture. The great thing is there are no flare-ups. There’s a roasting basket for ribs, poultry, and other meat. The roasting basket can hold up to 25 pounds. The cooking area were grilling can be done has 180 in.². You can adjust the temperature, which ranges from 9000 to 18,000 BTUs, in the smoker box in order to add flavor.
Pellet grills are every lazy man’s dream appliance. These grills need absolute zero to minimal maintenance. You just need to lightly wipe through it after every use, and maybe thoroughly clean it 2 to 3 times a year! All pellet grills now come with a drip pan that catch the accumulating oils that drops from the food. They are also made with good quality raw materials that enable them to withstand the outdoor atmospheres all year round. If this does not entice your lazy bones, no other appliance will, and that is a fact. Period!
Number two when cooking with charcoal (yes plain Kingsford is good stuff if you do it right, a lot of the cheaper brick and cheaper lump can put some weird twangs in your food) brick or lump can produce quality high temp steaks or slow & low bbq! To add some nice flavor add some wood, but do your homework! I think Clark ‘Smokey’ Hale has one of the best books ever for the grill and Q master, “The Great American Manual on Grilling and BBQ or something like that. Last I saw you can grab a used one on Amazon for a few cents and some shipping. The most prolific thing I read in there that so many miss, is burn your wood and your charcoal to where it is literally a coal of gray ash covered glowing ember. Do that and you will find a new flavor in your cooking! Problem is so many places think heavy smoke is great, as they are trying to imitate cold smoke flavors! They are not the same! All this talk I see here about, “I want heavy smoke flavor.” I can tell you if you burn your wood and your charcoal (and I feel even lump needs to be well on it’s way to gray ash covered or you get bitter smoke even though many say not necessary) to a red ember with gray ash covering 80 to 90% minimum preferably completely covered your flavor profile will change. Many supposedly good bbq restaurants I have been in serve something with a bitter or ash flavor, which I find much less enjoyable.
The Smokepro comes with many of the extras that define the Camp Chef line of products, such as the easy-to-use ash removal system as well and an interior fan. This model comes with easy-to-use controls and an LED temperature readout so you can monitor internal temperature at all times, even if you're cooking at night. The unit also comes with a convenient meat probe for ensuring that perfect finish.

A smoking piece of juicy pork butt will just make your day. Not only does it smell good and taste good, the excitement of grilling and the anticipation of a good meal makes the experience even greater. But if you’re new to cooking and grilling, gathering the correct ingredients for a pork butt might be difficult. So, we’d rather simplify it for you with off the shelf products. If you’d rather make the rub yourself, check out our detailed guide.
Hey David, Is there a particular reason why the Grilla grills interest you? I tend to find they’re great smokers, just expensive for what they are. If you’re working with limited space (say smoking on a condo balcony) then the Grilla models vertical footprint can make all the difference between having a smoker or not. But for the price, and for a standard model smoker, the Traeger models tend to be better all around.
Product is decent but customer service really didn't help me out when they sent me a wrong accessory part that was ordered by their customer service department. Explained that the representative misunderstood my request for an inside shelf  but I was sent outer shelf which I have already . Tried to be fair and asked them to pay for the return shipping so I could return it back. They said we will gladly return your $ . Well till this day after numerous calls and false promises for the credit return .. there still is no refund. They seem to care but actually they did nothing. It's been 3 months of calling. Sorry to say we are Done with this company. If they can't settle a small concern and have A + service then don't bother! Good thing they are not the only smoker on the market. Shop around folks.
I got my YS640 for a combination Father's Day/ Birthday gift and regardless of whether it's grilling or smoking beef, pork or chicken the results have been outstanding. I can hardly wait to break out the turkeys for the Holiday meals. The direct grilling grates leave a steak with beautiful grill marks and the use of the fruit wood pellets along with quality steaks have made for some incomparable meals. As for quality of the smoker itself, I have sons-in-law that are already jockeying for position to try to be the next to have the YS640 after my demise - - - and we're figuring that won't be for at least 20-30 years!
I believe the little Green Mountain Davy Crockett is the best portable pellet smoker currently on the market. Surprisingly, many of the portables out there still have an antiquated LMH controller, while Davy Crockett employs Green Mountain's advanced digital touch-pad controller, with an integrated meat thermometer that lets you check internal meat temp with the flick of a switch. Furthermore, it includes adapters to run the electronics from your car battery or cigarette lighter. And Green Mountain is aggressively—ahem, hello, price cut—promoting its WiFi capabilities, which enable you to monitor Davy Crockett from your smartphone or laptop.
Editor-in-Chief Sean McCoy is a life-long outdoorsman who grew up hunting and fishing central Wisconsin forests and lakes. He joined GearJunkie after a 10-year stint as a newspaperman in the Caribbean, where he learned sailing and wooden-boat repair. Based in GearJunkie's Denver office, McCoy is an avid trail runner, camper, hunter, angler, mountain biker, skier, and beer tester.

Hey Jimmy, thanks for commenting here about your experience. I’m sorry to hear your experience was less than optimal. I have only cooked on the Traeger pro models. I do know that it is good practice to vacuum out the burn pot after cooks of a few hours or more. Not sure this was where your problems were initiated. Did you contact Traeger support? If so, what was their response?


Purchased my grill last fall at Costco, overall it works OK, some meats like Lamb Chops are just delicious. However, customer service seems to be deteriorating as the company is having success. My kids recently purchased me an add on to my Pro 34, a cold smoker. Traeger sells this but does not support it. The installation instructions are incomplete, I was sent parts that do not go with the unit, then customer service couldn't figure it out, this went on for weeks. After getting it installed, I asked for some instructions or recipes on how to use it, there are none. The old cover does not fit now, and Traeger does not sell one to go with a unit with a cold smoker, or plan on doing so. After a web search, I found one at Charbroil that kinda fits. Also, I just saw the same model at Orchard Supply, it now comes with more shelves and upgrades which I now have to buy as extras.
With the traeger, rec-tec or cam chef smokers all seem to burn 1-2lbs per hour. But for a long 18hr brisket it seems like I will have to continue to use pellets the whole time to keep the heat in range over over 200 which will mean I am using almost a 20-40lb bag depending on the time year per smoke. This is even more expensive than the bradley seems even with the wasted briquette. IS this correct or is there something I am missing?
I also was a certified KCBS judge but never judged at an event. Their judging system was flawed in my opinion because if you truly follow their system it is possible that them best tasting piece of meat might not win. In cutting horses (not a judge but read all the rules as I showed a fair amount back then) you were always supposed to judge the best overall horse to win. I asked about leaving a process to make sure the piece of meat you feel is best to win and was told absolutely not you have to judge presentation points, tender points & etc. and not place based on your opinion of the best piece of meat! Not that KCBS is a bad organization, it’s rules didn’t fit my thought process. Passed their class and got the t-shirt just never agreed, was always a spectator.
I purchased my first Traeger Grills over a year and a half ago and now I am on my third grill. I have had the most amazing experience grilling, smoking and baking. I do everything on my Traeger. It accurately holds the temperature, starts up automatically and has convection which cooks my food evenly and thoroughly. I recommend this grill to anybody who’s looking for a amazing cooking experience with little effort and really likes to show off to their friends how good their food tastes. My favorite part is being able to walk away from the grill and not have to babysit it so I can do overnight briskets without even checking them. I love it.
Though it is technically a grill, you can carry out so much cooking styles in it. It can be used to sear meats and other food to a perfect golden crusty perfection; it can be used to bake quiches just like you would in a normal indoor oven. This is absolutely a trademark appliance that can also be used to smoke food, it can also be used to slow braise food, making it ideal for cooking up winter stews and casseroles. And very obviously you can grill in this thing. The lid on the pellet grills also aid in fast cooking by trapping smoke and heat and allowing the food to cook and flavor through quickly and more evenly.
If you live in an area where wood furnaces are used (not like down here in FL where a few heat strips will do the trick), you may also be familiar with pellet furnaces. In short, pellets compressed from sawdust and wood shavings fill a hopper and are then fed into a burn pot using an electric auger system. The auger, which is basically a long screw, delivers pellets to the burn pot based on the speed dictated by the unit’s thermostat.
×