At present, I am sponsored by and continually use pellets produced by CookinPellets.com. There are two versions of pellets – the Perfect Mix (Hickory, Cherry, Hard Maple, and Apple Woods) and 100 Percent Hickory. In each of these versions, CookinPellets uses all wood, no bark, no filler woods like oak or alder and no flavor oils. Just 100% of what is on the bag. I get consistently great flavor using these two varieties of pellet smoker pellets from CookinPellets.com, and I think you’ll enjoy them very much as well.
When reviewing pellet smokers, we’ve gone through over 1000 different user reviews to get an accurate understanding of how useful the products have been to them. With that primary data in hand, we did an extensive online research on 65 products from 17 different brands popular brands. In fact, we even looked into three less known brands as well, but they failed to stand out. We left no stone unturned.
Like other grills, pellet grills list cooking area two ways: primary cooking area, which refers to the main cooking grate, and total cooking area, which is the main cooking grate plus any secondary racks. However, since pellet grills are primarily indirect cookers, there really is no difference between cooking on the main rack or the upper rack&em;the temperature should be the same. Therefore, a smaller pellet grill with a primary grid of 450 square inches and an upper rack of 125 square inches may be a better option than a larger grill with only a 500 square inch primary grid.
Pellet cookers usually have an auger or another feed mechanism that pushes the pellets into a burn pot typically about the size of a beer can ripped in half. An igniter rod sits in the bottom of the pot and when you turn on the grill it glows like the element on an electric stove. As the pellets ignite, a fan blows to feed them oxygen, and the igniter shuts off. The Traeger L'il Tex, an inexpensive model, draws 300 watts an hour while the igniter rod is on in the first four minutes, then it drops down to 50 watts an hour for the duration of the cook session, less than a standard light bulb.
Cleaning/Maintenance: The grease catcher on this flat top is pretty decent. It is located on the bottom left hand side and all the oil/grease gets caught without anything dripping elsewhere. I usually wipe the grease catcher's orifice down with a paper towel to ensure it does not get clogged up over time. Other flat-top grills have either grease catchers that drip onto the leg of the grill or have them in the back of the flat top which is a little inconvenient getting to. As for cleaning after every use, I use a stainless steel scrapper/chopper to wipe the grill clean after I am done cooking. I scrape everything down into the grease catcher. For saucy foods or foods that might stick to the flat top, I use water when the grill is still hot to scrape it off and send it to the grease catcher. Afterwards, I put a little bit of oil onto the flat top and spread it all over using paper towels to maintain the seasoning before putting the cover on. Total clean-up time and re-seasoning takes roughly 3 minutes.
Who says bigger is always better? Our fourth contender to make it to our pellet grill review is the The Traeger TFB29LZA Junior elite grill. This petite pellet grill has been specifically designed to meet the needs of small households. Its small body makes it ideal for travelling and tailgating. It features a 300 square inch cooking surface. This pellet grill weighs just 60 pounds. You will get an LED digital, multi-position thermostat that comes with a 3 year warranty.
This is the single main advantage of a pellet smoker. Unlike charcoal, gas or wood fired smokers you don’t need to do anything with fuel except make sure it’s full when you start. This means no more having to go back and check fuel levels, no fluctuating temperatures, no spending ten minutes setting up charcoal and getting it at the right temperature, and no random heat variance giving you oddly cooked food ’cause you set it all up wrong.

Looking for a pellet grill to do all sorts of cooking with. I am between a Rec Tec, Camp Chef Woodwind, Gorilla and Yoder. Steaks, burgers, chicken, ribs, brisket, vegetables, etc. All in one. And want to have the option to sear meat, veggies as well. Ive seen so many different reviews my head is spinning. My budget is $700-$1,000 but willing to go up if necessary. I hear some can sear, some take too long to heat up, some dont hold the temp consistently. I am a low maintenance so ease of use important. Does not have to be portable.
You want a set-it-and-forget-it option: Traeger grills work best when they’re allowed to cook and smoke the food over long periods of time. As long as the system has fresh wood pellets in the hopper to feed the fire box, it will be able to maintain a steady temperature. So you can set up the grill and then leave it for half an hour, a couple of hours, or even longer, something that’s difficult to do with other grilling systems.

The Silverbac and the Silverbac original models of the Grilla Grills come with a good build. It has a stainless steel burn grate and a stainless steel firebox with a rugged exterior. It is painted with a high-temperature powder coating on a heavy-duty steel body. The seams are welded, caulked and powder coated for a three-layer weather resistance. Its lid and all the internal components are made of stainless steel, greatly improving this product’s life.

It’s built pretty solidly, which is what you want with a portable system as it’s obviously being moved around a lot more. I’d say it’s similar in build quality to the Traeger Junior Elite, which as a top of the line smoker says all that needs to be said. If something does go wrong, there’s a two year warranty. I’d have liked more, but it’s there, and that’s good enough.
They had the field to themselves for a few years, but the idea was too good to go un-imitated, and soon competitors began popping up. In the early days, most pellet smoker controllers had only three settings—low, medium, high (LMH)—and there was no temperature probe in the oven to create a feedback loop. So, whether you were smoking a few slabs of ribs on a scorching summer day or six pork butts during a blizzard, the controller only knew pellet-feed on and off times for its standard settings. It had no information on the actual temperature inside the cooking chamber.
My husband used my two cast iron dutch ovens to make corned beef, but neglected to wash out the pots afterward. Needless to say, when I discovered the ruination of the years of seasoning destroyed by the salt brine, I wanted to cry. This product is so much better than using vegetable oil or shortening as I have done in the past. It seals the surfaces well and does not leave a sticky residue. Hope it gets back to at least an approximation of the old coating. Only time will tell.
Compared with charcoal and other wood-fired grills, pellet smokers are simpler and cleaner and easier, giving more control than traditional smokers. Wood pellets are dense, burn hot and smooth, and can be easily fed into the flame with an automatic auger, allowing for consistent temperature with minimal effort. Many modern smokers let you practically set it and forget it, thanks to their digital controllers. Pellet grills are also efficiently cheap, often using as little as 1lb of pellets an hour.
Pellets work so well with the ease of use of a pellet grill because they’re 100% all-natural. They don’t have binders, chemicals, fillers, or petroleum products within them. They serve as a source of compact energy (8,500 BTU per pound) and smoke flavor. Most importantly, there’s little to no ash from them. Compared to coals, there are no flare-ups involved.
While the Traeger Lil-Tex does offer similar features as our top pick, such as a digital LED temperature control system and an auto-dispensing auger, there was one missing feature which we thought was necessary. This product has a smaller grilling area and lacks a removable upper rack, which gives you less grilling and prep space. I should mention that the unit does come in a bigger 700 square inch version for $200 more, as well as a smaller version that costs less. If this smoker is too big or too small for you, there are always other options available. Compared to our top pick, it’s also more expensive despite offering similar specs. Aside from that, this is a very efficient and reliable smoker – might even have been the best if our top pick wasn’t available on the market.
Wood pellets are small pieces of hardwood made from compressed sawdust from hardwood. Generally, some wood pellets made for room heating and stoves are produced using some form of binding agent like glue and other additives, which would leave a bad taste and flavor when used for cooking. However, for modern-day grilling, wood pellets are made of pure wooden sawdust and sometimes a little bit of vegetable oil to help it burn. So, nowadays, wood pellets are even better than the real wood chips for grilling.

For example, it has a decent 570 sq. in. of cooking area, a patented ash cleanout service, endless versatility (wherein you can barbecue, braise, roast, bake, smoke, and grill to your heart’s delight), and an advanced digital control (the same one that allowed the Camp Chef SmokePro to take the top spot). However, the quality control for this unit is a little worse than SmokePro.
I am a pellet grill newby and a recent convert from the backyard charcoal grill to the Yoder YS640. After a ton of research on pellet grills, I jumped in the deep end with this grill and have won raving Family fans after four grilling adventures. I have never cook ribs...tried three racks using a special rub and several ours on the Yoder...and my wife who isn't fond of ribs was eating the left overs the next day! This grill is easy to use and creates fantastic tasting food. My only regret is that I didn't purchase the grill a lot sooner.

When you’re buying a pellet smoker vs a wood smoker, what you’re buying is convenience and simplicity of use. Whilst electric smokers are arguably more convenient than pellet based smokers because they start quicker, only need a power point and a handful of wood chips, pellet smokers are still incredibly easy to use and far more convenient than wood smokers.

In some ways, it’s surprising that something so small could be the culprit behind so many problems on a hi-tech cooker like a pellet grill. Then again, pellets are your grill’s fuel and using bad pellets is like using subpar charcoal in a kamado, and it can cause the same problems—too much ash is produced, making it hard to hold a steady temperature and snuffing out the oxygen supply to the fire.


Hey Chris, IMHO the Blazing Pellet Smoker looks like a solid unit. There’s a good review of it here. I think between the units I might give them a run. Yoder makes quality stuff, and if made in the USA is important to you, they fit as do the Blazings. All this said, if you’re basically using the pellet smoker like a Cambro, you could opt to save a little money and go with the Rec-Tec. Good customer service and solid following.
© Copyright 2005 to 2018 by AmazingRibs.com. All text, recipes, photos, and computer code are owned by AmazingRibs.com and protected by US copyright law unless otherwise noted. It is a US Federal crime to publish or distribute anything on this website without permission. But we're easy! We usually grant permission and don't charge a fee. To get permission, just click here. And you don't need permission to link to us.
I have put together the best pellet grill review of the top 10 pellet grills in the market today. Mind that this list was not just put together in a jiffy; all the names in this list have been carefully picked and chosen through strict inspection on performance, ratings and consumer preferences. Let’s take a look at the pellet grill review I have for you:
3-Position Controller - 3 position controllers, also called LMH controllers, have just 3 temperature settings—low, medium, and high—which correlate to roughly 225°F, 325°F, and 425°F. They feed pellets in fixed cycles that are determined by which setting you choose. With just three settings to choose from, though, you have less control over cooking temperatures than more advanced controllers. These controllers are often found on lower priced pellet grills.

If you are looking to produce competition quality barbecue in your own backyard, then look no further than the Pit Boss Deluxe Wood Pellet Grill and Smoker. This grill has the most versatile cooking system ever built. Sauté, Stir fry, Cook breakfast, or Flame broil dinner in just a few minutes. Sears and broil steaks just like your favorite steakhouse. The 820 Series offers two tiers of porcelain-coated grid construction, totaling 820 sq. inches of cooking surface, allowing you to skillfully prepare food with savory natural hardwood flavor. The Fan-forced convection can bake anything that you would normally bake in your oven. A pellet grill is hands-down the best wood-fired pizza oven that is available. Even smoke your holiday turkey!


Explicitly designed as a tailgate smoker with maximum portability and accessibility, the Davey Crockett does what it does really well. It’s small, but it’s so easy to move and runs off of damn near any power source, so if you want a wood pellet smoker you can take literally anywhere with maximum portability and style, this is the one. That’s why in my opinion, this is the best pellet smoker out there for the money.
As people learn about pellet grills, they quickly realize that there are a number of brands offering a variety of models. So how are they different? And how do you know which pellet grill is right for you? With more options than ever, shopping for a pellet grill can be confusing. In a market filled with grills that claim similar capabilities, it can be difficult to discern what separates one from another. However, if you know which factors to consider and what features to look for, choosing the best pellet grill for you is a whole lot easier.
4 years ago I made a 700 hundred dollar mistake a bought a China made grill it never worked right from day one. My wife suggested that I should replace it. I decided I wanted a us made grill after seeing the yoder series and all of the great reviews I couldn't wait for it to arrive.so glad a bought the ys640 works like a dream, any one reads these reviews and buys another grill you have made a mistake
The Smart Smoke technology is one of the most convenient and easy to use features on the grill. It contains a dual LED temperature readout that keeps the heat at a constant temperature. This means you have more time for socializing and can sit back and relax. The temperature ranges from 160 to 500 degrees Fahrenheit. The grill uses a pellet feeder system that burns slowly to add intense flavor to your food. It also uses an electric auto-start ignition that requires the grill be plugged into a standard 120v outlet.
Rec Tec has always been known for making advanced Rec Tec wood pellet grills coming in at a higher price. However, some of the popular models come in smaller sizes, like Trailblazer 340 or Bullseye 380. However, compared to their capacities and features, the products in our top ten lists would be better choices. So, among its products, the RecTec Bull 700 is the only one that falls in our Honorable Mentions.
Auger Making Weight Noises: It’s usually indicating a problem with the motor that’s responsible for rotating the augers. Under such circumstances, you would be left with no other choice than to replace the motor completely. Since the motors and augers are usually packaged together, this can get quite expensive. In such scenarios, it’s better to let it make noises and run for as long as it would serve you before going to replace it. However, once that problem occurs, you’d often find the auger not feeding the pellets at the expected rate and thus, the desired temperature might not be reached in some cases.
Pick an item that is anything but difficult to clean and store. Stay away from massive units on the off chance that you don’t need your grill to stick around in the kitchen when not being used. You may likewise need to pick one that your space can suit. And afterward, search for a model that can be effortlessly cleaned and that accompanies a deplete framework and an oil/dribble plate/gatherer.
Hey Corry – GMG and Traeger have shown that they support their brands very well of late. In many cases, they both provide parts support even when warranty limits run out. If you’re considering a Traeger, I’d urge you to go with their Pro Series 22 or 34. Sounds like that’s what you’re probably looking at where they are concerned if you’re looking at a dealer.
Most pellet smokers are wood-burning ovens: great for ribs, turkey, brisket, and pork shoulders, but not so great for grilling steaks and burgers. The FEC PG series was one of the first lines of pellet burners to offer a sear station, a cast iron cooking grate right over the fire pot where the wood pellets burn. It isn't the best setup for searing, but it's better than most other pellet searing schemes. The real beauty of the Fast Eddy's design is that it produces meat with a deep mahogany finish, much like a competition-grade offset smoker. It also has two upper-level heat zones, for a total of four distinct temperature zones.

When a product is listed as Pre-Order, such product is not yet in stock but is available for advanced purchase on our site, prior to the manufacturer's public release date. Pre-Order items are shipped once in stock and the public release date arrives. You will be notified of a product's updated status by email. The expected shipment time is listed on the Product Detail page.
Wood pellets are an all natural product. No petroleum products in them, no fillers, chemicals, or binders. They are an excellent source of smoke flavor and compact energy, 8,500 BTU per pound. No hot coals, no flareups. There is also very little ash: 10 pounds of pellets will produce about 1/2 cup of ash. All the rest is converted to energy and combustion gases. I clean out the bottom of the ones I tested after about 10 cooks. At high temps there is very little smoke, at low temps the pellets smolder and produce superb but understated smoke flavors. Click here for more about pellets.

Regarding getting a good draft, this is a common misconception for pellet grills. The burn pot on pellet grills receives oxygen via a fan unit. As such, there’s no need for a draft to get a measured burn in the traditional sense. Most pellet grills lack sufficient insulation / gaskets, etc to prevent smoke from leaking out of the body. So, unless you’re going with the Memphis or something that uses oven style insulation, you don’t really need a chimney at all IMHO.
Well built and compact, this smoker and grill still has a 300 square inch cooking space, and is generally big enough to fit a small turkey inside, so it’s ample for six to eight people. It’s really easy to use, with an automated electric start, front mounted thermometer and idiot proof digital controls that make this so simple, an absolute beginner could walk up to it, have a quick play around and start cooking.
The Camp Chef SmokePro’s automatic features definitely set it apart and make it truly a “set it and forget it” kind of unit. It makes use of an electric auto-igniter system that lets you start grilling with just one button. The automatic auger instantly dispenses pellets to maintain the desired temperature and use your pellets the most efficient way.

“We love pellet grills but didn’t like the designs of the models on the market. They are more like an oven than a grill. MAK Grills are designed to be the best in class. You get outstanding BBQ flavor and safe cooking with real wood, along with an automatic lighting and fuel feed system. Simply turn the grill on and you’re cooking in minutes! Our direct heat FlameZone ® feature is pioneering the industry for “gas grill like” cooking without the hassle of flare-ups and burned food.” — MAK Grills
×