Cleaning/Maintenance: The grease catcher on this flat top is pretty decent. It is located on the bottom left hand side and all the oil/grease gets caught without anything dripping elsewhere. I usually wipe the grease catcher's orifice down with a paper towel to ensure it does not get clogged up over time. Other flat-top grills have either grease catchers that drip onto the leg of the grill or have them in the back of the flat top which is a little inconvenient getting to. As for cleaning after every use, I use a stainless steel scrapper/chopper to wipe the grill clean after I am done cooking. I scrape everything down into the grease catcher. For saucy foods or foods that might stick to the flat top, I use water when the grill is still hot to scrape it off and send it to the grease catcher. Afterwards, I put a little bit of oil onto the flat top and spread it all over using paper towels to maintain the seasoning before putting the cover on. Total clean-up time and re-seasoning takes roughly 3 minutes.
PG24 by Camp Chef is the best choice for any expert smoker. Its reasonable price and amazing features make it a good prolonged investment. It comes with lots of nifty features that facilitate, smoking, grilling and searing in your backyard. For all these reasons, in our pellet smoker review, we consider this smoker as the top choice for the serious BBQ buffs.
Like other grills, pellet grills list cooking area two ways: primary cooking area, which refers to the main cooking grate, and total cooking area, which is the main cooking grate plus any secondary racks. However, since pellet grills are primarily indirect cookers, there really is no difference between cooking on the main rack or the upper rack&em;the temperature should be the same. Therefore, a smaller pellet grill with a primary grid of 450 square inches and an upper rack of 125 square inches may be a better option than a larger grill with only a 500 square inch primary grid.
Hey Vernon – Yoder warranty is is 1-year on the igniter, 3-years on the control system and 10-years on the cooking body. Products manufactured by Memphis Wood Fire Grills carry a seven (7) year Limited Warranty from the date of purchase by the original owner against defects in material and workmanship. Electronic and electrical components carry a three (3) year replacement warranty when subjected to normal residential use. Limited Warranty does not apply to burn pot, meat probe, grill cover gaskets or damage caused by corrosion. The meat probe is under Warranty for 30 days from the date of purchase. (Both warranty blurbs were pulled from the respective company websites) Yoder: http://www.yodersmokers.com/pellet-frequently-asked-questions.html Memphis Grills: https://memphisgrills.com/warranty/

Built from substantial stainless steel, the SmokePro looks bombproof and weighs a hefty 140 lbs – so it’s not portable like the Z Grills or Traeger Junior Elite. It has a stainless-steel probe to directly monitor meat, and a sensor for the grill’s internal temperature. Both read out on the LED display next to the digital controller, which goes from 160F to 500F in 25-degree increments.


The Champion Competition Pro Wood Pellet Grill and Smoker by Louisiana Grills takes outdoor cooking versatility to all new heights. A total cooking area of 3432 sq. in. (8718 sq. cm) and fully integrated multi-chamber smoking cabinets, the Champion Competition Pro is designed to be a show stopper. With direct and indirect flame grilling in the main barrel, hot smoking in the lower smoke cabinet, and cold smoking in the upper smoke cabinet, the Champion Competition Pro is the ultimate grill for the outdoor barbecue enthusiast. This grill revolutionizes grilling in three different ways: the digital control center and lid thermometer allows for precise temperature control of a dynamic range of 60°F-600°F (15°C -177°C) for grilling and smoking, the use of all-natural hardwood pellets allows you to enjoy the amazing wood flavor with the single push of a button, and a programmable meat probe that works together with the digital control center to regulate temperature.
We are going to take the guesswork out of it for you. Here at Grills Forever we have seared, smoked and grilled on grill after grill so you can have the latest information on what smokers are the best pellet smoker grills. These best pellet smokers can sear and cook the most delicious foods, they are easy to control and convenient to use. We took all these features and more into consideration while compiling the top 10 wood pellet smoker review.
DS, I have a green mountain grill. besides that for any pellet smoker cook your chicken at a high heat otherwise the skin will be rubbery. doesnt have to be a direct flame to get it crispy. I set my GMG to 425 flip it after 8 mins pull it at 170 crispy perfection. if you want more smoke flavor, smoke it at 150 for an hour then crank it up to 425 to finish it. I was upset with my rubbery skin when i first used it as well but i got some good advice from the pros. chicken doesnt need to be cooked low and slow to tenderize it like pork and beef does. it doesnt have the tissues or muscles that need to be broken down like beef and pork
Remember, you are paying for every little feature, attachments and details on any product. So do not end up paying you inheritance for a feature that you are probably never going to use. Instead, invest on a pellet grill that caters to your needs and has features that will actually enhance your experience when using it. So do not, I repeat: do not, fall for fancy marketing features that sound too drastic.

We did return the Traeger to Costco for a full refund. It's not that Traeger has poor customer service; they don't have any customer service. We brought a Bradley Smoker, an upright design, and it has performed much better than the Traeger. The Bradley also takes up much less space and we've placed it on a dolly so it can be rolled around. Overall, a much better solution.


Brad Barrett at Grill Grates makes a fantastic product. Reverse searing 2″ steaks and chops (or thicker) works great on pellet smokers as you can get the internal temp up to 10-15 degrees below your desired finish temp, remove them and loosely wrap / cover in foil, crank up the smoker with the grates on to say, 400 degrees, and then sear off your protein getting great grill marks with little to no sticking at all. Huge fan of Grill Grates.
It’s built pretty solidly, which is what you want with a portable system as it’s obviously being moved around a lot more. I’d say it’s similar in build quality to the Traeger Junior Elite, which as a top of the line smoker says all that needs to be said. If something does go wrong, there’s a two year warranty. I’d have liked more, but it’s there, and that’s good enough.
I only just learned about “wood pellets” recently when my husband and I were researching ways to heat the small mountain cabin we just moved into a few months ago, and I had no idea there were so many options for pellet grills. Wow! I hadn’t even know these existed to consider them, and now your reviews have me wanting to try one out. You’ve offered amazingly detailed and positive information on each model listed to help buyers make an informed decision. Your writing style is so fun and upbeat, I can only imagine that your backyard and backyard gatherings rock! Thanks for giving me food for thought on our next grill, Nate. (And for making me hungry, too! lol)
Great reviews. I have been lately looking into pellet poopers. I currently own a large Big Green Egg and a Pit Barrel Grill. My Egg has limited space. On the PBC (Pit Barrel Cooker) I can cook a ton of food as it uses hanging meat method. But it has zero temperature control on it. A set lower vent and that’s it. You have to adjust the lid to get the temps up. I have adjustable rings for my Egg that allows for increased capacity. Eggs are great smokers, grills and ovens. I do have a FireBoss temp controller for the Egg which will allow a set it and forget operations. Wifi controls also. With that being said, I am looking for increased capacity in my cooks. I was seriously considering a XL Primo Oval or a XL BGE. Then I found these pellet poopers. After reading this blog and other reviews I found some limitations. One the lack of smoke flavor. Now with my Egg I add chunks of wood into the lump for smoke flavor. Same with the PBC. The PBC has different smoke flavor as the fats and juices from the meat drip on the hot coals which ignite (according to PBC’s website) and produce a smokey flavor in the meat. I’ve read two ways to increase the smoke flavor in Pellet Poopers. One is to start at a lower temp for a few hours, then crank it up to cooking temps. Two is the smoke tubes or Mojo Bricks. My question is do these techniques work? One review on the smoking tube said that they really didn’t make that much of a difference. Another issue was for grilling and the lack of direct heat. Grill Grates would eliminate this concern correct? My understanding of Grill Grates is that they provide a way to direct grill in an indirect environment. That’s a limitation with both of my cookers. The Egg can Indirect or Direct grill. Not both. Yes I can remove the indirect piece and set up the Egg for direct grilling, but you risk burnt fingers even with welders mitts on. Wouldn’t the Grill Grates on a Pellet Pooper solve this problem? Allowing you to slow cook that steak to say 10 degrees shy of your temp range then sear it on the grill grate for the a couple of minutes on each side to get it to your desired temp range? Or go the other way, sear first for a few minutes per side then indirect cook it to the desired temp?

Hey John! Thank you so much for your kind words. I try to do a good job here, and am pleased you are enjoying the site. Regarding electric smokers, I have friends who own them and love them. I’ll try to get a post out this summer on them. Folks seem to like Bradley smokers a good bit, so you might want to check them out. You can find a good selection of them on Amazon.com here.

My Egg will last past my lifetime. And I have a lifetime warranty on it as well. I don’t want to plunk down good money(even $500 is good money if you think about it) to have a grill of no use in 5 years. I guess I’m looking for a do it all grill. Not that I need one to do it all, heck I can use my Old Smokey to grill up some mean steaks and burger and hotdogs if need be.
It comes with some unique features, such as its proprietary “Sense-mate” technology that uses a thermal sensor to monitor the ambient temperature. If used in a cold weather, this grill fires up the turbo mode so you won’t have to wait for it to heat up before you start using it. It comes with “fan-only” mode to blow off the ash and automatically clean the grill once it has been shut off.
Extremely high build quality. It's heavy. Solid. Nothing flexes or bends. The temp displayed is very accurate when referenced with a thermometer. My only complaint is that the 2-piece diffuser should either be standard equipment, or an optional upgrade at order time (in exchange with the stock diffuser). The 2-piece diffuser is a MUST HAVE accessory. Cleaning the firepot is a messy pain the A** without the 2-piece diffuser. I didn't think I would need it, But I ended up ordering it about 6 weeks after receiving my YS640. I also highly recommend the direct grilling grates. I was able to get rid of my gas BBQ because the direct grilling feature works so well on the YS640.
First impression was this thing isn't built like a mass produced unit, it's more like something you would expect from a master fabricator. The assembly instructions were incredibly detailed, and the way it was packaged made it really easy. It takes a little time to get temp steady for low smoking, but once it's there it seems to be pretty steady. So far absolutely impressed with everything about this cooker, and made in the USA!!!
The rest of the product we reviewed offered 6-in-1 features, but this one surprised us with its 8-in-1 cooking versatility. If an efficient smoker that can do multiple things is what you’re after, then there’s no need to look further. This could just be your top choice! The pit Boss Pellet Grill with Flame Broiler cooks almost all kinds of food with 100% genuine wood pellets. Talk about quality and quantity!

The Sense-Mate feature is another one of the best additions to this smoker: it is a thermal sensor system that monitors and reads the internal temperature of the grill within 5ºF of the actual temperature! Once you set your desired temperature using its digital controls, the Sense-Mate technology reads and monitors the temperature, while displaying it on the LCD display. Sense-Mate makes sure that heat is kept at a constant temperature, so whether you are cooking at 150ºF or 550ºF, you can rest assured that your meats will be evenly cooked.
just received my new YS-640 two weeks ago and I absolutely love it. The shipping process and delivery was just as described. The delivery guy unloaded it off the truck, and wheeled the pallet into my garage. Everything was perfect. I am very impressed with the build quality...this thing is a tank. So far have smoked ribs and a brisket, and grilled chicken breasts. The grill heats up much faster than I expected. Temperature holds very steady over the long cooks. I love having the built in probe ports. Still figuring out and tweaking the baffle to control different cooking zones. Only negative thing I say is it can be difficult to manouver in tight quarters because it's so heavy and only the small caster wheels turn. So if you need to move your smoker around a lot, consider the comp cart.
Although these are marketed as grills, they do much more, including baking or roasting. Because they heat by convection, you might not get the grill marks that a gas or charcoal grill will give you, but you also won’t have the flame-up problems. While many pellet grills offer high cooking temperatures, the maximum depends on ambient temperature and wind. Many users wrap their grills in special insulating covers to help maintain heat, reduce fuel use, and reach the higher temperatures they desire.
×