Another avenue that many pellet grill owners use is participating in a bulk buy of their favorite brand.  Many times by ordering as little as a thousand pounds of pellets and having them shipped via pallet can save enough per pound to be worth the effort.  Also, check the websites of the pellet brands listed above, many have local distributors that maybe with an hour drive of your location.  If you are new to the pellet world, the thought of ordering a thousand pounds of pellets may sound excessive or intimidating.  Many felt this way at first, but if you are in a location where it is hard to get pellets, the mantra of keeping at least a hundred pounds of pellets (five 20 pound bags) on hand at all times starts to make sense quickly.
One-Touch Non-PID Controller - Featuring a LCD display and one-touch buttons for setting the cooking temperature in 5° or 10° increments, these controllers allow you to more accurately set a desired cooking temperature. However, like multi-position controllers, they use fixed cycles for delivering pellets and so are limited in accuracy to +/-15–20°F. These controllers may have inputs for meat probes that monitor the internal temperature of food.

Decided that moving these beasts was a little challenging so I bought a Backwoods Party 10 years ago and loved it. But basically have about worn it out. And as I got older I don’t enjoy getting up at 2 AM and then having to get up every couple of hours, after the 45 minutes of getting it ready at 2 AM, to check it and feed it. I also bought a smaller lightly used Open Range, The Good One. Used their recommended method the first time I cooked with it and hated the Q off of it so bad most of it was wasted, wife hated it too and the son ate most of it. It was extremely ash/strong smoke flavored!


Revising Product review to include photos! Excellent size and performs better than hoped for. Doe great job of smoking meats. Did a 12hr Pork Butt last weekend, tasty. Ran into a snag lately with the smoke stack though. Installed a aluminum patio cover over our deck $5,000. Now when I use my Traeger, the smoke has only a few feet to rise due to new roof over it. If windy, smoke billows in circles, trying to escape. And smoke will race into sliding door when opened. Experimented and came up with cure that works 100% excellent! Home Depot for 25ft roll of 6" Flexible Aluminum Duct. The 6" size goes over the hat on top of Traeger stack, pull down a few inches, wrap aluminum foil around bottom to seal. Other end over end of deck rail. Tried to keep as straight as possible, then trimmed to fit when expanded. Works like a charm and solved problem. Now smoke goes out end of 8ft long alum tube and out from under roofline, up into the air. No more smoke trapped under deck. With the flex alum tube, I can place it on East, West or North deck rails for smoke direction. Just thought I would pass this along as it did not effect the Traeger at all. Actually most likely helps with keeping air draft from entering thru smoke stack.

I have several smokers I have used over the years. I have dialed in everyone I own over a course of trial and error. They all get great results, but require me to tend them all throughout the cook. I wanted a smoker that I could easily get to the desired temp, maintain the temp, provide good smoke flavor, and have the size to do a small or large cook, and not need me to be tending it throughout the cook. The learning curve on this smoker is super easy if you know all your temps, your first cook will give you the results your looking for. I was a little worried that I was not going to get the smoke flavor with a pellet smoker, but my brisket turned out amazing, very tender, the smoke ring was perfect. When I was searching for a new smoker I was a little shy of the Yoder based on the price, but when you figure in the ability to grill as well this became a better alternative. The quality is top tier, this is built to last a long time. I'm so glad I went with the Yoder YS640 no regrets.
Having the same problem as the rest of the group. Rec Tec, Yoder, Green Mountain, Pellet Pro, or MAK? All seem to be heavy gauge SS, Pellet Pro seems really good value, MAK and Green Mountain seem to have controllers with more features. Have a friend who bought Rec Tec 3 years ago, he cannot say enough about the good customer service and the grill. If you could only buy one (money not the issue among these 5), which one, and why?

Hey John – great question. My experience is that I use maybe 8 lbs of pellets for a 7 or 8 hour cook at 275 degrees. Pellet grills are relatively fuel efficient. The brand of pellet you choose will play into this. Cost for pellets varies by manufacturer, similar to charcoal. I think you’ll find them very efficient if you’re just firing them up for high heat, shorter grilling sessions.
I purchased a Traeger Lil Tex 22 yesterday. I “grilled” a whole chicken. It overshot the temperature by nearly a hundred degrees which wasn’t a bad way to crisp up the bird but I was afraid it was going to melt itself down so I shut it down. I was up by 5 this morning to smoke a pork butt for pulled pork sandwiches. My wife’s family is coming over for dinner tonight and time being a concern I fired up the “smoker”. It snowed 12 inches last night so the next hour I was shoveling my walks. Imagine my surprise when I checked on the Traeger and it had shut itself off . The meat was colt to the touch. I read through the instructions to make sure I started it up correctly and I did. I removed the meat and restarted the smoker. It smoked for awhile then quit. The temperature never got above 140. I called Traeger technical support twice and each rep gave me a different answer as to why it wasn’t working. After 3.5 hours I gave up on the Traeger for a more conventional method. I purchased the Traeger for the the set and walk away feature. It let me down!! It is 34 degrees outside today so I will wait until it warms up to try again. Should it fail me again I will sell it for scrap! So far I am not impressed. My wood smoker takes time but it is reliable.

Ordering through All Things BBQ was VERY simple and easy. In fact, my YS640 arrived a few days sooner than expected/quoted. These grills are expensive, but I am a firm believer in "you get what you pay for". There is no doubt the quality of Yoder craftsmanship is exceptional. So far, I have only been able to use my YS640 a coupe of times. However, I'm looking forward to many meals being cooked on it going forward. If you buy one, you will not be disappointed!
I say almost idiot proof because I still make stupid mistakes when I'm cooking and I like to blame it on the pellet grill once in a while. The unit is extremely easy to use for a novice such as myself. I just fill the hopper with my favorite wood pellets, set the temperature and add my food. I have owned this unit a little over a year and everything from the first burger I cooked until the smoked pork chops I just had for dinner has turned out really, really well. I find myself wanting to either smoke or direct grill everything. We have cooked pizza, turkey breasts, tri-tips, pork butts, burgers, salmon, cookies, brownies, chicken wings, drum sticks, pork chops, ribs, cornbread, vegetables, meatloaf and many other things. Nobody ever complains. LOL I have used it in all types of weather all year long. Once I learned how to use the damper (didn't take long) the heat stays where I want it and remains relatively stable even on the coldest days. I would buy this unit again and I would recommend it to others.
From grilled beef, salmons to grilled turkeys I love them all. My passion for grilling delicacy gradually built during the time I was living with my parents. My family members especially my mother was a great fan of grilled dishes to and from the love of food. I started preparing smoked food with my mom. This bonding helped me to know more and more about to smoke, grill delicacies and also with smokers. So, in a word you can tell me a BBQ lover.
Thank you all for a great site and an informative discussion. I am a newbie to smoking and presently have a charcoal grill for when I have more time and a gas grill for a fast meal. Its time to replace my gas grill so I am looking at alternative options. Is a pellet grill overkill, or a timely expedition, if I want to grill a couple steaks or chicken breasts during week nights? I’d also be interested in smoking larger hunks of meat (and ribs!) less often, but am wondering if a pellet grill can cover both? How long does it take a pellet grill to get to temp (e.g. 450°)? With the indirect heat, can you get char marks on your meat? Thanks in advance for the info!

Second on our list of the best pellet grill review the Traeger pellet grill has a 292 square inch cooking surface area. It weigh 70 pounds and measure 21 inch by 23 inch by 21 inch in dimensions. This pellet grill is made out of steel and arrives in a black and bronze body. It has an automatic auger, an electronic auto start and a digital temperature control. The Traeger Pellet grill also feature a Digital Thermostat Control which detects the temperatures inside the grills using an RTD detector, and instructs the auger to fuel the fire and release the pellets according to that.  Other than that, they also come with a manual temperature setting of smoke, medium and high.
Hey Tom, first, thank you so much for reading the article and expressing your approval of it. It means a lot to me that the information posted on this site is useful for the people. To your question about pellet grills, yes. You must always use BBQ grilling pellets with these cookers. You cannot use raw wood with them. However, should you find yourself with access too hard woods like Hickory or maple, or fruit woods like apple, cherry, or peach – this is something that could be readily used in a charcoal smoker.
However, with a pellet smoker, you can ensure that new pellets are being fed into the fire automatically, ensuring that it burns for longer and while it burns, it imparts with its flavors. It doesn’t need to be soaked and fed into a burning pile of coal to work. Above that, sawdust, when separated by the heat and being burned, gets a larger surface area to burn with and thus sends out a bigger burst of flavor per pellet.
I spent a lot of time researching smokers before committing to the 640. I wanted something that can basically be left alone, produce good results and be durable. The 640 meets and exceeds those goals. It is built like a tank, and weighs about as much. I needed two people to help me assemble and move it. Assembly was straiightforward and took about 90 minutes. I have about 4 cooks on it and cannot be happier with the results.
I bought this directly from Traeger. Beware that this model is now discontinued. They replaced it with the Traeger Renegade Pro without notice. The new model has an updated saw horse design and a new digital controller with probes. It does not come with the handy spice rack however. To each their own but I'd check with Traeger prior to purchase. That said, I paid more from them so if this is discounted, grab it. I love mine!

PG24 by Camp Chef Pellet Grill also brings along a digital controller which you could use to set your desired temperature and at one point the heat in the chamber will be automatically adjusted. It allows meat to be smoked for hours at a temperature of 150 degrees F. You could increase temperature to 500 degrees F for searing and grilling. With convection, the cold and hot areas of the grill can be replaced with even heat.
Please Note: If you select Express or Expedited shipping, your order must be received and credit must be approved by 12:30 p.m. EST, or it may not be processed until the next business day. Expedited shipping is available for select products. You can view complete shipping options for your product in your shopping cart. The estimated delivery date for your order will be provided on the order review page prior to completing the order.
Mixing flavored woods with oak offers a couple of advantages, starting with price. Woods like cherry and hickory aren’t nearly as plentiful as oak and therefore cost more, making 100% flavored wood pellet more expensive than those that use a base of oak or alder. By using a blend of oak and cherry, pellet makers can keep prices down—and because oak is fairly neutral the cherry wood smoke flavor still shines through.
Multi-position Controller - A step up from 3-position controllers, multi-position controllers feature a knob with temperature settings that go from 180°F to 420°F in 25° increments and may have an LCD display. In addition to more settings, these controllers offer more temperature control. However, they also run on fixed cycles and can only maintain about +/-20°F in ideal conditions—in cold windy weather they are less accurate and reliable. Some versions of these controllers have inputs for meat probes that can monitor food temperatures.

Do you enjoy hassle and stress-free living? If you want to enjoy the juicy smoked BBQ ribs with your friends and family without feeling disturbed, then the automatic smoker is the top choice for you. The automatic smoker, a pellet smoker, makes for an ideal choice. Do you know why it has it has earned the reputation of the best among all the easy to use smokers? You will find the automatic features incredibly easy to use and this convenient product’s simplicity stands out.
We have shifted to a new house and here we have a very nice backyard. We were thinking of having pellet grill for the backyard for friends and family gatherings for making our holidays memorable. According to your review I think Camp Chef SmokePro DLX Wood Pellet Grill and Smoker | PG24B will be a good option for us. Do you have any other suggestion for us as it will be our first and we don’t have much knowledge about it.
I have used Bradley, Masterpiece, Green Egg, New Braunfels, Oklahoma Joe, Weber and now Traeger. So there is some experience in these comments. The “set it and forget” it is a misnomer and should not be used with Traeger (or any smoker/grill.) With Pellet Drive before you buy Read up on Er codes. The worst is when the fire pot fills up with pellets because the fire can’t keep up with the auger push and the whole cook is ruined or delayed. You have to pull everything out and basically start over while your expensive prime brisket is trying to be saved in the oven. Doesn’t matter what the weather is or wind conditions. Doesn’t matter if you stare at it and stir the hopper continuously. It will happen. Customer support at first was well you are at fault (didn’t leave the lid open on fireup for exactly 2 to 4 minutes or didn’t vacuum out the firepot between every cook) which is crazy. Finally, after so many calls over the past 6 months they are trying to make it right. Problem is, DO NOT believe the “set it and forget it.” That does not exist with any good cook. I have replaced the controller the fan and now getting a new probe. Do not waste your money. Unless someone out here in BBQ land can give me a recommendation on a product that won’t do this stay away from Pellet Drive?
Camp Chef is a leading manufacturer of camping stoves, dutch ovens, and other outdoor cooking equipment. If you want quality cookware to take on your next camping trip or barbecue in the park, Camp Chef has the solutions - from camp stoves to cast iron dutch ovens. Camp Chef makes cooking gear for campers, hunting, for traveling by RV, even for your next tailgate party. Camp Chef was built around the idea of finding better ways to cook outdoors - no matter the location, from woods to parking lots to campgrounds - and from that philosophy has come a whole line of outdoor cooking equipment, made to let you go gourmet in the wild!
The digital controller controls temperatures from 150F to 500F in 5-degree increments; that’s the most precise we’ve found on a pellet grill, and gives you a good, precise burn. There’s also Sense-Mate, a thermal sensor that monitors the smoker’s internal temperature, so you can keep an eye on it remotely on your phone via Wifi, letting you adjust the temperature from the app.
Cleaning/Maintenance: The grease catcher on this flat top is pretty decent. It is located on the bottom left hand side and all the oil/grease gets caught without anything dripping elsewhere. I usually wipe the grease catcher's orifice down with a paper towel to ensure it does not get clogged up over time. Other flat-top grills have either grease catchers that drip onto the leg of the grill or have them in the back of the flat top which is a little inconvenient getting to. As for cleaning after every use, I use a stainless steel scrapper/chopper to wipe the grill clean after I am done cooking. I scrape everything down into the grease catcher. For saucy foods or foods that might stick to the flat top, I use water when the grill is still hot to scrape it off and send it to the grease catcher. Afterwards, I put a little bit of oil onto the flat top and spread it all over using paper towels to maintain the seasoning before putting the cover on. Total clean-up time and re-seasoning takes roughly 3 minutes.
The Tailgater 20 Series Freestanding Grill is one of the best wood pellet grills from Traeger for those who like to cook away from home. It’s small and lightweight enough that you can load it in your car for tailgating before the big game, cooking while camping or grilling at the park. The ash bucket collects all ash created, which makes cleaning up before heading home easier.
Big Horn’s largest available grill, the XL 1093 comes with a large cooking area of 1093 sq inches. With it’s low price tag of around $300 and a high cooking area, this product could have been a great choice for pellet smokers. However, we’d rather not suggest something that’s susceptible to rust and weather conditions to be kept outdoors at all times.
The Green Mountain Grills Davy Crockett smoker lets you get more than what you paid for. At a surprisingly low price, you get to have tons of great features that are sure to elevate your BBQ experience. For its price, we were quite surprised to see that it satisfied most of the features on our review. We tested over fifty products, and even the expensive ones were no match for this product. In terms of value per dollar, this product deserves the top spot.

Second, more people know about them. More manufacturers are realising the advantages of pellet smokers and hopping on board, the market is expanding, and with the advantage of the internet putting all the info at our fingertips, even someone who hasn’t got the first clue about smokers and grills can find out everything they need in just a few minutes.
And #3, good bbq or grilled meats should taste great without a ton seasonings or sauce. Beef especially can be excellent with simple salt! Make sure your seasonings enhance flavor. Another great read, the late (and much grieved at our house) Paul Prudhomme’s ‘Louisiana Kitchen’ again available on Amazon used for a couple of bucks and a masterpiece! Paul was a master of seasoning. Don’t kill it with seasonings and sauce, enhance the foods flavors. Barks on meat are great if they are right. However burnt, sugar and many other seasonings detract from the meats natural flavor. I personally love a meat you can eat without a sauce and then sauce if you want some added flavors going on!
Now, there are different materials that certain pellet grills are made from. Since steel is such a heavy duty and heavy item, some brands have opted in for more cost-efficient materials, such as a stainless-steel lid to remove some of the weight from the pellet grill. With that said, the interior grill gates are as equally important as the exterior. For example, some grill gates are made from an easy to clean porcelain material while some are designed from stainless steel to be more user-friendly and cost-effective. With that said, let’s discuss another important element to consider when it comes to a pellet grill.
Rubbery skin has very little to do with the type of heat (direct vs indirect). Rubbery skin is a result of too low a cooking temperature. Take your smoker/grill or whatever you use and get the temperature in the mid 400’s or even higher and you will get crispy skin. One thing though never let the internal temperature of your bird get over 150 or you’ll have crispy skin and dry crunchy meat too. Take it off the grill and let is rest a full 30 minutes. Best bird you’ll ever eat no matter which grill, smoker, 50 gal barrel, etc you cooked it on.
×