Thankfully the popularity of pellet grills spurred many new pellet fuel manufacturing companies to enter the industry.  There are also some very big names in the grilling world that have seen the light and are now producing pellets as well.   This has helped the availability of pellets for sure, but we are still not to a point where pellets are commonplace in stores in all areas.
For as long as I can remember, the REC TEC RT-680 has been setting the standards for the best pellet smokers on the market, which is why REC-TEC is America’s fastest growing Pellet Smoker Company. And when they came up with the 2018 version of the REC TEC Pellet Grill, we knew it was going to be the very best pellet grill any barbecue lover could get their hands on.
However, with a pellet smoker, you can ensure that new pellets are being fed into the fire automatically, ensuring that it burns for longer and while it burns, it imparts with its flavors. It doesn’t need to be soaked and fed into a burning pile of coal to work. Above that, sawdust, when separated by the heat and being burned, gets a larger surface area to burn with and thus sends out a bigger burst of flavor per pellet.
Some cheaper models, such as the Brinkmann, have a controller with only three settings, Low, Medium, High (LMH), and there is no temperature probe in the oven to create a feedback loop. We do not recommend these units. You actually have less control over temp than you do on a gas or charcoal smoker. The whole reason to buy a pellet grill is because it is set-it-forget-it and it hits a temp and holds it regardless of the ambient air temp outside, winter or summer. On these LMH controllers, the temp fluctuates widely and it cannot correct itself for the weather. They just aren't as smart as a digital device. Whether you're smoking a few slabs of ribs on a scorching summer day, or six pork butts during a blizzard, the three position controller only knows auger on and off times for Low, Medium, and High. It has no information on the temperature inside the cook chamber.
For example, it has a decent 570 sq. in. of cooking area, a patented ash cleanout service, endless versatility (wherein you can barbecue, braise, roast, bake, smoke, and grill to your heart’s delight), and an advanced digital control (the same one that allowed the Camp Chef SmokePro to take the top spot). However, the quality control for this unit is a little worse than SmokePro.

My wife and I just purchased a Yoder YS640. After looking at a lot of other smokers we finally settled on this one. It weighs in at over 300 pounds and is built like a tank. You can see and feel the difference between this unit and others. We brought it home, put it together and did the initial burn in for 1 hour. We then made some ribs for dinner. The temp was set and only had 10 degrees fluctuation up or down. The meat was very moist and had just the right amount of smoke flavor. We are very glad we made this purchase.
This website has a lot of negative reviews... I mixed some salt and pepper, rubbed onto some ribs, and put on the Traeger. After about 5 hours sitting in my a/c living room, looking out the window, at perfectly managed temp, the ribs were done, perfect, juicy, with a beautiful wood smoky flavor that I've never gotten on charcoal or even in restaurants with professional pitmasters and all. I did phone Traeger when I was putting the grill together and doing the 1st burn in, there were humans there (!) and they were knowledgeable and helpful on the 1st time.

My wife and I purchased this over the weekend. Been wanting this grill for a while. $349.99 includes cookbook, 3 years warranty +costco visa warranty. They also had the lil tex and the other bigger grills at reasonable prices. Links are for the locations for their "roadshow" in order to capture the prices. Technically doesn't come with the cover but I convinced the rep to throw one in.
For beginner outdoors chefs and guys buying their first smoker, that’s an invaluable bit of knowledge. Knowing that no matter what you do, as long as you follow the standard set up, you’re going to produce professional quality meat with ease, which is why smokers like the ones below are the best choice for anyone looking at buying their first pellet smoker.
Kevin, Im about ready to pull the trigger – im pausing for a moment to consider your thoughts as you mentioned Grilla Silverback or Camp Chef. How do these compare to the Rec Tec on quality and price? (as they are less than Rec Tec) And reverse sear…how well does this work on pellet grill, ie how long does it take to go from 200 cooking temp to 500 searing temp (with grill grates)? Thank you for your time
All this said, I believe the girls you are looking at already will both provide you with long lasting grilling and smoking satisfaction. Honestly, when you get to a point where are your in the price range that you are in, it’s really hard to choose a bad option with pellet grills. The biggest Advantage you have over the ones you’re looking at and the Yoder models is that they are heavy built giving you excellent heat retention over your Cooks.
After owning this grill for six months I can honestly say I don't regret my purchase. I was waiting for low temp weather to really test this grill and i must be honest i was very surprised. I grilled 400 degrees with the outside temp at 38 degrees and the grill came up to temp within 20 minutes. Last night I started a brisket in 31 degree weather cooking at 225. No problem at all, and I haven't use a thermal jacket. We have done every thing from low and slow to baking and just have been amazed at outcome. Got a couple of more tests that i want to do, but six months, it's great. Stop thinking about it, stop worrying about the price, and prepare to make some great wood fire food.

But even with their indirect heat, wood pellets do something gas can’t; they give your meat that natural, smoky flavor you expect from wood. They don’t create as much smoke as wood or charcoal, so the flavor is not as intense, you swap that intensity for convenient cooking. The smoke they do create is clean and easy to control. And the hotter you burn pellets, the cleaner they burn, letting you crank up the heat when you don’t need smoke.
Traeger Scout Known Defective Product Jul 30, 2018 New grill has extreme temperature fluctuations. Set T 350 gets as HOT as 548 and as COOL as 275. Dealers are happily selling these while Traeger is aware per 1-800 call that they need to replace thousands of drip pans/heat exchangers on units that have been shipped because the ones in the units shipped allow heat to fluctuate widely. Traeger recommended NOT USING THIS BRAND NEW GRILL until I receive the replacement part which they will not receive until the last part of August and they will not commit to expedited shipping when they finally ship. WHY ARE THEY NOT ADVISING DEALERS THAT THE GRILL SHOULD BE PULLED OFF THE SHELF? How many have been sold since they discovered this malfunction? Don't they value their loyal customers and their reputation? Cooking Capacity Performance Design Portability Durability Quality Ease of Use Temperature Control Features Value Packaging Versatility You are receiving this email because of your shopping activity at www.traegergrills.com. Your privacy is very important to us; review our privacy policy here. © 2016 Traeger Grills 1215 E. Wilmington Ave Suite 200, Salt Lake City, UT 84106
If cost isn't an issue, check out the Elite Wood Fire. This 200+ pound behemoth from Memphis Grills costs more than some used cars, but it's fully loaded. Wifi-enabled, an extraordinary temperature range, and a cooking space large enough to be used by a small restaurant - the Elite has it all. The pellet hopper is built to match capacity, with enough fuel space to smoke for up to 62 hours straight.
Let's just say I really love to cook! Especially BBQ. I've had the YS640 a couple months now and can't say enough great things about it! I've grilled ,smoked and high temp roasted with excellent results! After week's of comparing and watching videos I know I made the right decision. There's just no comparison to the Chinese makes and the over priced stainless steel models. I considered the MAK smokers but at double the price couldn't justify it. For the price and USA build quality there isn't anything that can touch the Yoder!

Accurate Temperature Control: The Davy Crockett has better temperature control that permits us to program a great deal more correct temperatures (one-degree changes possible) using their application (the control board permits us to alter temperatures 5 degrees at any given moment). It uses a PID controller […] controller to expect and fine micromanage the temperature by controlling the wood screw speed and the fan speed.
The argument against bark is that it can cause an inconsistent burn and produce excessive ash. Again, consider a log on a fire. Because they have different compositions, the bark and hardwood burn at different rates and produce different amounts of heat. Furthermore, bark doesn’t burn cleanly, it creates more ash than the hardwood. When that ash builds up, it interferes with your grill’s ability to accurately read the temperature, causing large swings. If too much of that ash builds up in the fire pot, it can cut off the oxygen and snuff out the fire.
Turn it on to "Smoke" mode and use the P settings, or cook mode by selecting a temperature. When you select smoke or a temp setting you start the ignition sequence. The fan, igniter and auger motor turn on. The fan stays on until the smoker is turned off. The auger motor continuously delivers pellets to the red hot igniter rod in the firebox for two minutes under normal conditions. Then the igniter rod shuts off and the pellet fire burns with only the assistance of the auger and the fan.

Although mesquite is often thought of as the quintessential BBQ wood, don’t stock up on it until you’ve tried it. While many who are new to pellet smokers and BBQ immediately choose mesquite pellets, be forewarned: it has a strong assertive flavor than can overpower food. When buying pellets for the first time, its wise to choose flavors that are versatile enough to be used on many different foods.

Of all the different smoker designs available, pellet smokers are the easiest to use, because they're thermostatically controlled, like your kitchen stove. You just select a cooking temperature, and a controller maintains it by feeding wood pellets to a fire pot as needed to maintain your set temp. Set it and forget it. You can throw a brisket in a pellet smoker, set it for 225°F (105°C), go to bed, and sleep like a baby, knowing you'll wake up to delicious smoked meat.
All the talk about made in China...... well it could have likely been made anywhere and inside the hopper it says "Tested". Well the LED display does not work correctly, i.e. not all the letters have all the LEDs light up to correctly state the temperature. The frame had a crimp in it on the front and when I closed the lid, it cam down crooked. It was not put on square with the grill. The warranty says that defective parts will be replaced, but the defective part has to be returned, pre-paid by me. That is B.S. This adds to my cost of the grill. Unless they pay for the return of parts, then it will just be fully returned to Amazon.
Hey Ben! Cool re: your Camp Chef! Pellet smokers produce a light smoke as compared to stick burners, gravity fed smokers, Ugly Drum Smokers, etc. Most feel that the smoke provided is enough. If you need more – check out the Amazn Tube Smoker. You can find the Tube Smoker and Cookin’ Pellets via this link. Look for the Pellet Smokers and Pellets links.
Pellets look like rabbit chow. They are about the width of a pencil and as long as a couple of erasers. If they get wet they turn into a pile of sawdust. The beauty of pellets is that they have none of the additives and fillers in charcoal briquets, so they combust almost completely. Almost zero ash. The pellets provide the heat as well as flavor. No need to add wood chips. Surprisingly, they do not produce overly smoky food. If anything, the food is undersmoked to some people because the combustion is so complete.
Hey Jay – Yoder makes a great product. Price not being an option, I’d probably go MAK, Memphis Pro (I go back and forth between the two personally!), then the Yoder. I’ve heard good things about the Louisiana pellet grills, just haven’t featured them here so haven’t done a lot of in-depth research. I’m inclined to rate it below the ones I just mentioned – but not by tons. I will say that if American Made is a factor, MAK, Memphis, and Yoder are a go there.
Of course, we recommend our pellets and have proven them to work fantastically with all of our grills, but we would never be short-sighted enough to say that our owners must only use our pellets.  That just seems a bit, well, wrong.  From our testing and customer feedback, the following brands all worked very well:  B&B, BBQrs Delight, Cooking Pellets.com, Lumberjack and Smoke Ring.
Final Verdict: If you have the capability to cook on this full-time, then I recommend doing so. You will save your kitchen and house from excess grease and smell. It can cook most items relatively fast and easy once you get accustomed to cooking on a flat top. The only thing it can't do is cook sauces or bake items. I even recommend it to folks who don't eat typical greasy foods. This requires very little oil and can use all sorts of cooking oil. All of my food dishes have been cooked well and I constantly have people asking about this flat top. Clean up is a breeze and will save you from needing to clean skillets and pans. This is an essential cookware that every household should have.
Hey Brad, you’ve got 3 great grills there. Rec Tec has the edge on Pellet quantity. I like the build quality and support on the Grilla a bit better, especially with the extra insulation and updated comp wheel set up. Figure 10 min or so to get to top temps. Just remember to drop to around 300 F temp setting before going into the shut down cycle on any pellet grill if you’re cranking it up to the highest setting.

Background: I've had this flat top for a month now and do 99% of my cooking on it. I have it set up next to my kitchen balcony which allows me to cook outside in most weather conditions and allows me to keep my kitchen clean for the most part due to a natural gas hook-up that I have outside. I purchased the Natural Gas Kit Hose (NGKIT) and converted the flat top to only intake natural gas. Please note that once you make the conversion then you cannot convert it back to propane unless you get new orifices. I had to drill all 4 orifices with a #45 drill bit to ensure that sufficient gas will be funneled through to the flat top. This process took a couple hours and will take more if you don't have the proper tools.
The Traeger Pellet grill can accommodate temperatures from 180 degrees to 375 degrees, and high. It has a state of the art digital temperature control system that not only monitors the temperature to keep it consistent and even, but also regulates the pellets the auger feeds to the fire according to that temperature. This is truly a grill worthy of a place in our pellet grill review.
Barbecue was not his first career. He earned a BA from Columbia College in Chicago and studied at the Cleveland Institute of Art and the Dana School of Music. He has been involved in every aspect of film, video and music production. He edited the 1991 Academy Award nominated documentary, "The Mark of the Maker" and "Universal Hotel", which is part of a permanent exhibit at the Dachau Memorial Museum.
I live in Florida (Ocala), and I would like to grill, but I am undecided what to buy. I would not use the grill everyday. I am not a ‘griller’, but I do enjoy grilling simple meats, hamburgers, pork tenderloin and chicken; perhaps smoking a 12 lb. turkey for Thanksgiving and Christmas. I have no knowledge as to grill veggies or fish. I am an ignoramus! I tried, but I couldn’t detect them among the ashes!
Therefore, for a reliable and consistent meal/ grill every time, go for the Traeger grill. It is easy to set and control the temperatures, thus the results are always as expected. Besides, a novice griller can master its use immediately, as it is a complete digital experience. On the same note, it can do a lot more than just grilling. You can use it to smoke, barbecue, braise, roast, and bake, all through the digital control system.
While many people enjoy pellet grills, some find it difficult to use pellets to produce true, flavorful steaks and barbecue since the fuel often lacks the same flavors as traditional grills. That smoky, wood flavor many steaks have is not impossible to get with the right pellet grill however. The Z Grills Wood Pellet Grill sports a combined grill/smoker setup with temperature control for the best pellet grilling experience available.
×