OK. I’m rambling a bit. To your point regarding Traeger. I think that the models you can buy at big box stores (Costco etc) are OK. I still hear a few complaints about blistering paint etc. But… their Pro Series Models are a different story. The new management at Traeger has come a long way in their efforts to reaffirm the Traeger brand as a legitimate BBQ Pellet Smoker brand that everyone from the backyarder to competition pitmasters can get behind. To that end, they only allow specialty retailers carry the Pro Series models, which are built with a bit more heft and better PID controls, electronics, etc. You can find these at Ace Hardware stores, places like the Whiskey Bent BBQ Supply store we have here in Lakeland, FL (there is now one in Odessa, FL) as well. You can find a Traeger Pro model by going to http://www.traegergrills.com/dealers.
Today, all serious players in the pellet smoker market have switched to digital thermostatic controllers that dictate pellet-feed commands based on a temperature sensor inside the cooking box. Just like with the oven in your kitchen, you set the desired cooking temperature, and the heating system kicks on and off to maintain that set point. An LED display shows your set temp, and most models allow you to toggle between set temp and actual temp readings from the internal thermostat. Actual temperatures will fluctuate a bit as the controller switches on and off to hover around your set temp, but many sophisticated touch-pad controllers can maintain tighter tolerances than your indoor oven. Some pellet controllers also have integrated probes that let you monitor the internal temperature of whatever you're smoking. Wireless remote control and monitoring from your smartphone or tablet are also increasingly common. (You can learn more about pellet smokers on AmazingRibs.com.)
This pellet smoker and its humongous 20 inches by 15 inches or 300 square inches of grilling space are capable of holding 3 rib racks, 18 hotdogs, 4 chickens, or 12 burgers at the same time. This is also one of the most Affordable pellet smokers around. Its thermostat control is LED digital so that you can set it as easily as your microwave. Just press buttons and get the setting you want every time.
PG24 by Camp Chef has a weight of 124 lb with a pellet hopper that has 20-pound capacity. That’s so large, you won’t need to worry of getting more before your meal is done. This approach allows you to have the ultimate cooking experience. When the temperature drops, one wood pellet is released. This convenience can’t be found in other grill types, like gas or charcoal.
However, it does not mean that you stop grilling with wood pellets. You can minimize this risk by avoiding flare-ups and over-charring the meat. If the meat over-burns then it does not only spoil the taste but is a risk to your health. Moreover, the flavored wood pellet smoke is also a risk, even though it can enhance the taste of the food. This is because it contains carcinogenic elements that are unhealthy for you. One such element is the polyaromatic hydrocarbons or PAHs. Besides, you can find this element is most processed food products but its concentration is high in wood smoke.
Hi Dan, I had a Bradley some years ago and the quality of the smoke is somewhat comparable to that of a pellet unit. As I said in my earlier post, compressed sawdust does not create the wood flavor that permeates the meat— no matter what pellet you use. I recently bought a Lang reverse flow, and on my first cook the difference was spectacular. My nephew went to the trouble of adding a full size wood burning firebox to his pellet stove as an experiment. He piped the smoke from the firebox into the pellet unit while making some ribs and the results were obvious. The next day he was out looking for a new smoker. Wood burners are a lot of work compared to a pellet unit, as you say, so I understand your reluctance. Many like vertical units that burn charcoal with wood chunks. These units are much easier to manage than a stick burner and give good results. All I can say is that the first time you make BBQ in your backyard with a wood unit, you will know you made the right choice. There are many good BBQ forums that discuss these points. Good Queing to you.
Revising Product review to include photos! Excellent size and performs better than hoped for. Doe great job of smoking meats. Did a 12hr Pork Butt last weekend, tasty. Ran into a snag lately with the smoke stack though. Installed a aluminum patio cover over our deck $5,000. Now when I use my Traeger, the smoke has only a few feet to rise due to new roof over it. If windy, smoke billows in circles, trying to escape. And smoke will race into sliding door when opened. Experimented and came up with cure that works 100% excellent! Home Depot for 25ft roll of 6" Flexible Aluminum Duct. The 6" size goes over the hat on top of Traeger stack, pull down a few inches, wrap aluminum foil around bottom to seal. Other end over end of deck rail. Tried to keep as straight as possible, then trimmed to fit when expanded. Works like a charm and solved problem. Now smoke goes out end of 8ft long alum tube and out from under roofline, up into the air. No more smoke trapped under deck. With the flex alum tube, I can place it on East, West or North deck rails for smoke direction. Just thought I would pass this along as it did not effect the Traeger at all. Actually most likely helps with keeping air draft from entering thru smoke stack.
Rec-Tec has a strong following, and – as with the rest of the pellet grills in this review, will do you right. They’ve recently gone to an all black (no more red) look with their newer models. Though, you can probably still get the red. They have the most pellet holding capacity of any other grills pretty much, so that might be a plus for you. Getting temps back down is pretty fast… 5-10 minutes or so. I’d consider reverse searing, so long as your steaks are 1 and 1/2 inches or more. Thinner cuts won’t work. So, basically – you get the steak up to around 125-35 at around 225-250 F. Wrap it in foil. Then, crank your heat up to the highest setting, remove your steak from the foil, and sear it off on both sides to your desired doneness level. This limits the amount of grey – making for a more uniform pink from the top to the bottom of the steak.
Camp Chef's Woodwind Pellet Smoker is a quality smoker and super searing grill wrapped up in one. As I mentioned above, though pellet smokers are often referred to as pellet grills, most have a limited grilling capability at best. To fill this gap, in 2017, Camp Chef introduced its optional LP gas Sear Box, which can be added to any of its current SmokePro pellet smokers. Woodwind is a package deal that comes standard with the Sear Box and sells for about $50 less than a SmokePro with the optional Sear Box. As a bonus, Camp Chef is one of the few brands on the market with an ash-removal system that deposits ash in a cup under the smoke box for easy disposal.
Hey Jennifer, I think a pellet grill/smoker would make a great addition to your cooking arsenal. You can get a pellet smoker up to 450 degrees in about 10 or 15 minutes. The following article gives you a good idea of what you might do to reverse sear a nice thick steak using a pellet smoker. note, that this method employs the use of GrillGrates, which you can find easily on Amazon. Here’s the article:http://blog.greenmountaingrills.com/rib-eye-reverse-seared/
They had the field to themselves for a few years, but the idea was too good to go un-imitated, and soon competitors began popping up. In the early days, most pellet smoker controllers had only three settings—low, medium, high (LMH)—and there was no temperature probe in the oven to create a feedback loop. So, whether you were smoking a few slabs of ribs on a scorching summer day or six pork butts during a blizzard, the controller only knew pellet-feed on and off times for its standard settings. It had no information on the actual temperature inside the cooking chamber.
If cost isn't an issue, check out the Elite Wood Fire. This 200+ pound behemoth from Memphis Grills costs more than some used cars, but it's fully loaded. Wifi-enabled, an extraordinary temperature range, and a cooking space large enough to be used by a small restaurant - the Elite has it all. The pellet hopper is built to match capacity, with enough fuel space to smoke for up to 62 hours straight.
My wife and I were one of the first buyers of the YS640 in 2010. We had owned a couple of gas grills that, of course, eventually rust out. My wife saw the YS640 at the Kansas State Fair and called me and said that I HAD to look at this smoker! At first, the smoker had many problems--inaccurate temps, huge swings in temps, etc. Don and Joe kept working on the problems and installing updates--never charging us for updates or service calls. Finally, in about March of 2011, they installed the update that really was the solution. Since then, the YS640 has been a consistent workhorse that does everything as advertised. Built like a tank. built to last. Don and his staff stuck by his product and by his customers. In this day and age, customer service is uncommon. By the way, I thought the YS480 would have been big enough, but my wife said, "our family isn't getting smaller,".....I'm very glad we got the 640 and the second shelf. I have needed it many times. Thanks Don!
Hey John – great question. My experience is that I use maybe 8 lbs of pellets for a 7 or 8 hour cook at 275 degrees. Pellet grills are relatively fuel efficient. The brand of pellet you choose will play into this. Cost for pellets varies by manufacturer, similar to charcoal. I think you’ll find them very efficient if you’re just firing them up for high heat, shorter grilling sessions.
Like other grills, pellet grills list cooking area two ways: primary cooking area, which refers to the main cooking grate, and total cooking area, which is the main cooking grate plus any secondary racks. However, since pellet grills are primarily indirect cookers, there really is no difference between cooking on the main rack or the upper rack&em;the temperature should be the same. Therefore, a smaller pellet grill with a primary grid of 450 square inches and an upper rack of 125 square inches may be a better option than a larger grill with only a 500 square inch primary grid.
Although I marked price high. I would buy it again, tomorrow. I was a novice. I had never smoked anything when I bought this. It is amazing and if you asked my friends and family I should have opened a bar & grill. It's grills better than any gas grill u can buy. The YS640 only gets better with time you get good at using it. It's the best cooker on earth. If your considering paying over $800 for a cooker. Spend the money... you will not regret it. My cousins have Traegers.. and they smeared by them. One weekend at my cabin one has ordered his the other don't have the money yet. I have used it a minimum of 2 days a week and have already got my money out of it by not ruining meat. The guys at Yoder have a monopoly. No one makes a cooker that could stand up to it. THANK YOU YODER. YOU HAVE MADE SOME GREAT HOLIDAY MEMORIES FOR ME AND MY FAMILY. Remember if your on the borderline don't know if it's worth a little more. By the 12th month of owning it. You will look at your wife or girlfriend and say "I'm so glad I spent a little extra and got that. It's beautiful.
Rubbery skin has very little to do with the type of heat (direct vs indirect). Rubbery skin is a result of too low a cooking temperature. Take your smoker/grill or whatever you use and get the temperature in the mid 400’s or even higher and you will get crispy skin. One thing though never let the internal temperature of your bird get over 150 or you’ll have crispy skin and dry crunchy meat too. Take it off the grill and let is rest a full 30 minutes. Best bird you’ll ever eat no matter which grill, smoker, 50 gal barrel, etc you cooked it on.
The small burn pot is covered with a large deflector plate that absorbs the heat and spreads it out below the cooking surface making them essentially wood-fired convection ovens. Flare-ups are a thing of the past. You need to keep the plate clean because it is right below the food and if you leave sauce and grease on there, it can smolder and leave soot on your food. Carbon buildup will also diminish its heat transmission.
Food not cooking evenly or at desired times: It’s worth checking out the health of the fans in your pellet grill. Usually, if the fan is unable to distribute the heat properly throughout the whole smoker, these problems occur. Fans are relatively inexpensive and very easy to replace. Even if you see the fan working and still getting these problems, it might be that the fan is working intermittently or at slower speeds that it needs to. Have it replaced: it would be the best course of action and won’t be heavy on your wallet.
Competition: If you are buying a smoker for participating in any competition, then pellet smokers are your best choice. Gas or electric smoker grills are not allowed in any competition as they are using automation. Though you are getting temperature control and electronic start in pellet smoker it is accepted in competition. This pellet smoker review will point out the ones best for a competition.
This exceptional dual-purpose wood fired oven and smoker This exceptional dual-purpose wood fired oven and smoker is the flagship member of our stunning outdoor gourmet group by Alfresco Home. With its handsome vertical design and stylish exterior the Fornetto immediately draws a crowd. When this beauty is fired up and delivering mouth watering meats poultry fish and vegetables ... More + Product Details Close
I remember a time when I was going through some quad-bike reviews; it was all so confusing and I had no clue whom to believe and whom not to. Even when I eventually decided to put my faith in one of them, I kept having second thoughts regarding whether or not they would fail me. If you’re someone like me, let me give you four reasons our reviews won’t fail you:
Traeger Junior Elite Pellet Grill is a great model for those who want to start up the smoker, add some meat, and let the work be done for them. It is also extremely versatile, allowing you to grill, smoke, roast, and bake. It is perfect for individual households, college students, and even tailgating. And it’s a great option for first timers as well as those who have experience using pellet smokers.
On Tabletop Models: I didn’t include them here because though extensive, this post is more of an overview of a few select makers of Pellet Smokers I think do a fine job with both manufacturing and product support. The one exception is that I did include a link to where you can find the Rec-Tec mini. That’s Rec-Tec’s answer to the smaller, tabletop or tailgating models.
Thank you for stopping by to read this article pertaining to Pellet Grill Reviews. If you’re here, it’s likely you’ve already read a few reviews about pellet smokers. As such, you’re in the process of figuring out whether Pellet Smokers are a good choice either for personal backyard BBQ cooking or as a means of getting started on the BBQ competition circuit.