All the talk about made in China...... well it could have likely been made anywhere and inside the hopper it says "Tested". Well the LED display does not work correctly, i.e. not all the letters have all the LEDs light up to correctly state the temperature. The frame had a crimp in it on the front and when I closed the lid, it cam down crooked. It was not put on square with the grill. The warranty says that defective parts will be replaced, but the defective part has to be returned, pre-paid by me. That is B.S. This adds to my cost of the grill. Unless they pay for the return of parts, then it will just be fully returned to Amazon.
I think a lot of reviewers here don't have enough experience in pellet grilling to recognize how many features are packed into this unit for the money. I'm not going to talk about the usual advantages of pellet grilling in general in this review (i.e., clean flavor, "set and forget", less ash,). Instead, I'm going to focus on what makes this one uniquely better than the other grills in it's class.

The Woodwind is a Pellet Grill for the connoisseur. Along with a high price tag come all sorts of fancy extras, from a specially constructed 'sear box' to a lever-operated cleaning system for removing wood ash. It's roomy too, with over 500 square inches of cooking space so whether you're cooking for one or smoking several racks of ribs at the same time, the Woodwind will get the job done.

This grill is mounted on a bracket with a sawhorse design with wheels that provide it mobility in all terrains. It has a steel construction with a powder-coated finish, giving it a great look and a sturdy body. It has a hopper capacity of 18 pounds but it’s enough to continuously cook and smoke food in its 380 sq. inches of cooking area. Its porcelain-coated grill grates give you a no-rust and non-stick cooking experience that you won’t forget.

In some ways, it’s surprising that something so small could be the culprit behind so many problems on a hi-tech cooker like a pellet grill. Then again, pellets are your grill’s fuel and using bad pellets is like using subpar charcoal in a kamado, and it can cause the same problems—too much ash is produced, making it hard to hold a steady temperature and snuffing out the oxygen supply to the fire.

In smoke mode the controller is no longer controlled by the thermometer, it merely switches the pellet feeding auger on and off. On time is 15 seconds, off time ranges from 45 seconds at P0, to 165 seconds at P15. Temp and smoke are controlled by the duration of off time: the auger always runs at the same speed. More smoke is produced at higher P settings and lower temp settings because longer off times allow the pellets to smolder. At P0 in smoke mode or "High" in cook mode the auger replenishes the pellets at a faster rate, creating more flame, less smoke.
Your choice of the pellet can also dictate how much cleanup you’ll have to deal with (even though generally 10 pounds of pellets can produce at most half a cup of ash, but this varies from pellet variant to pellet variant). Just be warned that when the temperature is high, there’s not much smoke happening, so you need to smoke out your meats at lower temperatures to get that smoky flavor.
All of GMG’s like of product lines like the Daniel Boone and Jim Bowie come with similar features. In fact, the Daniel Boone will always be a better alternative to the Davy Crockett. However, the Daniel Boone line isn’t winning any spot in our budget pick due to its higher price tag. With its build and quality, it does become one of our honorable mentions, if not the pick; and the Davy Crockett continues to be the top choice for the grillers on budget.
Many of the models require you to clean them up for 30 minutes because you have to take out the gooey deflector plate and the greasy grates in order to scrape them off and wash them until they’re shining. Careful cleaning is required when the grease and carbon are covering the deflector plate. The easy-clean grills typically make the parts more accessible but the amount of cleanup remains the same.

Aside from durability, a well-built pellet grill has another significant advantage: It will perform better. High-quality materials and good construction allow the grill to retain heat better, making it more efficient and providing better pellet consumption, even in cold weather. Furthermore, it's unlikely that a brand offering a cheaply made grill invested much time designing it to maximize airflow or engineering a control board that can hold a tight temperature.
With the traeger, rec-tec or cam chef smokers all seem to burn 1-2lbs per hour. But for a long 18hr brisket it seems like I will have to continue to use pellets the whole time to keep the heat in range over over 200 which will mean I am using almost a 20-40lb bag depending on the time year per smoke. This is even more expensive than the bradley seems even with the wasted briquette. IS this correct or is there something I am missing?
Another option is to put a griddle (or GrillGrates) on the pellet smoker when it's cranked to high heat, get it blistering-hot, add just a little oil to prevent sticking, and sear by conduction on the metal. It should take only two to three minutes per side. This is a good technique for reverse-seared meats: You start them indirect, low and slow on the cooking grate, with a little smoke, and then sear the surface with direct contact to the hot metal griddle to create a delicious brown crust. It's not as good as searing directly over hot coals or gas, but it's a good compromise.
Pellet grills come in various sizes from the portable types for tailgating to the extra-large units for commercial use. If you are someone who wants to be able to take your smoker on the go, be it camping, partying or any other event you’ll want something that’s easy to lift and has wheels to facilitate movement. If you have lots of parties and gatherings at home, then you might want something bigger. Its all up to what your needs are.
Thanks for the great information and the research you did. I am a retail store owner in Boise, Idaho area and we sell a pellet grill smoker in our store. I would like to encourage to look at the Sawtooth Pellet Grill. It is made local here and is American Made. It is an excellent grill for the price with an awesome company backing it. You can find their website at sawtoothpelletgrills.com. Again thanks for the information and if you do another publication regarding pellet grills, I would love to see what your opinion of the Sawtooth would be 🙂
The little cooking space is sufficiently sizeable to help you cook meat for a little gathering of individuals or a family. It can without much of a stretch hold 12 burgers, 2 chickens, 18 wieners and 3 rib racks advantageously. Generally on the off chance that you’ll be grilling for a bigger gathering, then you might need to consider a greater BBQ. Traeger BBQ 155.01 is composed of a side table for comfort when you have to place things on a surface. This grill is among many grills with a front mounted rack, yet in the event that you like a grill with a front shelving, simply ahead and get it.
There is no party like a backyard grill and BBQ party on a hot summer weekend with some good music on the back, and of course the centerpiece: the food. You see, food is a universal language. It is a way to say how much you appreciate and care for one another; a way to people’s hearts. And there is nothing more comfortable, warm and heart than some good old open grill and BBQ cooking on your pellet grill. And this is the reason you need an expert pellet grill review. 
The Z Grills Wood Pellet Grill and Smoker comes with Smart Smoke Technology, which lets you set and forget your grilling. It accurately sets and maintains the desired temperature using an automated electric feed system, heating your unit from 180 degrees F to 450 degrees F. We’ve gotten used to smokers taking around 30-40 minutes to heat up, but with this unit, it took only 20 minutes for the temperature to settle in!
Craft amazing wood-fired creations with the Traeger Lil' Tex Elite 22 pellet grill. From grilled steak, to smoked ribs, and even a freshly baked apple pie, the set it and forget it ease of use allows any home chef to cook it all. Swap the gas and charcoal barbecue for 100% pure hardwood pellet flavor and grill, smoke, bbq, bake, roast, or braise a masterpeice.
It's true that even the entry-level models of pellet smokers are a bit pricey. But I've never met an unhappy pellet smoker owner, even if they paid a few hundred bucks more than the cost of their neighbor's grill. And manufacturers are rising to meet increased consumer demand, with more selections, more features, and more competitive pricing. While many folks struggle trying to get cheap offset and bullet smokers to work, with a pellet smoker, it's easy to make the best smoked ribs, brisket, and pulled pork in the neighborhood.
Traeger Smoker – Buyer beware. My Traeger stopped working both times I’ve used it. It just stops after about 2 hours. Traeger’s response is their pillory is they don’t make refunds. The nearest service is 3 hours away and it’s just too far for them. They said the solution to it stopping is for me to partially disassemble it when it stops and vacuum out the burner pot. They said they would talk me through some troubleshooting. They offered to send me replacement parts but said they don’t think it will help. I can’t return it, they can’t determine a fix for it. I’m supposed to just eat the $830 cost for a smoker that doesn’t work.
If you’re one of the serious barbecue enthusiasts, you would not want to leave any stone unturned to get your hands on the best of the best pellet smoker the market has to offer, in that case, you need the REC TEC Wood Pellet Smoker. The REC TEC has a large surface which takes care of all sizes of cuts, the thermostat maintains the temperature and ranges all the way from 180 F to 500 F. It has been leading the market for so long that the company now provides warranty for 6 years.
Thanks for your question! I think you’ve actually selected the grill that I’d recommend too. The Camp Chef pretty much has it all. It’s quality, it’s priced nicely, it does a great job smoking… and honestly, that ash cleanout feature is pretty much something that I wouldn’t want to do without. Especially if you’re new to pellet grilling, anything that makes the job smoother and simpler will be appreciated!
You want longevity in a pellet grill: As the Traeger brand name has been around for a few decades, you can have some peace of mind that you’re purchasing a grill that should have replacement parts available for the foreseeable future. And Traeger grills tend to have good longevity ratings, working in top condition for several years, as long as you follow the manufacturer’s maintenance recommendations.

Hi Mark – I’ve not personally used the Smoke Hollow Pellet Grill you mention here. The base model pellet smokers I see at stores like Sam’s and Costco are going to do fine for most backyard cooking preparations. I’d look into what the Smoke Hollow folks offer customer service wise. When you buy at the lower end, understand that the unit might not enjoy the longevity or durability of other mid-tier or higher end models.
One option is to put a griddle or a frying pan on the grill, high heat, get it blistering hot, add just a little oil to prevent stickling, and sear by conduction on the metal. It should only take two to three minutes per side. This is a good technique for reverse seared meats. You start them indirect, low and slow, with a little smoke, and then Maillard the outside in a hot pan or on a griddle. No, it's not cheating. It's making food better.
Hey Brad, you’ve got 3 great grills there. Rec Tec has the edge on Pellet quantity. I like the build quality and support on the Grilla a bit better, especially with the extra insulation and updated comp wheel set up. Figure 10 min or so to get to top temps. Just remember to drop to around 300 F temp setting before going into the shut down cycle on any pellet grill if you’re cranking it up to the highest setting.
Pit Boss Wood Pellet Grills are fueled by all natural BBQ wood pellets. The digital control board ignites the grill and allows you to set the cooking temperature from 180° to 500°F. Fan forced convection cooking eliminates the need for a rotisserie and creates a versatile environment for grilling, roasting, smoking, braising, searing and baking. The 820 features a Flame Broiler as standard; this adds the option to grill directly over an open flame when direct heat is needed. The Pit Boss 820 features a large 820 sq. in. total cooking surface: 580 sq. in. main and 240 sq. in. removable upper rack. With complete structural strength and durability, the Pit Boss 820 is made to last.
Up next to find its place in our pellet grill review is the REC TEC’s mini portable pellet grill. It has a 341 square inch cooking surface with 180 degrees to 550 degrees Fahrenheit temperature limit, with 5 degrees increment. But it can easily reach 600 degrees Fahrenheit in full mode. It has a satisfactory pellet hopper capacity and has folding legs. It is great for travel and movement as it is compact and small in size.
We have shifted to a new house and here we have a very nice backyard. We were thinking of having pellet grill for the backyard for friends and family gatherings for making our holidays memorable. According to your review I think Camp Chef SmokePro DLX Wood Pellet Grill and Smoker | PG24B will be a good option for us. Do you have any other suggestion for us as it will be our first and we don’t have much knowledge about it.

The flame broiler uses a digitally controlled burn system. Its Digital Control Center lets you set the temperature ranging from 170F to 600F with ease. The desired temperature is set and maintained through an electric auto-start and fan-forced air mechanism. These, in addition, give that flavorful smoky taste to all of your foods. The auger automatically feeds pellets into the smoker, so you can pretty much let it take care of everything.
I was so excited to get this grill for the weekend. It was easy to assemble and get going. It has a great place for me to keep my bbq tools and a front rack to set stuff down so I am able to easily put things on and off the grill. We made steak and lobster tails and they could not have turned out better and it came with a cookbook to know exactly how to do it!
I've been BBQing and pit smoking for many years. About 4 yrs ago I tried out pellet grilling with an import brand, and had to rebuild and replace parts for 3 yrs until it was no longer worth it! I started looking at the YS640 about a year ago, and finally pulled the trigger on buying one. No gimmicks, No hype, this is the finest backyard pellet grill/smoker and wood fired sear machine on the market. The YS640 would also be right at home on the competition circuit as well. As many other reviews have stated, if your thinking about buying one, just do it. You will not be disappointed. Shes built like a tank and holds temp very consistently. From start to finish the staff at ATBBQ has been outstanding and professional, the unit arrived in only 1-1/2 weeks and was packaged securely on a pallet. Great American made product, and great customer service have made this one of the best purchases we've made in years, Thank you.

It can be said often enough: the best pellet grill is the one that's best for you. Ultimately, you're the one paying for it and you're the one who will be cooking on it, so make sure whatever pellet grill you choose is the one you'll be happy with. Just because you're friend has no qualms paying top dollar for the most advanced grill on the market doesn't mean you should feel bad about spending half as much on a grill that does the things you want it to do. The best advice: do your research, be informed, and know what you're purchasing. If you can do that, you're unlikely to experience buyer's remorse.


Many products have a problem at some time in their life. My Yoder 640 was one of those products. Here is what is different. You all know that sinking feeling when you have a problem....and get ready to call customer service. We sort of steel ourselves to be prepared for the response....or actually, lack thereof. NOT AT YODER. After fully explaining my problems to Joe, he and his company completely exceeded my expectations. My customer service experience was world class - rivaling famed LL Bean, Amica Insurance and other. This is old honor. They better be careful though.....this kind of customer service is going to create raving customers and more business!~


For beginner outdoors chefs and guys buying their first smoker, that’s an invaluable bit of knowledge. Knowing that no matter what you do, as long as you follow the standard set up, you’re going to produce professional quality meat with ease, which is why smokers like the ones below are the best choice for anyone looking at buying their first pellet smoker.
What’s more, as Pellet Grills are electric-powered and regulate their own fuel intake, they are a far more foolproof option than other smokers and grills which may require a large amount of maintenance and care during the cooking process. Wood pellets themselves are also incredibly versatile. Aspiring smokers can experiment with a whole array of wood varieties in order to explore the flavors that each lends to meat.
To your question regarding Traeger, I’ve not reviewed their grills of yet. I do know that Traeger as a company is taking steps to up their game some, as quality/reliability of their pellet grills has diminished over the last few years. The new CEO – Jeremy Andrus – they hired comes from the Skull Candy company and brought that headphone company from annual sales from less than $1 million to nearly $300 million. I know also that a few big hitters in the BBQ world are being contacted by Traeger to bring the brand back to its former prominence. You can read more about that here from the site of one of the company’s that now has an ownership interest in Traeger: http://www.trilantic.com/News_Story.aspx?StoryType=1&ID=56.

I have owned my YS640 for about 9 months now. Before I bought this I researched smokers/grills for about 2 years because I had very little experience with them & cooking in general. With the help of a few good websites I have produced some great food. There is a ton of room to cook on & the heat stays pretty much where you want it. Only a few issues I have had is that where the stack mounts to the side of the grill it drips. I did have a scratch on mine from the shipper & when I called about it I was sent a can of matching high temp paint very quickly. One thing that I like the most about this smoker is it is heavy. You can tell that this thing was built to last.
To sear a steak you need direct radiant heat. I don't care if you can heat the air to 1000°F, it is still indirect heat and that does not deliver as much energy as direct radiant heat. It's physics, but not hard to understand. In short, heat is not the same as temperature. It feels hotter at 80°F if the sun is shining on you than if it is 80°F in the shade. I discuss the concept in more detail in my article on thermodynamics of cooking.

While the Traeger Lil-Tex does offer similar features as our top pick, such as a digital LED temperature control system and an auto-dispensing auger, there was one missing feature which we thought was necessary. This product has a smaller grilling area and lacks a removable upper rack, which gives you less grilling and prep space. I should mention that the unit does come in a bigger 700 square inch version for $200 more, as well as a smaller version that costs less. If this smoker is too big or too small for you, there are always other options available. Compared to our top pick, it’s also more expensive despite offering similar specs. Aside from that, this is a very efficient and reliable smoker – might even have been the best if our top pick wasn’t available on the market.


Pellet grills have a couple of very distinct advantages and disadvantages. The best can hold a constant temperature more or less indefinitely, provide even smoke at low temps, cook w/o smoke at high temps, make it possible to evenly cook several different meats and do a good job at two zone cooking. The Yoder excels at these. It is built like a tank, easy to use and I love it. One drawback for some pellet grills is the inability to reach high temps and sear. With the GrillGrates I have reached almost 600F and can sear with the best of them. Drawbacks. Well, it is a bit tricky to clean, but I guess I am keeping it cleaner than I did my previous grills!
Cleaning and Maintenance: Keeping the grill clean is critical if you need to get the most out of the unit. Old debris can influence the viability of the unit thus normal cleaning is vital. In addition, while moving it around, take alert not to thump it since it accompanies little legs which can without much of a stretch tip over the unit when thumped.
Rubbery skin has very little to do with the type of heat (direct vs indirect). Rubbery skin is a result of too low a cooking temperature. Take your smoker/grill or whatever you use and get the temperature in the mid 400’s or even higher and you will get crispy skin. One thing though never let the internal temperature of your bird get over 150 or you’ll have crispy skin and dry crunchy meat too. Take it off the grill and let is rest a full 30 minutes. Best bird you’ll ever eat no matter which grill, smoker, 50 gal barrel, etc you cooked it on.
×