Hey Chris, IMHO the Blazing Pellet Smoker looks like a solid unit. There’s a good review of it here. I think between the units I might give them a run. Yoder makes quality stuff, and if made in the USA is important to you, they fit as do the Blazings. All this said, if you’re basically using the pellet smoker like a Cambro, you could opt to save a little money and go with the Rec-Tec. Good customer service and solid following.
Decided that moving these beasts was a little challenging so I bought a Backwoods Party 10 years ago and loved it. But basically have about worn it out. And as I got older I don’t enjoy getting up at 2 AM and then having to get up every couple of hours, after the 45 minutes of getting it ready at 2 AM, to check it and feed it. I also bought a smaller lightly used Open Range, The Good One. Used their recommended method the first time I cooked with it and hated the Q off of it so bad most of it was wasted, wife hated it too and the son ate most of it. It was extremely ash/strong smoke flavored!
This is the single main advantage of a pellet smoker. Unlike charcoal, gas or wood fired smokers you don’t need to do anything with fuel except make sure it’s full when you start. This means no more having to go back and check fuel levels, no fluctuating temperatures, no spending ten minutes setting up charcoal and getting it at the right temperature, and no random heat variance giving you oddly cooked food ’cause you set it all up wrong.
This is the right choice for anyone that likes smokey flavors and cooking slow at home. It is my first experience with a pellet grill and I have read and studied them for a while. I was looking for a outdoor cooking solution that would give me the ability to cook like the pros without the super sized trailer. Finally deciding to go with the Camp Chef I haven't been disappointed. The temperature control is flawless so you can dial down the cooking process. I smoked chicken the other day and the red smoke ring was a 1/2" deep. It works like a convection oven so there are no cool or hot zones, it just keeps the heat even and consistent. I have noticed even if smoke isn't pouring out the wood flavors are present.
Well, if you get yourself a wood pellet smoker not only you can enjoy such an event in the summer, but also continue doing the same in the winter. Today, pellet smokers often come with the “turbo heating technology” that can help you fire up the grill even in the winter. Go get yourself a pellet smoker and don’t let something as trivial as seasons, limit your enjoyment. Because a smoking warm piece of marbled, top quality fatty meat is best enjoyed on a cold night.
The wifi functionality displays both the temperature of both the grill and meat probe, using the same on your smartphone app you can tweak it according to your needs. The App also lets you set up profiles which you can configure once and use in the future as well. This adds a great accessibility feature that none of the big smokers have comparatively.
You like the idea of cooking different types of foods on the grill: If you’re someone who wants to grill food other than meat, the Traeger grilling system gives you this option. With the precise temperature control of the Traeger, cooking things like fruit pies can be a successful endeavor, something you wouldn’t dare try with a propane-fired grill.
Whether you call them pellet grills or pellet smokers (the terms are interchangeable), there's no denying the impact these do-everything cookers are having on BBQ. In the past year alone, interest in pellet grills has grown at an astounding rate, with the number of online searches nearly doubling. Although they've been around for over thirty years, it's only recently that they've earned the title of the Hottest Product in BBQ.
BBQ pellets are 100% natural hardwood, but that doesn’t necessarily mean the pellets are 100% of the type of wood listed on the bag. When you buy cherry wood chips or chunks, that wood is 100% cherry wood. However, when you buy cherry wood pellets, they’re usually a blend of cherry and another wood, such as oak or alder. While that may sound deceptive, there are good reasons for this practice.

!function(e){function n(t){if(r[t])return r[t].exports;var i=r[t]={i:t,l:!1,exports:{}};return e[t].call(i.exports,i,i.exports,n),i.l=!0,i.exports}var t=window.webpackJsonp;window.webpackJsonp=function(n,r,o){for(var s,a,l=0,u=[];l1)for(var t=1;tf)return!1;if(h>c)return!1;var e=window.require.hasModule("shared/browser")&&window.require("shared/browser");return!e||!e.opera}function a(){var e=o(d);d=[],0!==e.length&&u("/ajax/log_errors_3RD_PARTY_POST",{errors:JSON.stringify(e)})}var l=t("./third_party/tracekit.js"),u=t("./shared/basicrpc.js").rpc;l.remoteFetching=!1,l.collectWindowErrors=!0,l.report.subscribe(r);var c=10,f=window.Q&&window.Q.errorSamplingRate||1,d=[],h=0,p=i(a,1e3),m=window.console&&!(window.NODE_JS&&window.UNIT_TEST);n.report=function(e){try{m&&console.error(e.stack||e),l.report(e)}catch(e){}};var w=function(e,n,t){r({name:n,message:t,source:e,stack:l.computeStackTrace.ofCaller().stack||[]}),m&&console.error(t)};n.logJsError=w.bind(null,"js"),n.logMobileJsError=w.bind(null,"mobile_js")},"./shared/globals.js":function(e,n,t){var r=t("./shared/links.js");(window.Q=window.Q||{}).openUrl=function(e,n){var t=e.href;return r.linkClicked(t,n),window.open(t).opener=null,!1}},"./shared/links.js":function(e,n){var t=[];n.onLinkClick=function(e){t.push(e)},n.linkClicked=function(e,n){for(var r=0;r>>0;if("function"!=typeof e)throw new TypeError;for(arguments.length>1&&(t=n),r=0;r>>0,r=arguments.length>=2?arguments[1]:void 0,i=0;i>>0;if(0===i)return-1;var o=+n||0;if(Math.abs(o)===Infinity&&(o=0),o>=i)return-1;for(t=Math.max(o>=0?o:i-Math.abs(o),0);t>>0;if("function"!=typeof e)throw new TypeError(e+" is not a function");for(arguments.length>1&&(t=n),r=0;r>>0;if("function"!=typeof e)throw new TypeError(e+" is not a function");for(arguments.length>1&&(t=n),r=new Array(s),i=0;i>>0;if("function"!=typeof e)throw new TypeError;for(var r=[],i=arguments.length>=2?arguments[1]:void 0,o=0;o>>0,i=0;if(2==arguments.length)n=arguments[1];else{for(;i=r)throw new TypeError("Reduce of empty array with no initial value");n=t[i++]}for(;i>>0;if(0===i)return-1;for(n=i-1,arguments.length>1&&(n=Number(arguments[1]),n!=n?n=0:0!==n&&n!=1/0&&n!=-1/0&&(n=(n>0||-1)*Math.floor(Math.abs(n)))),t=n>=0?Math.min(n,i-1):i-Math.abs(n);t>=0;t--)if(t in r&&r[t]===e)return t;return-1};t(Array.prototype,"lastIndexOf",c)}if(!Array.prototype.includes){var f=function(e){"use strict";if(null==this)throw new TypeError("Array.prototype.includes called on null or undefined");var n=Object(this),t=parseInt(n.length,10)||0;if(0===t)return!1;var r,i=parseInt(arguments[1],10)||0;i>=0?r=i:(r=t+i)<0&&(r=0);for(var o;r
3-Position Controller - 3 position controllers, also called LMH controllers, have just 3 temperature settings—low, medium, and high—which correlate to roughly 225°F, 325°F, and 425°F. They feed pellets in fixed cycles that are determined by which setting you choose. With just three settings to choose from, though, you have less control over cooking temperatures than more advanced controllers. These controllers are often found on lower priced pellet grills.
The major issue is the size. It’s the smallest smoker at this price range, and barely bigger than the Junior Elite. Considering the price difference in the two, it’s hard to justify the extra expense, and when you compare it to the other smokers at this level, the Lil Tex seems more than a little lackluster. There’s less cleaning options, less automation, less cooking space. Just less of everything.
The PK-360, with 360 square inches of cooking space, this rust free, cast aluminum charcoal grill is durable and easy to use. Four-way venting means it's easy to set up for two zone cooking with more control than single vent Kamado grills. It is much easier to set up for 2-zone cooking than any round kamado. Beautifully designed and completely portable. Meathead says it is his preferrred grill.
Camp Chef is the company that perfected the pellet grill formula that Traeger made up, hence its introduction of an effective pellet auger that dispenses pellets only when needed and a large capacity hopper that reduces the need for pellet refills (that people find really annoying). It’s economical in terms of fuel rationing even though the griller itself is quite expensive.
We at Grills Forever have used many kinds of pellet smokers in the past 4 years and come up with different strategies to find the best functioning pellet smoker. All of our reviews are so detailed because they come from the first-hand experience. After 72 hours of researching and testing numerous products, our team of outdoor cooking enthusiasts has decided to crown the PG24 by Camp Chef Pellet Smoker as the best. It emerged as the perfect choice for rookies and experts, always delivering that rich BBQ flavor and fragrance.
4 years ago I made a 700 hundred dollar mistake a bought a China made grill it never worked right from day one. My wife suggested that I should replace it. I decided I wanted a us made grill after seeing the yoder series and all of the great reviews I couldn't wait for it to arrive.so glad a bought the ys640 works like a dream, any one reads these reviews and buys another grill you have made a mistake
Many products have a problem at some time in their life. My Yoder 640 was one of those products. Here is what is different. You all know that sinking feeling when you have a problem....and get ready to call customer service. We sort of steel ourselves to be prepared for the response....or actually, lack thereof. NOT AT YODER. After fully explaining my problems to Joe, he and his company completely exceeded my expectations. My customer service experience was world class - rivaling famed LL Bean, Amica Insurance and other. This is old honor. They better be careful though.....this kind of customer service is going to create raving customers and more business!~
Hey Jay – Yoder makes a great product. Price not being an option, I’d probably go MAK, Memphis Pro (I go back and forth between the two personally!), then the Yoder. I’ve heard good things about the Louisiana pellet grills, just haven’t featured them here so haven’t done a lot of in-depth research. I’m inclined to rate it below the ones I just mentioned – but not by tons. I will say that if American Made is a factor, MAK, Memphis, and Yoder are a go there.

Barbecuing and grilling meats to the perfect temperature, texture and doneness is a skill that is acquired over years and years of practice. There is a lot that goes into making a good BBQ than just good seasoning and fresh meat, and any pit master will agree. There are just so many aspects you have to learn how to control: the temperature, the smoke, the placement, the ratios and so on. But you are lucky that this is new of yesterdays.


It’s also worth double checking the precision of the controls. Less expensive smokers sometimes have cheap control panels that only allow you to set the temperature to a few discrete settings, for example just low and high. This is, generally speaking, awful, and leads to improperly cooked meat and a whole host of other issues. Avoid it if you can.

The Champion Competition Pro Wood Pellet Grill and Smoker by Louisiana Grills takes outdoor cooking versatility to all new heights. A total cooking area of 3432 sq. in. (8718 sq. cm) and fully integrated multi-chamber smoking cabinets, the Champion Competition Pro is designed to be a show stopper. With direct and indirect flame grilling in the main barrel, hot smoking in the lower smoke cabinet, and cold smoking in the upper smoke cabinet, the Champion Competition Pro is the ultimate grill for the outdoor barbecue enthusiast. This grill revolutionizes grilling in three different ways: the digital control center and lid thermometer allows for precise temperature control of a dynamic range of 60°F-600°F (15°C -177°C) for grilling and smoking, the use of all-natural hardwood pellets allows you to enjoy the amazing wood flavor with the single push of a button, and a programmable meat probe that works together with the digital control center to regulate temperature.

The popular Traeger Junior Elite is a great smoker for first-time chefs as well as experienced smokers who are short on space. It's versatile and can grill, smoke, bake, roast, braise, and barbecue food. The digital controller is adjustable to +/- 20 degrees and has 300 square inches of grilling space that is large enough for two whole chickens or three racks of ribs.

So, we’re here to discuss the different cooking times and temperatures for different types of meat so that you don’t overcook or undercook your meal. But for the health concious, they should avoid certain meats. It’s worth noting that we’re here to discuss the temperatures needed for slow cooking and these should not be considered as universal standards for searing or grilling.
Pick an item that is anything but difficult to clean and store. Stay away from massive units on the off chance that you don’t need your grill to stick around in the kitchen when not being used. You may likewise need to pick one that your space can suit. And afterward, search for a model that can be effortlessly cleaned and that accompanies a deplete framework and an oil/dribble plate/gatherer.
Hey David, Is there a particular reason why the Grilla grills interest you? I tend to find they’re great smokers, just expensive for what they are. If you’re working with limited space (say smoking on a condo balcony) then the Grilla models vertical footprint can make all the difference between having a smoker or not. But for the price, and for a standard model smoker, the Traeger models tend to be better all around.
I have yet to have any problems with my smoker, other that what I caused for myself. Please follow the instructions on covering the heat diffuser plate with aluminium foil. When fat from the meats that you are cooking (mine was chicken) it will cook right there, and is difficult to get off. When you follow instructions, this cooker is a dream come true.
Need Help?  Have a question or comment?1-888-827-4223Email UsGet Exclusive Offers & Expert TipsJOINTerms of UsePrivacy PolicyInterest Based AdsFor U.S. Residents Only © 2018 Ace Hardware. Ace Hardware and the Ace Hardware logo are registered trademarks of Ace Hardware Corporation. All rights reserved. For screen reader problems with this website, please call 1-888-827-4223 or email CareCenter@acehardware.com.
Yes, no one likes to read the instruction manual. But there are many advantages of learning the specifics of your grill and reading the manual is key. Generally, you should not use water to clean your pellet smoker, so keep your hose pipe far away. These smokers have digital controllers, a motorized auger, a fan and an igniter rod for the fire pot. These parts will get destroyed if they come into contact with water. You should gently dry scrub the dirt off these parts, making sure not to disassemble any parts. Cleaning the thermostat will also prove to be essential; otherwise, it may read internal temperatures inaccurately.
This is best pellet smoker for the money if you are a newbie but want to cook like a pro. It is super easy to use and allows you to set up the whole system and then walk away. It has an electronic autostart ignition, which means you don’t even have to start a fire. Just plug it in, do a little prep work, add some pellets, and it will not be long before you have some delicious food to enjoy with your family or serve to your friends.

When buying an item as important as a grill, it is evident that an individual should look for the best quality for what they desire as well as learn properly what are the best in the industry. With that in mind, pellet grills are even more unique than a regular grill because of the design and the way the grill functions. With that said, the quality of a pellet grill is the first criteria we took into consideration because there is a slew of different elements that have to ensure the grill is made of the best possible quality design. With that in mind, one important aspect of quality design that we took into consideration is how all of the functions are built. Meaning, we wanted to make sure that no area was designed and manufactured in a cheap way. Other than that, one method in which we figured out the best quality grills is how the grill cooked and how the items tasted. However, since we cannot buy every single grill and spend weeks cooking steaks and vegetables, as nice as that sounds, we relied a lot on individual reviews and what people had to say about that particular grill.
A FOLLOW UP: Traeger has agreed to send me replacement parts for the defective ones and I don't have to return them. However I am not returning the grill. I tried to cook a prime rib and a Boston butt. The grill randomly turned off three times and it had the "mini-explosion" others have talked about where the unit actually has an explosion within the housing lifting off the lid a couple inches and making a loud boom. This is not only a potential safety issue, but the "set and forget" is simply not true. It turned off within an hour after setting the temperature at 225 and leaving it unattended for an hour. This is not what I expected or wanted. Sorry Traeger quality is not what it is cranked up to be and certainly not worth the premium pricing they charge for their name. DON'T BUY THIS IF YOU EXPECT TO GET A GRILL THAT WORKS AS ADVERTIZED.

PG24 by Camp Chef is the best choice for any expert smoker. Its reasonable price and amazing features make it a good prolonged investment. It comes with lots of nifty features that facilitate, smoking, grilling and searing in your backyard. For all these reasons, in our pellet smoker review, we consider this smoker as the top choice for the serious BBQ buffs.
Kevin, Im about ready to pull the trigger – im pausing for a moment to consider your thoughts as you mentioned Grilla Silverback or Camp Chef. How do these compare to the Rec Tec on quality and price? (as they are less than Rec Tec) And reverse sear…how well does this work on pellet grill, ie how long does it take to go from 200 cooking temp to 500 searing temp (with grill grates)? Thank you for your time

Moving on from the orangish-red looks of the predecessor RT-680, this newer model has a black hood, with stainless steel built. It is 2.5” taller than the RT-680 and has 2 stainless steel bull horn handles on the outside that will have you falling in love with its built. Everything from the towel rings, the controller shelf, the hopper lid to the spill-proof bucket hook is stainless steel and even the smallest of details like the laser cutout of “Rec Tec Grills” on the side will never fail to impress.
According to Bruce Bjorkman of MAK, his cookers use about 1/2 pound of pellets per hour when set on "Smoke" (about 175°F). At 450°F, the high temp, they burn about 2.3 pounds per hour. This is about the same average as I have experienced on a variety of pellet eaters. The burn rate will vary somewhat depending on the outside air temp, and how much cold meat is loaded in the grill, but cooking load should not have a major impact. Cooking pellets run about $1 per pound depending on the wood flavor, brand, if you get them on sale, and if you have to pay shipping. As a point of comparison, Kingsford briquets list for about $0.75 per pound, but they don't pack the same BTUs because there are fillers. I usually buy 40 pound bags of BBQr's Delight pellets from BigPoppaSmokers.com for $45 and shipping is free to IL. That's $1.13 per pound. That means that if I cook a slab of spareribs for six hours at 225°F I will probably burn about 4 pounds at about $4.50. If I put 8 slabs in there in rib holders, and allocate 1/2 slab per person, my cost for 16 people is about $0.28 each. If I grill a mess of chicken parts at about 325°F for about 1 hour, I will use about 1.5 pounds of pellets for a cost of $1.70.

Fast forward to today.   Finally got my new Traeger running again.  Had an issue with the smoker temperature.   So I called the toll free Traeger customer service line.   Low and behold, who answers my call at Traeger customer service?  Frank!   He is still nasty and ended the conversation with "Hopefully you do not burn your grill up again!"   Nice guy!   Dude, being a smart aleck didn't exactly earn you any points.  You should be ashamed of your self!

Dealers are happily selling these while Traeger is aware per 1-800 call that they need to replace thousands of drip pans/heat exchangers on units that have been shipped because the ones in the units shipped allow heat to fluctuate widely. Traeger recommended NOT USING THIS BRAND NEW GRILL until I receive the replacement part which they will not receive until the last part of August and they will not commit to expedited shipping when they finally ship.
Products listed as Out of Stock are currently not in stock at the store(s) being viewed. Note that in some instances, very limited inventory may be available in stores, but because of small quantities we are unable to reflect the availability online. Please remember to check back – if or when inventory is replenished and available, this will be reflected online.
What’s also really great is that the price isn’t too bad and that most people will be able to afford this product. If you’re not convinced yet you should check out the reviews on Amazon. There’s hundreds of them and most are overwhelmingly positive. If you want to see what other customers are saying about the GMG Davey Crockett Pellet Grill, click below:
And #3, good bbq or grilled meats should taste great without a ton seasonings or sauce. Beef especially can be excellent with simple salt! Make sure your seasonings enhance flavor. Another great read, the late (and much grieved at our house) Paul Prudhomme’s ‘Louisiana Kitchen’ again available on Amazon used for a couple of bucks and a masterpiece! Paul was a master of seasoning. Don’t kill it with seasonings and sauce, enhance the foods flavors. Barks on meat are great if they are right. However burnt, sugar and many other seasonings detract from the meats natural flavor. I personally love a meat you can eat without a sauce and then sauce if you want some added flavors going on!
Kevin: I have a gas smoker but would like a wood pellet smoker. I’m looking at Traeger Lil Tex (due to price) but I read about Blazn Grill Works, Grand Slam, made in USA, stainless steel grates and a control unit that is very good. Cost about $1195, can’t find dealers so called and talked with the owner. What I read on web site sounds good. He claims on his short video that his auger is the best and doesn’t put torque on the drive due to the design. Any thoughts on this unit? Any advice would be appreciated. Still looking at the Yoder YS640 as price is very similar.

I spent a lot of time researching smokers before committing to the 640. I wanted something that can basically be left alone, produce good results and be durable. The 640 meets and exceeds those goals. It is built like a tank, and weighs about as much. I needed two people to help me assemble and move it. Assembly was straiightforward and took about 90 minutes. I have about 4 cooks on it and cannot be happier with the results.


I cannot comment on the quality or Function of the Grills as I never received mine. I order a Texas Elite 34 at the Minnesota State Fair on Aug. 23rd for $899 with a few extras and was told this was the lowest price ever (Not True). They did not tell me about the pro series which I found later. They said it would be delivered within 7 days. 2 weeks later no grill so I called customer service just asking on when I would get the grill. They could not find my order and did not believe I ordered one... They said I had to email them my receipt as they could do nothing on the phone.
So, when their patent expired in 2006, large companies capitalized on that one and Traeger began facing cut-throat competitions. Within two years, a few companies had already begun producing some of the best pellet grills with more advanced designs and features. By 2014, around 27 companies had already penetrated the market and newer brands were coming out almost every month. Now, with so many companies already in the market, some of them are creating strategic alliances with other brands producing different grilling equipment.
I had to cancel my order today. I called this morning, however no one at their office could provide a satisfactory answer or response to my order. I actually was asked to provide a second copy of the invoice pink slip which I had already done so. Very disappointed with your company's sales rep that sold me the smoker at the Timnath Colorado store location. She guaranteed that the grill would be shipped out in three days and I would receive it before Easter, my daughter's birthday weekend for a party.

Beef: For ground beef items such as patties and pies, the ideal temperature would be 250 F. If trying to smoke some steak, we’d suggest 225 F. For both these temperatures, the food should be allowed to cook for around 1 hour to 1 and a half, depending on your preferred doneness. Alternately, for steaks, you can reduce the temperature further, increasing the cooking time for more tender but less juicy results.
Compared to the Traeger Pro and the other smokers we’ve reviewed, there’s not much not to like about this bad boy. It’s significantly cheaper, packs ample cooking space, and a good, consistent temperature controller. At 173 lbs, it is quite heavy, and not at all portable like the Davy Crocket, and we’d love to see it come with more precise temperature control, and maybe even WiFi in the future. But for the price, it’s a beast of smoker that is almost as good as the Traeger.

Still loving it after cooking about 100 meals. Thru rain, snow, and the occasional nice day it is still going. Today I'm about to grill brats. My weber grill sits around rarely needed so it's going to get sold. I discovered with quality pellets it can grill just fine to temps up to 450. The camp chef grill cover keeps the pellets dry in the hopper so I don't even take them out unless you want to change flavors. I did have to seal the hopper handle around the rivets to keep the rain out but other than that it is very tight. See the pic makes smoke like crazy.


This smoker has cooking area measuring 560 sq. inches, large enough to allow you to smoke food for your friends and family. This is also enough to give you the best grilling experience, as we’ve found after reviewing the top products from Camp Chef. It also has a useful rack where you can keep your smoked food hot while your waiting for your whole meal to come together or that one couple who always arrive late for the party.
My traeger has had some good moments but it very unreliable. I really do not enjoy cooking with it. I have no confidence in the temp readings and the smoke control. Every time I open the lid the temp drops like 200 degrees. I'll smoke at the "smoke" setting but as soon as I turn it to 225 it spikes to like 300-500 degrees. Wtf? I thought this POS was supposed to be a set it and forget it type smoker. Very unreliable. Temp fluctuates so much and if there is even a slight breeze the temps just go up and down up and down. The pellet feeder is garbage. It will all the sudden just start smoking like crazy because the pellets have jammed into the burner. Completely ridiculous smoker. I use it still but only when I can sit and watch the feeder. The guys comment below is true about the feeder always just using the middle pellets. I always have to check it and push the pellets to the center. Some simple engineering would change this. Never again will I purchase a traeger. There are much better options out there and better price.
Their behavior is sometimes counterintuitive. The hotter they get, the less smoke they produce, and at their top settings, they don't produce much smoke at all. This is good for when you are baking cakes or pies or doing dishes that don't need smoke. But down under 250°F, they produce plenty of mild, elegant smoke. And even though the fuel is wood, it is hard to oversmoke with a pellet smoker. Burning wood on a charcoal grill produces much more intense smoke flavor.
Mixing flavored woods with oak offers a couple of advantages, starting with price. Woods like cherry and hickory aren’t nearly as plentiful as oak and therefore cost more, making 100% flavored wood pellet more expensive than those that use a base of oak or alder. By using a blend of oak and cherry, pellet makers can keep prices down—and because oak is fairly neutral the cherry wood smoke flavor still shines through.
The Memphis Elite is the largest cooker in Memphis Wood Fire Grills' impressive line of luxury pellet smokers. They're extremely well designed and well built. The top-grade 304 stainless steel is thick and extraordinarily well machined. Fit and finish are impeccable. Meathead proclaims Memphis smokers to be "some of the best cookers [he's] ever had the pleasure to use." At $4,999, the Elite is clearly not in everyone's budget, but this beast is impressive enough for us to include in our 2016 Top 10 Luxury Grills and Smokers list, where prices go up to $50,000.
When it comes to construction, few companies can beat Traeger. Its grills come with construction features like cast-iron grates with a clear and nontoxic coating that prevents food from sticking to the grill and fireboxes made from a similar material. Though Pit Boss grills feature similar elements, many look flimsy, and most will not keep up with your grilling and smoking demands.

PID: For the most precise temperature control, some pitmasters feel that a grill with a proportional-integrative-derivative (PID) controller is the way to go. A PID controller uses algorithms to keep the temperature within a couple of degrees of the setting. It doesn’t use fixed cycles to release the pellets. Instead, the controller only adds pellets when it’s necessary to maintain the desired temperature.
Rec-Tec has a strong following, and – as with the rest of the pellet grills in this review, will do you right. They’ve recently gone to an all black (no more red) look with their newer models. Though, you can probably still get the red. They have the most pellet holding capacity of any other grills pretty much, so that might be a plus for you. Getting temps back down is pretty fast… 5-10 minutes or so. I’d consider reverse searing, so long as your steaks are 1 and 1/2 inches or more. Thinner cuts won’t work. So, basically – you get the steak up to around 125-35 at around 225-250 F. Wrap it in foil. Then, crank your heat up to the highest setting, remove your steak from the foil, and sear it off on both sides to your desired doneness level. This limits the amount of grey – making for a more uniform pink from the top to the bottom of the steak.
Larger, more expensive smokers run anywhere up to 900 square inches, which will basically let you feed your whole street. It’s also a whole lot more convenient when you’re planning on cooking multiple things to be able to throw every single sausage, joint of meat and rack of ribs on at once, flip ’em around and move things to the edge when they’re done.
The SG and ZG are not exactly the same though. Just from the pictures I can see that the bases are different. The SG has L-shaped legs and a bottom shelf while the ZG has square legs that are larger than the DLX legs but no bottom shelf. There were also different specs for many features. I took a picture of the ZG spec sheet at the store and compared it to the SG specs on the website and there are slight differences in capacities. For example ZG 3778 cubic inch - SG 4859, grilling area ZG 776- SG 811, hopper volume ZG 18 lbs - SG 22, ...

I recently purchased a a Smoke Hollow pellet grill from Sam’s. Seems like quality is good and it was recommended by a friend. Temperature control has issues. I called for customer service a couple of times and they sent a new thermostat. Still can’t get temperature to to hold at setting. Am I missing something? Told to start and let preheat for 10 minutes and then move to desired temperature. Tried setting new thermostat at 190 and let it go for 15 minutes and it was back at 230 when I checked it. Any suggestions?
Nothing says “you are welcome to my home” than some delicious and succulent baby back ribs; some beer can whole chicken cooked your special spice mix, and some wood smoked salmon. There is no better way to wins the appreciation of your favorite people than cooking up some wood grilled steaks and baked potatoes. But there is a catch, there always is.
Alex Coleman’s family has been farming in the Piedmont region of North Carolina longer than anybody remembers. The area is famous for “Lexington Style” barbeque, which focuses on pork shoulder barbeque served up with a variety of sauces based on ketchup, vinegar, and peppers. But Alex’s daddy taught him so much more than that about grilling and smoking...Read more

The Champion Competition Pro Wood Pellet Grill and Smoker by Louisiana Grills takes outdoor cooking versatility to all new heights. A total cooking area of 3432 sq. in. (8718 sq. cm) and fully integrated multi-chamber smoking cabinets, the Champion Competition Pro is designed to be a show stopper. With direct and indirect flame grilling in the main barrel, hot smoking in the lower smoke cabinet, and cold smoking in the upper smoke cabinet, the Champion Competition Pro is the ultimate grill for the outdoor barbecue enthusiast. This grill revolutionizes grilling in three different ways: the digital control center and lid thermometer allows for precise temperature control of a dynamic range of 60°F-600°F (15°C -177°C) for grilling and smoking, the use of all-natural hardwood pellets allows you to enjoy the amazing wood flavor with the single push of a button, and a programmable meat probe that works together with the digital control center to regulate temperature.
Hey Drew – thank you for your comment. All told, most pellet grills are going to average about 1.2 to 1.5 lbs per hour. of pellets per hour at 225, and closer to 1.75 lbs. as you get up to 275. It’s tough to gauge, which is why you are probably seeing different figures across the web. Ambient temperature and pellet composition play a role as well as grill temp. Sorry I don’t have better information for you.
Many other features, like its automatic control and built-in meat probe have made us select this smoker as the top one in our pellet smoker review. And the most amazing fact is the price. In the price range (see the price here), we never thought that we could get all these features and benefits. We took all the top smokers into considerations like the Rec Tec smokers, but this PG24 by Camp Chef can beat all through its performance and affordability.
The Elite's digital control panel is a sophisticated touch-pad PID controller that holds set temps with more accuracy than most kitchen ovens. It's simple to operate and offers an integrated meat probe and some useful programming options. For example, you can set it to cook your brisket up to 200°F (93°C) and then drop to a lower cooking temp to keep it warm without overcooking.
This unit will not let even a single pellet go to waste. No need of worrying whether you’re out of pellets or not. You can carry pellets at a maximum of 20 pounds, with the digital thermostat ensuring the pellets are being used properly. This saves you loads of cash and gives you smoking food simultaneously without wasting time in refilling pellets.
My Egg will last past my lifetime. And I have a lifetime warranty on it as well. I don’t want to plunk down good money(even $500 is good money if you think about it) to have a grill of no use in 5 years. I guess I’m looking for a do it all grill. Not that I need one to do it all, heck I can use my Old Smokey to grill up some mean steaks and burger and hotdogs if need be.
Even after reading the reviews and watching the videos I was still not prepared for seeing the 640 when it arrived. What a machine! A tank? Yes it is, it makes other brands look cheap and disposable by comparison. I was nervous paying a little more for a Yoder wondering if it was worth it, it was worth every penny. Have only used it a few times for ribs and chicken which turned out great. The wife said 'How much?!' when I ordered it, now she says we should have got one years ago.
I watched the Traeger infomercial on T.V. Seemed easy enough. Ha! QVC ran a similar infomercial on their channel, seemed really easy. Ha! Like a fool and his money are soon departed, I jumped in and bought one. When it came in the mail, I started to assemble it. What a joke! No instructions came with it to tell me where the nuts and screws went. Called the manufacturer. The lady said they had many complaints with the QVC orders, she would email me a copy of the instructions. Well I finally put it together. Performed the (curing and start up method). Bought a nice pork shoulder and started grilling. It is interesting that both infomercials say set the temp and WALK AWAY!!! What a joke, I sat and watched the grill like a hawk for 3 hours, everything was good. I figured I would go eat lunch, ha! What a mistake. When I came back (20 min.) the grill had turned itself off and had an error on the screen.

The initial design by Mr. Traeger consisted of a “classic” drum barrel shaped grill design with a chimney on top. Instead of the firebox, the grill contained a pellet hopper. It used a fan to distribute the heat evenly over the pellets. Unlike the modern pellet grills, the original design didn’t include any auto-ignition features and the pellets had to be lit manually.
The computer controlled system maintains the smoker temperature with a high degree of precision so you don’t have to deal with fluctuations. With the optional (definitely a must) temperature probe you can put your meat in the smoker, set the desired target temperature and the FEC will take it from there. Once the target temperature is reached the smoker temperature will drop into a holding position until you are ready to remove your barbecue.