A good pellet grill can hit high temperatures for that perfect steak and still hold a steady low and slow temperature for great barbecue. All the while adding great smoke flavor from hardwood pellets. These pellet grills cost more but do so much more while being highly efficient, precise in temperature and widely capable. Among these, you will find cookers large enough for a whole hog as well as units with full network interfaces for controlling from a distance. These are the best of the best in Pellet Grills.
All this said, I believe the girls you are looking at already will both provide you with long lasting grilling and smoking satisfaction. Honestly, when you get to a point where are your in the price range that you are in, it’s really hard to choose a bad option with pellet grills. The biggest Advantage you have over the ones you’re looking at and the Yoder models is that they are heavy built giving you excellent heat retention over your Cooks.
From among these 65 products, we have selected the top class pellet smokers out there shortlisting 18 of the best candidates. Then, we have conducted a secondary research and compared their features against each other to find the best 10. Finally, we have compiled this review list of top 10 best rated pellet smokers considering their features, reviews, ratings, review frequencies and how great they were when we tested them out during BBQ parties.
I also was a certified KCBS judge but never judged at an event. Their judging system was flawed in my opinion because if you truly follow their system it is possible that them best tasting piece of meat might not win. In cutting horses (not a judge but read all the rules as I showed a fair amount back then) you were always supposed to judge the best overall horse to win. I asked about leaving a process to make sure the piece of meat you feel is best to win and was told absolutely not you have to judge presentation points, tender points & etc. and not place based on your opinion of the best piece of meat! Not that KCBS is a bad organization, it’s rules didn’t fit my thought process. Passed their class and got the t-shirt just never agreed, was always a spectator.
Ready for the camp or cabin, this reliable, no-frills stove features two 30,000-BTU commercial-grade cast burners. The all-steel range features sturdy grates built to support hefty cast-iron cookware. It's surrounded by a three-sided steel screen to block drafts and grease splatter. The heavy-duty steel legs slide off for transportation and storage. Cooks up to 15 hours on a 20-lb. propane cylinder (not included). Includes hose and regulator.
Of all the different smoker designs available, pellet smokers are the easiest to use, because they're thermostatically controlled, like your kitchen stove. You just select a cooking temperature, and a controller maintains it by feeding wood pellets to a fire pot as needed to maintain your set temp. Set it and forget it. You can throw a brisket in a pellet smoker, set it for 225°F (105°C), go to bed, and sleep like a baby, knowing you'll wake up to delicious smoked meat.
First, it’s really easy to use, with an electric auto ignition and shutdown system, plus LED controls that make setup idiot proof. Once it’s up and burning, the built in temperature sensor and meat probe make knowing what’s going on inside simple, especially considering that the thermometer is one of the most accurate I’ve seen, with only around 10 degrees variance. It’s got multiple settings if you’re using it as a meat smoker, as well, so you can control your flavor.
Never worry about overcooking or burning your food. Masterful control of airflow throughout all chambers allows you to skillfully prepare food with savory natural hardwood flavor. Our propriety exhaust system makes for even grilling and smoking in the main grilling chamber, and sliding damper vents allow great versatility and control when using the upper and lower smoke cabinets. The fan-forced convection airflow in the main barrel allows the grill to work like a convection oven with indirect flame cooking, while the sliding plate on the flame broiler gives the option to sear a steak using direct flame cooking when desired. The removable upper cooking racks in the main barrel adds additional cooking space: cook dinner on the bottom and prepare vegetables and dessert at the same time on the top racks.

Hey Rob! First, I really appreciate you reaching out. That’s what The BBQ Beat is for! To your question, I own a Davy Crockett Tailgate Model pellet smoker and really like it. Full disclosure, it was given to me by the company to test and Jason Baker of GMG said I could just keep it. But, I get a good number of products to review sent to me and a whole lot of them don’t make it onto the blog. I’d rather “omit” than “detract” – keep things positive sharing the stuff out there that I can get behind.
To cook food using a pellet grill, put the pellets into a hopper. When you turn it on, the igniting rod will burn pellets in the fire. The motor-driven auger will then supply the fire pot with pellets from the hopper. The ratio that auger delivers pellets to fire pot depends on the settings you control. If you set it at a high temperature for a longer period of time, the auger will keep on feeding the fire pot with pellets. However, if you are slow-cooking and set a low-temperature one, the feeding and delivery of pellets will also slow down.
The best thing about pellet smokers is that unless you’re buying the absolute cheapest models, there are no bad choices. In this list for under $500, you’ll find pellet smokers and grills perfectly suited for dropping a few burgers at home use like the Traeger Junior Elite, for throwing in the back of the van and using anywhere like the Green Mountain Davey Crockett, or for cooking whole turkeys when you have ten people round on Thanksgiving, like the Camp Chef Smokepro.
Food not cooking evenly or at desired times: It’s worth checking out the health of the fans in your pellet grill. Usually, if the fan is unable to distribute the heat properly throughout the whole smoker, these problems occur. Fans are relatively inexpensive and very easy to replace. Even if you see the fan working and still getting these problems, it might be that the fan is working intermittently or at slower speeds that it needs to. Have it replaced: it would be the best course of action and won’t be heavy on your wallet.
When you have owned your smoker grill for 5-6 years you start wondering if owning a new one would be the best idea. This might happen because you are facing problems with your machine and not getting the desired result. The first and primary advice in this situation remains to clean up your grill thoroughly. Open up each and every part then proceed to doing a thorough cleaning. Most of the problems like temperature inconsistency or jamming will get solved this way.
This is a great pellet smoker! With a few minor tweaks, this thing would be perfect. Ribs, brisket, chicken, pulled pork, sausage, you name it and it comes off of the grates awesome. I've had mine since 2012 and would recommend that you purchase a spare thermocouple in case your's bites the dust in the middle of a smoke (replaced my thermocouple twice since 2012). This thing is built solid with longevity as a guarantee. The customer support at Yoder is unbelievable as well. I have gotten phone calls from them at 8am on Sunday morning when my first thermocouple gave up in 2014. Made in the USA with a commitment on customer support that has been incomparable to anything I've ever purchased! It's a bit pricey compared to the competition but does an amazing job. "The Sauce", with Chef Tom, is a huge help for those just getting their feet wet in pellet smoking. He does an amazing job by keeping it simple and flavorful!
Hey Pete, first thanks for your kind words. Traeger pellet grills fell off a bit quality wise over the past several years. That said, they’ve hired a new CEO – formerly from the Skull Candy Head Phone company – who brought that company’s valuation up considerably. I see them making moves to get back to their roots… aligning themselves with some of the more well known names in BBQ again. From a build quality, they’re making solid pellet grill bodies using fairly heavy steel. The area I’d like to see them improve on is the controllers they use. Right now, GMG is making great strides in claiming some of the entry level pellet smoker market share away from Traeger. This is due to a superior PID controller, advances in built in Wi-Fi monitoring, and outstanding customer service.
The Camp Chef SmokePro is probably the best pellet grill on this list by rating and by performance. It has a decently large area for cooking at 19.2 inches by 22 inches plus its smoking or warming rack is also 6 inches by 24 inches in size. This is one of the best pellet smoker for home use because of its combination of quality features that are never superfluous and works as advertised.
Wattage – With the right amount of wattage by your side, you will easily reach the temperature required, and it will stay there provided that you are providing enough pellets for it to make use of. Anything north of 1200W will easily be able to cover all your requirements, but as a rule, it’s ideal to be sheltered than sorry, so it can’t hurt to purchase a unit with a bigger Wattage than you might suspect you’ll require.

For as long as I can remember, the REC TEC RT-680 has been setting the standards for the best pellet smokers on the market, which is why REC-TEC is America’s fastest growing Pellet Smoker Company. And when they came up with the 2018 version of the REC TEC Pellet Grill, we knew it was going to be the very best pellet grill any barbecue lover could get their hands on.


So Kevin here is where you come in. Been wanting to make getting consistent Q on the table regularly and easily. Been looking at pellet poopers for about 5 years now and decided to take the plunge. Had already done enough looking a few years ago Traeger’s issues had scared me off. Several friends had them and raved but always mentioned problems. I decided from my work I don’t want to be buying someone’s, ‘we know the problems and are fixing them’ if you can find something solid for similar cost. Yoder and FEC were pretty much my finalists. So I was doing my final thoughts and found your article.
Coming over to the cooking area, you will find 2 stainless steel grill grates that give you 702 sq. in. of cooking space with an option of the second shelf that makes it 1054 sq. in. Its tall enough for turkeys and large enough to fit 6 large-sized racks of ribs. So, hosting a bunch of people for a BBQ party, and cooking delicious meat for them, would be as easy as it could get.
From the models and brands that I have reviewed here, I highly recommend the REC TEC 680 Wood Pellet Grill as the best pellet smoker. This comes with a grill technology, which gives you more convenience, whether you are a novice or an experienced grill master. If you have found this article to be helpful, please share it with your friends and family and help them make the right decision.
I had my Traeger grill now at least a week. Not really satisfied because every time I use it it does good for about a hour then it starts to cool down very quickly. Have to turn it off and start over and over again. This take all day to do this. I should not have to do this all day. Just a waste of pellets. Done wasted a whole bag of pellets. Called customer service. They tell me do the same thing. I think a grill should not do this. The meat I cook sometimes is not cooked. Have to start over again. All of this I have described take hrs. Have to stay outdoor to babysit. This grill should not have to do this. That tell me the grill is not good.
In addition to providing savings, using an oak base also creates consistency. Different types of wood have different densities, burn at different rates, and produce different amounts of heat and smoke. For instance, cherry burns faster than hickory, so using 100% cherry you’d go through more pellets than if using 100% hickory. The addition of oak allows every flavor to burn at a similar rate and with a similar heat output, providing consistency from cook to cook.
Cleaning/Maintenance: The grease catcher on this flat top is pretty decent. It is located on the bottom left hand side and all the oil/grease gets caught without anything dripping elsewhere. I usually wipe the grease catcher's orifice down with a paper towel to ensure it does not get clogged up over time. Other flat-top grills have either grease catchers that drip onto the leg of the grill or have them in the back of the flat top which is a little inconvenient getting to. As for cleaning after every use, I use a stainless steel scrapper/chopper to wipe the grill clean after I am done cooking. I scrape everything down into the grease catcher. For saucy foods or foods that might stick to the flat top, I use water when the grill is still hot to scrape it off and send it to the grease catcher. Afterwards, I put a little bit of oil onto the flat top and spread it all over using paper towels to maintain the seasoning before putting the cover on. Total clean-up time and re-seasoning takes roughly 3 minutes.
I have the Expedition 2x stove I purchased from Costco a few years ago and upgraded it with these side shelves. These are really nice and very useful. Easy to install (only took about 10 minutes) and they fold right on top of the stove so the whole works still fits into the carry bag. They are sturdy, but NOT meant to support heavy items like a cast iron pan or griddle! A little common sense here will go a long way. Happy cooking!
True blooded grill sweethearts out there might value this item. It is a minimized, full-included pellet barbecue that can take care of their grilling needs. You may need the item that accompanies all that you may require. When you have warmed it up, you can anticipate a perfect temperature and warmth in view of what you have chosen. Much the same as when you have found a reasonable latte machine for you, you would feel pleased with yourself for picking an extreme item that stays aware of your needs. Another element you may acknowledge in the item is that can keep the correct temperature all through the barbecuing or cooking process—regardless of whether you burn, grill, smoke or prepare. The cooking instrument is an exact griller that won’t make you stressed over any temperature variance. So whether you are an amateur or a pit ace, you might need to investigate this item that can take your grilling to the following level.
Apart from the replacement parts for a pellet smoker, there are also certain accessories that one can use to increase the range of its usefulness as well as improve its performance. A user can attach a griddle attachment to a pellet grill to use it as a flat top griddle, or use a hopper extender to increase the pellet hopper capacity; there is an attachment for every purpose to suit all of your needs. Let’s take a look at the types of accessories commonly found:

This grill actually came about because of an IndieGoGo campaign. IndieGoGo is a crowdfunding platform wherein interested parties on the Internet can donate money to the maker if they want his invention or service to come about. The Z Grills Wood Pellet BBQ Grill and Smoker got its $500,000 from its donators and now the previously nonexistent Z Grills Company now exists to make their wildly popular grill.
I live in Florida (Ocala), and I would like to grill, but I am undecided what to buy. I would not use the grill everyday. I am not a ‘griller’, but I do enjoy grilling simple meats, hamburgers, pork tenderloin and chicken; perhaps smoking a 12 lb. turkey for Thanksgiving and Christmas. I have no knowledge as to grill veggies or fish. I am an ignoramus! I tried, but I couldn’t detect them among the ashes!
My Egg will last past my lifetime. And I have a lifetime warranty on it as well. I don’t want to plunk down good money(even $500 is good money if you think about it) to have a grill of no use in 5 years. I guess I’m looking for a do it all grill. Not that I need one to do it all, heck I can use my Old Smokey to grill up some mean steaks and burger and hotdogs if need be.
Z GRILLS or Z Grills is a maker of smokers, grillers, and stainless steel prep work tables galore. It entered the world of pellet grills recently and launched an IndieGoGo campaign in order to fund its “affordable wood pellet grill” for $500,000 and currently gives even Traeger’s economical offerings a run for their money with its ability to accept all types of pellets and do all sorts of cooking styles.
Now, the best pellet grills come with more advanced features like auto-ignition using igniting rods, Wi-Fi Support, automatic turn on/off, and much more. One of the key safety features added by pellet smokers (designed by Green Mountain Grills), is a cooling fan to cool off the grill after it has been turned off. Even the shape of the body has been changed to have peaked lids so that it can accommodate turkeys and other kinds of roasts. Some come with multiple levels of racks for warming and cooling.
What’s more, as Pellet Grills are electric-powered and regulate their own fuel intake, they are a far more foolproof option than other smokers and grills which may require a large amount of maintenance and care during the cooking process. Wood pellets themselves are also incredibly versatile. Aspiring smokers can experiment with a whole array of wood varieties in order to explore the flavors that each lends to meat.
Barbecue was not his first career. He earned a BA from Columbia College in Chicago and studied at the Cleveland Institute of Art and the Dana School of Music. He has been involved in every aspect of film, video and music production. He edited the 1991 Academy Award nominated documentary, "The Mark of the Maker" and "Universal Hotel", which is part of a permanent exhibit at the Dachau Memorial Museum.
2. The grill does not come back to the set temperature after the lid is opened and closed to place the meat. I start it, close the lid, set the temp (startup procedure has changed to this according to Traeger service tech) and after 15 or 20 minutes it is not at the set temp yet...in fact it is declining. Well I need to cook on it and cannot wait forever so I open the lid quickly, throw the meat on, and close the lid quickly.
Compared to the Traeger Pro and the other smokers we’ve reviewed, there’s not much not to like about this bad boy. It’s significantly cheaper, packs ample cooking space, and a good, consistent temperature controller. At 173 lbs, it is quite heavy, and not at all portable like the Davy Crocket, and we’d love to see it come with more precise temperature control, and maybe even WiFi in the future. But for the price, it’s a beast of smoker that is almost as good as the Traeger.
The Tailgater 20 Series Freestanding Grill is one of the best wood pellet grills from Traeger for those who like to cook away from home. It’s small and lightweight enough that you can load it in your car for tailgating before the big game, cooking while camping or grilling at the park. The ash bucket collects all ash created, which makes cleaning up before heading home easier.
With the summer right around the corner, it’s about that time of the year that consumers are thinking about hosting outdoor picnics and having their friends and family in the backyard. Now, to make this year special, many people are flocking towards purchasing pellet grills. In efforts to assure our readers that each grill on today’s list is the absolute best, we performed an update on this buying guide. Included in this update, readers will get to learn about the criteria that we used to evaluate each grill and a list of answers to some commonly asked questions. Before the summer arrives, check out this update!
This smoker offers a massive 560 cubic inches of grilling area with a large-capacity pellet hopper. Even though it’s the perfect starter grill, it’s still packed with plenty of extras that even the pro chefs will enjoy. If the grilling space isn’t enough, the removable upper racks can be turned into extra cooking space. The smokestack behind the unit can also be converted into a prep area.
Despite being a little complicated when compared to the other types of grilling equipment (because of the automatic pellet auger and fan), they are pretty easy to repair if you have the right parts. You can find these parts right at a home depot or online. It doesn’t matter if you need to replace the auger or the fan, the ignitor rod or the hopper, for the top brands, you’ll find the replacement parts just as easily. Let’s look at the replaceable parts of a pellet smoker:
SquareTrade Protection Plans are only valid for new or Amazon certified refurbished products purchased at Amazon in the last 30 days. By purchasing this Protection Plan you agree to the Protection Plan Terms & Conditions (http://www.squaretrade.com/terms-standard). Your Protection Plan Terms & Conditions will be delivered via email within 24 hours of purchase

Now, I will be very honest with this topic here. While prices vary from model to model and brand to brand, one thing to understand is that the best pellet grills are made with the best materials, made by keeping consumers needs in mind, made with intelligent designs and features that can serve and last a long time. There are pellet grills in the market ranging from extremely cheap and affordable to very expensive, and sometimes even unnecessarily expensive. While there are exceptions in many cases, the blatant truth is that good stuff will cost an extra penny. This is why I will be giving you my pellet grill review, so that you can see and identify your specific needs and buy a grill according to that instead on spending a fortune on low quality or unnecessarily multiple-feature grills.
Hi Mark – I’ve not personally used the Smoke Hollow Pellet Grill you mention here. The base model pellet smokers I see at stores like Sam’s and Costco are going to do fine for most backyard cooking preparations. I’d look into what the Smoke Hollow folks offer customer service wise. When you buy at the lower end, understand that the unit might not enjoy the longevity or durability of other mid-tier or higher end models.
Thanks Kevin for the reviews and content. Like many of the folks I too will be purchasing a pellet pooper. I have narrowed my choices to a MAK 2 star and a Memphis Elite. One of the earlier posters indicated on the Memphis that the effective direct grilling space was about 1 square foot. I am assuming that with the smaller footprint of the MAK that the direct “flame zone” is less than that. I’m just wondering how much less.
Using accurate digital thermometers to monitor cooking and internal meat temperatures is essential to being all that you can be in the backyard. Unlike the caveman-era heat estimators built into the lids of most grills and smokers, modern pellet smoker LED displays will give you the real story of what's happening in your smoker. Of course, if your smoker doesn't come with a dual-display system that monitors both cooking and meat temps, you'll still need an accurate digital meat thermometer.
Turn it on to "Smoke" mode and use the P settings, or cook mode by selecting a temperature. When you select smoke or a temp setting you start the ignition sequence. The fan, igniter and auger motor turn on. The fan stays on until the smoker is turned off. The auger motor continuously delivers pellets to the red hot igniter rod in the firebox for two minutes under normal conditions. Then the igniter rod shuts off and the pellet fire burns with only the assistance of the auger and the fan.

As you can see from the image of a Traeger Pellet Grill above, pellets move from a hopper (left) via an auger to a burn pot (far right). The rate at which the pellets are fed into the hopper is dictated by your Pellet grill’s thermostat. Extra fuel in the form of oxygen is blown over the burn pot to increase the burn rate and help regulate a nice, steady, and efficient burn. The lower your temp, the more smoke is created.

×