Hey Kevin great article. I too am currently looking for a pellet smoker. I’ve narrowed it down between a Yader, Memphis Pro and the Rec Tec. The Green Mountain did not seem very well built. The wheels looked liked the would break on the first roll and the stainless steel door was flimsy and did not have a good seal. I know the Rec Tec has a 6 year warranty. Do you know how long the warranties are on the other two?
Kevin, Im about ready to pull the trigger – im pausing for a moment to consider your thoughts as you mentioned Grilla Silverback or Camp Chef. How do these compare to the Rec Tec on quality and price? (as they are less than Rec Tec) And reverse sear…how well does this work on pellet grill, ie how long does it take to go from 200 cooking temp to 500 searing temp (with grill grates)? Thank you for your time
Hi Joshua – Rec-Tec makes a solid product. I can’t say a bad thing about them. I think you’d be very happy with the Silverbac. Email Shane Draper – Pitmaster for Grilla Grills at pitmaster@grillagrills.com. He’s super quick with responses and can answer all questions re: Grillas. The Traeger pro series is a solid buy as well. You can check them out at Ace Hardware Stores or via stores acting as dealers for the pro model (find these on the Traeger website). I have the smaller Traeger 22 pro model and have been very happy so far. Regarding controllers, my verdict is still out on whether they’re what you need. It’s almost getting to a point where I “want” some temp swing, especially at the lower settings, in order to get a bit more smoke from the cooker. 15 degrees either way on temp is pretty normal. You might find that this is the case, even when controller units “read” steady. Pellet grills all feed pellets into burn pots in cycles. So some swing is inevitable. Hope this helps.
Just putting a stamp on your info and recommendations. The Pro is definitely a Pro! Consistent, excellent temp control, juicy and great flavor. Smoke ring, some of my ribs are pink all the way through and dripping with juice. Smoke profile, good, not over powering. I have used 45# of hickory so far, 20# of cherry and a few pounds of apple and pecan. Have not tried anything but Lumberjack but that will be the next experiment. I have tried the smoke tube and it is ok. I was worried about getting an ash or bitter taste as the smoke is fairly heavy and a little acrid smelling if you let it burn from bottom to top. So I lay it down and light on my wife’s Weber gas grill side burner and get the whole thing burning good and then blow it out. If it smells acrid your meat will get some of that taste. Starting the tube this way it is still going an hour later.
I have used Bradley, Masterpiece, Green Egg, New Braunfels, Oklahoma Joe, Weber and now Traeger. So there is some experience in these comments. The “set it and forget” it is a misnomer and should not be used with Traeger (or any smoker/grill.) With Pellet Drive before you buy Read up on Er codes. The worst is when the fire pot fills up with pellets because the fire can’t keep up with the auger push and the whole cook is ruined or delayed. You have to pull everything out and basically start over while your expensive prime brisket is trying to be saved in the oven. Doesn’t matter what the weather is or wind conditions. Doesn’t matter if you stare at it and stir the hopper continuously. It will happen. Customer support at first was well you are at fault (didn’t leave the lid open on fireup for exactly 2 to 4 minutes or didn’t vacuum out the firepot between every cook) which is crazy. Finally, after so many calls over the past 6 months they are trying to make it right. Problem is, DO NOT believe the “set it and forget it.” That does not exist with any good cook. I have replaced the controller the fan and now getting a new probe. Do not waste your money. Unless someone out here in BBQ land can give me a recommendation on a product that won’t do this stay away from Pellet Drive?

When I first noticed the BBL, with its attached cover, I thought that this would be something I'd eventually want. When it came up on sale, I ordered one after reading the Amazon description of what it would work on. I should have checked the Camp Chef website. This unit is designed for the stoves with the 14 inch capacity front to back--as in the two-burner models. The Amazon propaganda stated that it would fit both two burner and three burner stoves. My intent was to use it on one burner of my 3 burner Pro-90 model, and use the remaining burners with a Camp Chef griddle that I already had. I gave this 4 stars because it is useable, but you have to place the unit crossways over one of the burners. This leaves you with deciding whether to face the lid toward ... full review
We love recommending and reviewing wood pellet smoker grills, but we also want you to get the most out of them once you purchase. Without proper care and maintenance, even the best pellet smoker is bound to have a shorter lifespan. Therefore, how you use your smoker and how you maintain it after use greatly determines how long it will serve you. A little bit of work will go a long way toward extending the life of your smoker. A thorough cleaning of the smoker should occur at least once a year. If you frequently use it, you should have it done at least three times a year. Buying quality pellets will extend its life as well.

Because most Traeger grills make use of an Ortech digital temperature controller that’s precise within about 15 degrees of your setting, they may not be precise enough for the type of cooking you want to perform. If so, some pellet grill manufacturers, such as MAK, Yader, and Memphis, can give you temperature control within about 5 degrees of the setting. These types of grills use multiple temperature probes inside the cooking area to guarantee the temperature remains consistent. And some of these high-end brands can reach a higher cooking temperature (such as 600 or 700 degrees Fahrenheit) versus the Traeger family of grills (usually around 450 or 500 degrees). Additionally, MAK, Memphis, and Yader grills are made in the United States, while some parts of Traeger grills are made in China.
The original Traeger Grill was invented 30 years ago and was every bit as impressive then as it is now. Although it developed a cult following, the early Traeger never grew beyond a niche product. In the past two years, however, Traeger has stepped up its game, redesigning and upgrading its grills while doing everything it can to build a buzz around its amazing do-everything cookers.

In addition to providing savings, using an oak base also creates consistency. Different types of wood have different densities, burn at different rates, and produce different amounts of heat and smoke. For instance, cherry burns faster than hickory, so using 100% cherry you’d go through more pellets than if using 100% hickory. The addition of oak allows every flavor to burn at a similar rate and with a similar heat output, providing consistency from cook to cook.

At present, I am sponsored by and continually use pellets produced by CookinPellets.com. There are two versions of pellets – the Perfect Mix (Hickory, Cherry, Hard Maple, and Apple Woods) and 100 Percent Hickory. In each of these versions, CookinPellets uses all wood, no bark, no filler woods like oak or alder and no flavor oils. Just 100% of what is on the bag. I get consistently great flavor using these two varieties of pellet smoker pellets from CookinPellets.com, and I think you’ll enjoy them very much as well.
Many other features, like its automatic control and built-in meat probe have made us select this smoker as the top one in our pellet smoker review. And the most amazing fact is the price. In the price range (see the price here), we never thought that we could get all these features and benefits. We took all the top smokers into considerations like the Rec Tec smokers, but this PG24 by Camp Chef can beat all through its performance and affordability.

Second, It would be just my wife and me BBQing so I’m looking small. I’m considering the REC TEC Mini Portable Wood Pellet Grill (RT-300) after reading your reviews. Having only ever BBQed with hard wood coals on a Webber, is there going to be a taste fall-off going to the pellet grill as far as charring and/or smoke? I’d hate to spend that kind of money and get bland steaks. Really, steak is all we ever cook outside, though that would probably change with a nice grill.

I had an American made Traeger for 6 years and after it rusted out I was looking something built for the long haul. The YS 640 is it. Built like a tank it will hold up for years and the extra steel helps retain the heat. Temperature control is spot on and recoverey after opening the lid is amazing. I thoroughly researched all my options and I could not be happier. I cooked steaks the other night in 40 degree weather and had no issues whatsoever. The grille grates are a must and leave beautiful lines. Before you buy anything else, investigate what the other cookers are made of. There really is no comparison.
Kevin, Im about ready to pull the trigger – im pausing for a moment to consider your thoughts as you mentioned Grilla Silverback or Camp Chef. How do these compare to the Rec Tec on quality and price? (as they are less than Rec Tec) And reverse sear…how well does this work on pellet grill, ie how long does it take to go from 200 cooking temp to 500 searing temp (with grill grates)? Thank you for your time
My traeger has had some good moments but it very unreliable.  I really do not enjoy cooking with it.  I have no confidence in the temp readings and the smoke control.  Every time I open the lid the temp drops like 200 degrees.  I'll smoke at the "smoke" setting but as soon as I turn it to 225 it spikes to like 300-500 degrees. Wtf?  I thought this POS was supposed to be a set it and forget it type smoker.  Very unreliable.  Temp fluctuates so much and if there is even a slight breeze the temps just go up and down up and down.  The pellet feeder is garbage.  It will all the sudden just start smoking like crazy because the pellets have jammed into the burner.  Completely ridiculous smoker.  I use it still but only when I can sit and watch the feeder.  The guys comment below is true about the feeder always just using the middle pellets.  I always have to check it and push the pellets to the center.  Some simple engineering would change this. Never again will I purchase a traeger. There are much better options out there and better price.
The Pit Boss Company manufactures an extra-large pellet grill with 700 square inches of cooking surface. It closest competitor in pellet smoker largeness is the 7-year veteran known as Rec-Tec. It has probably one of the largest cooking surfaces (or the largest at that) in the pellet grill and smoker industry. It approaches grilling with the idea that sometimes bigger really is better, at least in terms of cooking more meats at the same time.
First, it’s really easy to use, with an electric auto ignition and shutdown system, plus LED controls that make setup idiot proof. Once it’s up and burning, the built in temperature sensor and meat probe make knowing what’s going on inside simple, especially considering that the thermometer is one of the most accurate I’ve seen, with only around 10 degrees variance. It’s got multiple settings if you’re using it as a meat smoker, as well, so you can control your flavor.
I got my YS640 for a combination Father's Day/ Birthday gift and regardless of whether it's grilling or smoking beef, pork or chicken the results have been outstanding. I can hardly wait to break out the turkeys for the Holiday meals. The direct grilling grates leave a steak with beautiful grill marks and the use of the fruit wood pellets along with quality steaks have made for some incomparable meals. As for quality of the smoker itself, I have sons-in-law that are already jockeying for position to try to be the next to have the YS640 after my demise - - - and we're figuring that won't be for at least 20-30 years!
Just like your kitchen oven, a pellet grill must keep a consistent temperature in order to produce great food. To get tender brisket, the temperature needs to stay as close as possible to 250°F for the entire 12-plus hours its cooking. A pellet grill’s ability to do that is largely determined by its control board, which is essentially the brains of the pellet grill. There are different types of controllers, and their precision and consistency varies. Most can hold a consistent temperature in ideal conditions, but not all controllers can maintain a tight temperature in the cold, wind, and rain.
Cleaning/Maintenance: The grease catcher on this flat top is pretty decent. It is located on the bottom left hand side and all the oil/grease gets caught without anything dripping elsewhere. I usually wipe the grease catcher's orifice down with a paper towel to ensure it does not get clogged up over time. Other flat-top grills have either grease catchers that drip onto the leg of the grill or have them in the back of the flat top which is a little inconvenient getting to. As for cleaning after every use, I use a stainless steel scrapper/chopper to wipe the grill clean after I am done cooking. I scrape everything down into the grease catcher. For saucy foods or foods that might stick to the flat top, I use water when the grill is still hot to scrape it off and send it to the grease catcher. Afterwards, I put a little bit of oil onto the flat top and spread it all over using paper towels to maintain the seasoning before putting the cover on. Total clean-up time and re-seasoning takes roughly 3 minutes.
I did a lot looking around at pellet smokers before buying the ys 640. This thing is amazing! I have been cooking BBQ for about 15 years. I owned a Gator pit entertainer which is made in Houston Texas (stick burning pit) and I currently own a $25,000 Ole Hickory Pit EL-EDX which can cook 700 lbs of BBQ at once. I wanted something smaller to cook for family. The ys 640 turns out PERFECT Q every time! The amount of smoke is just right. Plenty of smoke flavor without over smoking which is very easy to do in my other pit. This is an EXCELLENT product which I strongly recommend.

Hey Pete, first thanks for your kind words. Traeger pellet grills fell off a bit quality wise over the past several years. That said, they’ve hired a new CEO – formerly from the Skull Candy Head Phone company – who brought that company’s valuation up considerably. I see them making moves to get back to their roots… aligning themselves with some of the more well known names in BBQ again. From a build quality, they’re making solid pellet grill bodies using fairly heavy steel. The area I’d like to see them improve on is the controllers they use. Right now, GMG is making great strides in claiming some of the entry level pellet smoker market share away from Traeger. This is due to a superior PID controller, advances in built in Wi-Fi monitoring, and outstanding customer service.


Is it customization? I called before I order my YS640 and told them I wanted my grill grates made out of expanded stainless steel, and a few other small things done to ""personalize"" my grill so it was just the way I wanted it. ""No problem. The added materials will cost extra, and shipment will a week so we can fabricate your grates."" Try getting that with a Chinese import!
Alex Coleman’s family has been farming in the Piedmont region of North Carolina longer than anybody remembers. The area is famous for “Lexington Style” barbeque, which focuses on pork shoulder barbeque served up with a variety of sauces based on ketchup, vinegar, and peppers. But Alex’s daddy taught him so much more than that about grilling and smoking...Read more
Many other features, like its automatic control and built-in meat probe have made us select this smoker as the top one in our pellet smoker review. And the most amazing fact is the price. In the price range (see the price here), we never thought that we could get all these features and benefits. We took all the top smokers into considerations like the Rec Tec smokers, but this PG24 by Camp Chef can beat all through its performance and affordability.
Just started shopping around for a pellet smoker. Am also going to need a new gas grill soon. Stopped in at the local BBQ supply store today and they showed me the Memphis Pro and said it would function well for both smoking and cooking steaks/burgers. Price point on that one is pretty high. Would any of the others reviewed above offer similar functionality? Do you have a recommendation of which will work well for both functions? I live in KS so kind of like the idea of sticking with the local guys from Yoder, but Fast Eddys in OK isn’t too far away either. Thanks.
With that said, we also wanted to take into consideration the smaller grills of the family. For instance, we wanted to share pellet grills that were intended for portable use or individuals that want a small smoker that is of the best quality. As far as cost and value are concerned, we can say that all of the grills on this list are top of the line and have expert quality features that make them ideal for the individual that wants their ideal pellet grill.
One of the most common problems people encounter with pellet grills is abnormal temperature fluctuations—the controller is set to 250°F, but the grill is dropping to 200°F then climbing to 325°F. Usually people assume that it's a mechanical issue and either the controller or RTD probe need to be replaced. However, very often the problem is far simpler and the solution far easier.

Every outdoor cooking enthusiast wants an affordable pellet smoker that has all of the key features that even a high-end unit would have. In most cases, this is just a dream and a result of false advertising, because most impressive smokers typically cost a hefty sum of money. The Z Grills Wood Pellet Grill and Smoker claims to be a reasonably-priced smoker that offers top-of-the-line features, and many users have agreed with those claims. With this pellet smoker review of the Z Grills Wood Pellet Grill and Smoker, we’ll find out if it really does what it claims to do.
I have ate a few peoples cooking that have won at the Royal, Houston and Memphis in May. They have all had one thing in common, I didn’t put one drop of sauce on them and they had not been sauced on the Q before serving! The restaurant Cackle and Oink is just a ways from where we live and the owner Aaron Vogel is there regularly. I have tasted all his sauces and they are very good, but the 3 times I have been there, his sauces never touch my ribs and brisket! Aaron does say, if you like this you need to try my competition food (which I will at one of the competitions he is in locally). None of the KCBS, Houston or Memphis in may winners Q had even a hint of ash or bitter smoke flavor. They also had a very light smoke profile. They also all say they cook over well burned down wood.

I don’t know how many meals I cooked on that thing, but it’s been enough to make me a hero and de facto camp chef among my friends. I seared up a tri tip large enough to feed four hungry kayaking buddies at the Salmon River Festival one year, then covered it with foil and cooked it on indirect heat for one of the best steaks of my life, which we happily consumed in the middle of nowhere. The grill also perfectly charred onions and peppers to deliver a mountain of chicken and beef fajitas to a crowd of ten. I still get compliments on that one. 
The grill is plated with beautiful stainless steel that gives the grill a refined and impressive look. The huge cooking area includes 570 square inches of surface area. That’s enough to hold 20 burgers or 4 rib racks! It also contains a second warming rack and bottom shelf that provides the grill stability and extra storage. This version comes with a sear box that can reach temperature of up to 900 degrees Fahrenheit, which caramelizes your food. There’s a cheaper version without a sear box that costs around $200 less if a sear box isn’t a necessity for you. Additionally, the legs are built with extreme thickness giving the grill a grounded base. The caster wheels add portability to the grill so you can find that perfect place in the backyard.
This is a great smoker for beginners who are willing to take the time to understand how pellet smokers work. You can follow the instructions in the video provided on the manufacturer’s website to see how to put it together. It is also great for people who have been pellet smoking for years. It has a huge cooking surface, which is perfect for entertaining large groups of friends.
What’s also really great is that the price isn’t too bad and that most people will be able to afford this product. If you’re not convinced yet you should check out the reviews on Amazon. There’s hundreds of them and most are overwhelmingly positive. If you want to see what other customers are saying about the GMG Davey Crockett Pellet Grill, click below:
We purchased our wood pellet grill (Model TFB57CLB) from Costco in August 2017. It came with one bag of the gourmet blend pellets. We used the Traeger cookbook to try a few different recipes in the fall. Most of these involve a period of smoking followed by a period of grilling. The grill seemed to work fine at first. We used it a couple of times on warmer days in the winter and it had some trouble getting up to the desired heat level. We started using it regularly again in April 2018. I was careful to clean it and check the pellets etc. The smoking feature seemed to work alright, but when I would turn the heat up for grilling, the grill would usually struggle to get much over 225. I would resort to turning it up to 375 or more just to get it to 225 and then often it would sink back down to 180 or 160. I went to the troubleshooting guide on the manufacturer's website and checked all the components, which seemed to be working fine.
Hey Tom! First, thank you so much for commenting on this article. I hope it’s proved useful to you and helping you make your pellet smoker buying decision. I took a look at the smokers you mentioned in your comment, and they appear to be similar in build to those made by Yoder. I can verify that Yoder does exceptionally good work with both the build quality and the heavy gauge steel Construction of their smokers. I don’t know much about the manufacturing practices of the smokers you mentioned. I do like the fact that their controller automatically dropped down to a warming temperature after your food reaches the programmed temperature setting. That’s a feature that I’ve only seen in higher-priced pellet grills like the Memphis Pro Series that I talk about in this article. However, more grills are starting to utilize this in the programming aspect of their controllers. In any case it’s a great feature. To be honest with you I’m not sure that the auger mechanics are going to be all that different between smokers. I’m sure there are differences, but I don’t feel that they are dramatic enough to offer a distinct selling Advantage for the manufacturer. If you haven’t looked at them yet, you might consider taking a look at the Traeger Pro Series pellet grills. You can’t find it on Amazon, but you can find them at different retailers listed on the main Traeger site. A friend of mine has one major competitions using the pro series models.

Personal review of the Traeger: The auger fed the pellets after the fire pot went out making a large pile up which caused it to catch fire and burn up my grill. I had to use a fire extinguisher to put out the flames and prevent my house from catching fire. I sent Traeger the description of damages with photos. After much waiting and no response from the management team regarding my Traeger grill we gave up. The service team was very responsive but lacked any authority to make decisions to fix the grill. We worked with the service team for awhile having a different person each time respond and request information and photos that were already provided. Then, we got passed up to the management which is highly ineffective because we never heard from them, even after an email requesting an update. We really did like our Traeger grill and had high hopes that since it was under warranty and caught fire due to a failure we would have the grill repaired. Because of the terrible unresponsive service of Traeger we took our money and purchase a Green Mountain Grill.
Thanks Kevin. I am about to buy both a 5 burner gas grill and a smoker for a new bbq island. Rather than buy both, will one of these higher end pellet grills take the place of a traditional propane grill? I can apply the funds for the gas grill to a higher end pellet if it can really do double duty. It has to be able to cook burgers and dogs and steaks etc. Just like a gas grill though. Thoughts?
Hello Mark! Thanks for commenting here. The Kalamazoo Hybrid Grill looks like a BEAST! If you can swing it, I’d go for it. I truly enjoyed cooking on the Memphis Grill, which is to date the most high end pellet grill I’ve used. It offered a nice blend of professional grade convection with the wood fire taste of the pellets. The Kalamazoo hybrid really does seem to offer one step beyond with the addition of charcoal and wood chunks. I see that Derrick Riches of About.com stands behind the Kalamazoo brand. You’re hard pressed to get a better endorsement of a grilling product than that! Keep me posted at kevin@bbqbeat.com and let me know how your search goes! 🙂
You are worried about flare-ups: When grilling fatty types of meat on a propane grill, you run the risk of having flare-ups, where the flame gets too high and too hot, burning the meat. You have to keep a close eye on the propane grill to guard against them. But with the Traeger grilling system, the even distribution of the heat and the indirect heating system prevent this problem.
Hello Mark! Thanks for commenting here. The Kalamazoo Hybrid Grill looks like a BEAST! If you can swing it, I’d go for it. I truly enjoyed cooking on the Memphis Grill, which is to date the most high end pellet grill I’ve used. It offered a nice blend of professional grade convection with the wood fire taste of the pellets. The Kalamazoo hybrid really does seem to offer one step beyond with the addition of charcoal and wood chunks. I see that Derrick Riches of About.com stands behind the Kalamazoo brand. You’re hard pressed to get a better endorsement of a grilling product than that! Keep me posted at kevin@bbqbeat.com and let me know how your search goes! 🙂
We all know about Davy Crockett and Daniel Boone, but Traeger is the true pioneer of pellet smoking. This company introduced the first pellet smokers, and it remains the best-known brand, although competition is growing. There's nothing fancy here. Instead of a touch-pad controller, Traeger employs an older-style digital dial controller. No WiFi or meat probes; just no-frills schmokin' from the industry leader.
Hey Tom, first, thank you so much for reading the article and expressing your approval of it. It means a lot to me that the information posted on this site is useful for the people. To your question about pellet grills, yes. You must always use BBQ grilling pellets with these cookers. You cannot use raw wood with them. However, should you find yourself with access too hard woods like Hickory or maple, or fruit woods like apple, cherry, or peach – this is something that could be readily used in a charcoal smoker.
Beef: For ground beef items such as patties and pies, the ideal temperature would be 250 F. If trying to smoke some steak, we’d suggest 225 F. For both these temperatures, the food should be allowed to cook for around 1 hour to 1 and a half, depending on your preferred doneness. Alternately, for steaks, you can reduce the temperature further, increasing the cooking time for more tender but less juicy results.

The Rainier is also hearty as hell. It survived banging around in the bed of my truck for four years. And I didn’t exactly baby it, cramming it into the limited storage space in my truck with paddles, helmets, and all manner of gear. But I never worried that it wouldn’t fire up to cook another meal. Once, one of the stubby rubber legs popped off as I was pulling the Rainier out of my truck. The stove sat crooked for a weekend, but I eventually found the leg and simply screwed it back on.

You like the idea of cooking different types of foods on the grill: If you’re someone who wants to grill food other than meat, the Traeger grilling system gives you this option. With the precise temperature control of the Traeger, cooking things like fruit pies can be a successful endeavor, something you wouldn’t dare try with a propane-fired grill.
So, when their patent expired in 2006, large companies capitalized on that one and Traeger began facing cut-throat competitions. Within two years, a few companies had already begun producing some of the best pellet grills with more advanced designs and features. By 2014, around 27 companies had already penetrated the market and newer brands were coming out almost every month. Now, with so many companies already in the market, some of them are creating strategic alliances with other brands producing different grilling equipment.
The argument against bark is that it can cause an inconsistent burn and produce excessive ash. Again, consider a log on a fire. Because they have different compositions, the bark and hardwood burn at different rates and produce different amounts of heat. Furthermore, bark doesn’t burn cleanly, it creates more ash than the hardwood. When that ash builds up, it interferes with your grill’s ability to accurately read the temperature, causing large swings. If too much of that ash builds up in the fire pot, it can cut off the oxygen and snuff out the fire.

I watched the Traeger infomercial on T.V. Seemed easy enough. Ha! QVC ran a similar infomercial on their channel, seemed really easy. Ha! Like a fool and his money are soon departed, I jumped in and bought one. When it came in the mail, I started to assemble it. What a joke! No instructions came with it to tell me where the nuts and screws went. Called the manufacturer. The lady said they had many complaints with the QVC orders, she would email me a copy of the instructions. Well I finally put it together. Performed the (curing and start up method). Bought a nice pork shoulder and started grilling. It is interesting that both infomercials say set the temp and WALK AWAY!!! What a joke, I sat and watched the grill like a hawk for 3 hours, everything was good. I figured I would go eat lunch, ha! What a mistake. When I came back (20 min.) the grill had turned itself off and had an error on the screen.


With the upcoming and already existing new features, you can achieve an easier and much better smoking experience than ever before. Always look for features that can help bring out the real taste of food, and give you more control and convenience. Keep visiting this page because we will always be the first ones to bring you the newest and the best news about the innovations in grills and smokers.
One-Touch Non-PID Controller - Featuring a LCD display and one-touch buttons for setting the cooking temperature in 5° or 10° increments, these controllers allow you to more accurately set a desired cooking temperature. However, like multi-position controllers, they use fixed cycles for delivering pellets and so are limited in accuracy to +/-15–20°F. These controllers may have inputs for meat probes that monitor the internal temperature of food.
To start using the grill, pour wood pellets into a hopper (pellets are usually are made from compressed sawdust). Press the start button to ignite the pellets, which are fed into the fire box with an auger, where a controlled number of pellets are lit and burned (depending on the temperature setting selected). The auger adjusts the number of pellets entering the fire box to maintain the desired temperature.
You are worried about flare-ups: When grilling fatty types of meat on a propane grill, you run the risk of having flare-ups, where the flame gets too high and too hot, burning the meat. You have to keep a close eye on the propane grill to guard against them. But with the Traeger grilling system, the even distribution of the heat and the indirect heating system prevent this problem.
Another option is to put a griddle (or GrillGrates) on the pellet smoker when it's cranked to high heat, get it blistering-hot, add just a little oil to prevent sticking, and sear by conduction on the metal. It should take only two to three minutes per side. This is a good technique for reverse-seared meats: You start them indirect, low and slow on the cooking grate, with a little smoke, and then sear the surface with direct contact to the hot metal griddle to create a delicious brown crust. It's not as good as searing directly over hot coals or gas, but it's a good compromise.
PID Controller–PID Controllers (Proportional Integral Derivative) are devices that most of the grill manufactures don’t fully utilize yet. They can be found as a separate device attached to the grills if you’re handy enough, but all the manufacturers aren’t fully considering them yet. Using a PID controller, you can accurately maintain the temperature while cooking and ensure that the food is cooked automatically to perfection without much supervision.
The Camp Chef SmokePro’s automatic features definitely set it apart and make it truly a “set it and forget it” kind of unit. It makes use of an electric auto-igniter system that lets you start grilling with just one button. The automatic auger instantly dispenses pellets to maintain the desired temperature and use your pellets the most efficient way.
Yoder pellet smokers maintain a very strong reputation for quality and precision. Based out of Hutchinson, KS, the company prides itself on producing a 100 percent Made in America product that is one of the sturdiest and most reliable brands of smokers available. Check out this Yoder Smokers promo video to get an idea of how they are branding themselves.
×