Hi i would like to buy my boyfriend a good quality smoker but can’t seem to find one that’s small for people just starting out with smoking for our small backyard. Does anyone have any suggestions? I don’t want to invest too much to start incase it’s too difficult to use or we find we don’t like it. I’ve read some reviews on little smokers that catch on fire and that worries me since we live in a townhouse. I figured someone on here would know of a well made brand that is on the smaller/less expensive side.
Thank you for stopping by to read this article pertaining to Pellet Grill Reviews. If you’re here, it’s likely you’ve already read a few reviews about pellet smokers. As such, you’re in the process of figuring out whether Pellet Smokers are a good choice either for personal backyard BBQ cooking or as a means of getting started on the BBQ competition circuit.

Camp Chef is a leading manufacturer of camping stoves, dutch ovens, and other outdoor cooking equipment. If you want quality cookware to take on your next camping trip or barbecue in the park, Camp Chef has the solutions - from camp stoves to cast iron dutch ovens. Camp Chef makes cooking gear for campers, hunting, for traveling by RV, even for your next tailgate party. Camp Chef was built around the idea of finding better ways to cook outdoors - no matter the location, from woods to parking lots to campgrounds - and from that philosophy has come a whole line of outdoor cooking equipment, made to let you go gourmet in the wild!

Traeger's, unlike other models, have a temperature probe, these sensors tell it if the temperature is too low and automatically feeds more pellets to the fire. You can set up the temperature in 5-degree increments. Other brands and cheaper versions only offer three settings low, medium and high. There is no sensor to monitor the temperature. If you are purchasing a pellet grill it is because you can set it and forget it. If you plan to hoover then it makes more sense to use a standard smoker or to transform your grill into a smoker.
I don’t know why these cookers are referred to as grills. By definition they are not grills. Grilling involves cooking with direct heat and none of the pellet cookers I’ve seen use direct heat; they all use indirect heat. They are more accurately described as smokers/convection ovens. For me what this means is they’re useless for cooking chicken since I like my chicken cooked with crispy/burned skin. I’ve done some experimenting to get the skin to crisp up but always end up with leather skin. They have their place in outdoor cooking but grilling ain’t it. I just bought a Green Mountain and I’m still debating if I’m going to hang on to it. Shame on me for not doing more thorough research first.

If you have an older smoker and need a lot of physical maintenance like changing the hopper and the digital control, then changing those two parts may not help. These two changes may cost you $200 – $250 and with a rusty hopper, you will continuously lose the smoke you produce. This is not safe for your health, so in this situation, you should definitely opt to get a new pellet smoker grill.
You prefer a direct heat method of grilling: The Traeger grill uses an indirect heating source, much like an oven, so you won’t be able to sear meat, as many people like to do when grilling a steak. The Traeger system is better for those people seeking more of a smoker type of cooking system, although you can sear your meat by using a frying pan with a little oil initially before you finish cooking it with the Traeger grill. You can use the frying pan on a stove top burner or on the surface of the Traeger grill.
I store it in the Camp Chef cover. It takes about a minute to pull the cover off, install the gas cylinder and side tables, move it into cooking position on my deck, and light the burners. It doesn't take much longer to clean up. After getting the griddle back up to high temperature for cleaning, the active work of squirting, scraping and wiping down takes just a couple of minutes. After cool down, removing the gas tank and side tables (which fit nicely on top of the griddle for storage) and putting the cover on takes another a minute.
Ease Of Use – Check if the unit is anything but difficult to setup and work. A few units are a breeze to gather, and you should simply to take after the manual of guidelines that accompany it. And after that, you ought to likewise discover how to work the grill and it ought to offer you easily of operation. For the most items I have evaluated here, they can be worked with the push of a catch, so they will let you simply set the clock and temperature and forget about it.
What’s more, as Pellet Grills are electric-powered and regulate their own fuel intake, they are a far more foolproof option than other smokers and grills which may require a large amount of maintenance and care during the cooking process. Wood pellets themselves are also incredibly versatile. Aspiring smokers can experiment with a whole array of wood varieties in order to explore the flavors that each lends to meat.
Thankfully the popularity of pellet grills spurred many new pellet fuel manufacturing companies to enter the industry.  There are also some very big names in the grilling world that have seen the light and are now producing pellets as well.   This has helped the availability of pellets for sure, but we are still not to a point where pellets are commonplace in stores in all areas.
These food grade wood pellets contain only the best and the pure compressed sawdust from hardwood and are sometimes added with natural vegetable oils, perfectly safe and healthy for your food. However, the carbon in the soot and ashes that fly off the firebox can get embedded into the body of the food, which can get inside your body. The good news is problems such as these can be easily avoided if you can keep your smoker clean.
Hey Kevin great article. I too am currently looking for a pellet smoker. I’ve narrowed it down between a Yader, Memphis Pro and the Rec Tec. The Green Mountain did not seem very well built. The wheels looked liked the would break on the first roll and the stainless steel door was flimsy and did not have a good seal. I know the Rec Tec has a 6 year warranty. Do you know how long the warranties are on the other two?

This grill actually came about because of an IndieGoGo campaign. IndieGoGo is a crowdfunding platform wherein interested parties on the Internet can donate money to the maker if they want his invention or service to come about. The Z Grills Wood Pellet BBQ Grill and Smoker got its $500,000 from its donators and now the previously nonexistent Z Grills Company now exists to make their wildly popular grill.
Z GRILLS or Z Grills is a maker of smokers, grillers, and stainless steel prep work tables galore. It entered the world of pellet grills recently and launched an IndieGoGo campaign in order to fund its “affordable wood pellet grill” for $500,000 and currently gives even Traeger’s economical offerings a run for their money with its ability to accept all types of pellets and do all sorts of cooking styles.
Ease Of Use – Check if the unit is anything but difficult to setup and work. A few units are a breeze to gather, and you should simply to take after the manual of guidelines that accompany it. And after that, you ought to likewise discover how to work the grill and it ought to offer you easily of operation. For the most items I have evaluated here, they can be worked with the push of a catch, so they will let you simply set the clock and temperature and forget about it.

So Kevin here is where you come in. Been wanting to make getting consistent Q on the table regularly and easily. Been looking at pellet poopers for about 5 years now and decided to take the plunge. Had already done enough looking a few years ago Traeger’s issues had scared me off. Several friends had them and raved but always mentioned problems. I decided from my work I don’t want to be buying someone’s, ‘we know the problems and are fixing them’ if you can find something solid for similar cost. Yoder and FEC were pretty much my finalists. So I was doing my final thoughts and found your article.
I do have a question for you that i didn’t already find answered… How important do you feel a pellet release option is for a pellet fed BBQ? I have only found 3 models that have it; Traeger, Cabela’s Pellet Grill, and Camp Chef. It seems to me that this would almost be a must to make things easier to clean up when done smoking. What are your thoughts on the pellet release, and then your thoughts on these 3 pellet grills.
What are your thoughts about the Kalamazoo hybrid grills? From what I’ve found online, you have the choice of gas, charcoal and wood for cooking or combinations of all. I have no first hand experience with Kalamazoo but it seems very versatile? At the moment after a month of researching, I’m leaning towards a Mac/Yoder or a Webber spirit & egg or a Memphis….so in other words, I’m no closer to a decision than when I started. I currently have a 9 yr old treager that won’t break, seriously, I’ve only repainted once with rustolium….dang thing won’t break so I can get a new toy. I sear in a skillet in the kitchen. My treager has the smoke/med/high switch and I want more control, I’ve maxed what I can do and it’s a challenge in cold weather and wind but it was a great start when they were made to last, more than got my money’s worth. I cook at all levels from smoking to grilling. I do love pellets and don’t want an egg but enjoy the food as much as the process of preparing it. Ok probably to much info but money aside, will you list your recommendations of what you think is best for me?

Or the fact that it lives up to its “Ultimate Tailgating Grill” moniker for all you campers out there. You need to watch your roast closely so you won’t have to finish your pork butt in the oven. It’s not quite a “set it and forget it” kind of smoker grill because you still have to make sure that there’s a steady supply of pellets so that it won’t shut down.

Decided that moving these beasts was a little challenging so I bought a Backwoods Party 10 years ago and loved it. But basically have about worn it out. And as I got older I don’t enjoy getting up at 2 AM and then having to get up every couple of hours, after the 45 minutes of getting it ready at 2 AM, to check it and feed it. I also bought a smaller lightly used Open Range, The Good One. Used their recommended method the first time I cooked with it and hated the Q off of it so bad most of it was wasted, wife hated it too and the son ate most of it. It was extremely ash/strong smoke flavored!


If you have an older smoker and need a lot of physical maintenance like changing the hopper and the digital control, then changing those two parts may not help. These two changes may cost you $200 – $250 and with a rusty hopper, you will continuously lose the smoke you produce. This is not safe for your health, so in this situation, you should definitely opt to get a new pellet smoker grill.
The Vulcan is a Picnic Time original design The Vulcan is a Picnic Time original design and the ultimate tailgating cooler and propane barbecue set in one. Don't be fooled by other similar looking items on the market. Only picnic time's Vulcan features a PVC cooler that conveniently nests inside the compartment that houses the portable propane BBQ. ...  More + Product Details Close

Rifles Delivery Confirmation-Adult Signature Required. Customer must provide a physical address for delivery of this item. Cannot ship to a PO Box or APO/FPO addresses. Black powder rifles are not shipped to customers in IL, MI, NJ, NY and Washington, DC because of restrictions. This item will be removed from your order if your shipping address is to a restricted location.
I have used a pellet smoker for about five years, and looked at, or used, many different brands. I have added auxiliary smoke generators, and tried almost every way possible to create authentic BBQ on a pellet smoker— It can’t be done. When the vendors, or users, refer to subtle smoke they mean virtually no wood flavor. Do yourself a favor and try a simple test: go to a really good BBQ joint, or BBQ competition; try some of their Q and then compare it to pellet meat. There is no comparison. I wanted the pellet unit to produce good Q in the worst way because of the ease. You cannot duplicate the smoke created in a wood, or wood/charcoal firebox with compressed sawdust. It pains me to say it but it is true.
Choosing the one perfect pellet grill that could change your cooking experience is easier said than done. There is just so know you have to know before committing to it. Though I did give you a run-through of all the basic and important things to look for in a pellet grill before buying one, it is still a scratch on the surface. It is tiring to have to go from store to store to find the quality ones that you can choose from. So, to come to your rescue once again, I will now give you the some pellet grill review.
I bought a Yoder YS480 three years ago. I still use my cheaper pellet grill for everyday smokes, but I use the Yoder when I want to get serious. It does a beautiful job on baby back ribs (can do up to 8 racks laying flat on the grate) and I have smoked two complete turkeys at a time. The only time I have had a problem after 2 1/2 years of smoking was caused by a failed temperature probe. I got a new probe, installed it in a few minutes, and was back up and smoking again.
I have owned a Memphis Elite (built-in) for 16 months now. It is a very high quality product, and couldn’t be easier to use. The direct flame area is arguably a little small (effectively a bit smaller than 1 sq ft), but it does a great job. The temperature control is phenomenal, and includes a meat probe control that can put the grill into “hold” mode once the meat reaches the target internal temperature. A very happy owner here!
Heating pellets, meanwhile, can consist of a variety of woods, including softwoods like pine, which contains resin that infuses food with a bitter unappetizing taste. Because it doesn’t really matter what’s in heating pellets, so long as they burn, they can also include bark and leaves and other impurities that can adversely affect food flavor and possibly pose a health risk if ingested. Because less care goes into the production of heating pellets and they're not guaranteed to be 100% pure hardwood, heating pellets are significantly less expensive than BBQ pellets, making them appealing to budget conscious shoppers. However, resist the temptation to save a few bucks and never use heating pellets in a pellet smoker.
JUNK!!!!! Major defects and powder coating coming off and possibly getting my family sick. Very rude customer service telling me to just take it back to Costco! Did I mention I bought the biggest one and will need to disassemble the entire thing to fit it in my explorer! I will be sending the paint chips that came off to a lab to determine what the stuff is and if my family has been exposed to carcinogenic chemicals. A $1,000 for Chinese junk....Stay away for your families sake!!!!!
The great part about this smoker is that it is fairly light-weight, weighing in at 69 lbs, and its legs double as handles: all you have to do is fold the legs up and carry the smoker wherever you need to! Furthermore, this smoker comes with a 12V connector that you can plug into the cigarette lighter of your car, and a 12-foot alligator clips that you can connect to your car’s battery if necessary. You can take this smoker anywhere!
*Big R strives for accuracy in our advertising, but errors in pricing, photography, and/or description may occur. Big R reserves the right to correct any such errors. Photography is for illustration purposes only and may not reflect actual product. Big R reserves the right to limit quantities ordered and the right to accept or decline any E-Commerce order.
Thanks for the quick response and advice. I see a pellet pro hopper assembly is around $250 compared to the Memphis pro at over $2000. I didn’t realize that drafting isn’t important for the sake of temp regulation but what about how the smoke travels from the firebox towards the meat? I also would like to include an element of humidity, is simply putting a pan of water in the cooker or is there a better way?
Pellet grills come in many different sizes that accommodate food as per those sizes. However, even the smaller kinds are able to cook up a meal for a large family of 4 to 5 at a time! The larger ones are obviously able to accommodate large portions of meat and other food in it. In fact, some large pellet grills are used to cook up a whole baby lamb or large fishes at a time! This is one appliance that has been proven ideal for feeding a lot of heads at a time without the stress and the hard work of course, making it great for small to medium parties and get-together.
To your question regarding Traeger, I’ve not reviewed their grills of yet. I do know that Traeger as a company is taking steps to up their game some, as quality/reliability of their pellet grills has diminished over the last few years. The new CEO – Jeremy Andrus – they hired comes from the Skull Candy company and brought that headphone company from annual sales from less than $1 million to nearly $300 million. I know also that a few big hitters in the BBQ world are being contacted by Traeger to bring the brand back to its former prominence. You can read more about that here from the site of one of the company’s that now has an ownership interest in Traeger: http://www.trilantic.com/News_Story.aspx?StoryType=1&ID=56.
PG24 by Camp Chef has a weight of 124 lb with a pellet hopper that has 20-pound capacity. That’s so large, you won’t need to worry of getting more before your meal is done. This approach allows you to have the ultimate cooking experience. When the temperature drops, one wood pellet is released. This convenience can’t be found in other grill types, like gas or charcoal.
The cooking process is made a lot more convenient with this smoker. To start cooking, all you need to do is flip the Traeger on/off switch, and you’re good to go. Then, you can simply set your desired temperature through the digital controls. Enjoy your time and relax while you leave the unit to do everything else. With its efficient temperature control system and automated auger with an induction fan, heat remains constant throughout the cooking process. You’ll have evenly-cooked foods that have that mouth-watering smoky flavor in no time.
Kevin, Im about ready to pull the trigger – im pausing for a moment to consider your thoughts as you mentioned Grilla Silverback or Camp Chef. How do these compare to the Rec Tec on quality and price? (as they are less than Rec Tec) And reverse sear…how well does this work on pellet grill, ie how long does it take to go from 200 cooking temp to 500 searing temp (with grill grates)? Thank you for your time
Thanks Kevin for the reviews and content. Like many of the folks I too will be purchasing a pellet pooper. I have narrowed my choices to a MAK 2 star and a Memphis Elite. One of the earlier posters indicated on the Memphis that the effective direct grilling space was about 1 square foot. I am assuming that with the smaller footprint of the MAK that the direct “flame zone” is less than that. I’m just wondering how much less.
Background: I've had this flat top for a month now and do 99% of my cooking on it. I have it set up next to my kitchen balcony which allows me to cook outside in most weather conditions and allows me to keep my kitchen clean for the most part due to a natural gas hook-up that I have outside. I purchased the Natural Gas Kit Hose (NGKIT) and converted the flat top to only intake natural gas. Please note that once you make the conversion then you cannot convert it back to propane unless you get new orifices. I had to drill all 4 orifices with a #45 drill bit to ensure that sufficient gas will be funneled through to the flat top. This process took a couple hours and will take more if you don't have the proper tools.

Many of the models require you to clean them up for 30 minutes because you have to take out the gooey deflector plate and the greasy grates in order to scrape them off and wash them until they’re shining. Careful cleaning is required when the grease and carbon are covering the deflector plate. The easy-clean grills typically make the parts more accessible but the amount of cleanup remains the same.
A good pellet grill can hit high temperatures for that perfect steak and still hold a steady low and slow temperature for great barbecue. All the while adding great smoke flavor from hardwood pellets. These pellet grills cost more but do so much more while being highly efficient, precise in temperature and widely capable. Among these, you will find cookers large enough for a whole hog as well as units with full network interfaces for controlling from a distance. These are the best of the best in Pellet Grills.
First off, in general I was a huge Traeger fan due to my brother-in-law smoking up meat and fish for us for the past 3 years and it was just damn delicious. He also just raved about his Traeger, so finally I took the plunge and purchased a Century 34 model during one their Costco road shows. Customer Service - In general I will give them 4 stars because I am talking with a human, they were seemingly very thorough when I spoke with them and didn't appear to be reading from a knowledge base article when I described the problems. I also grilled them to ensure that the Costco specific model wasn't being manufactured with subpar parts since the price was so much less than retail and seemingly more bells and whistles. More than one representative confirmed that was not the case. This is where it stops being good news.
Green Mountain pellet smokers offer innovation and good quality as well as relatively low price points. The Daniel Boone model is the midsized version. It boasts an advanced digital touch-pad dual-probe controller and stainless steel grates and drip pan, and, with 13.5 inches of headroom, Daniel Boone can accommodate large turkeys and roasts. Although the WiFi option adds a hundred bucks to the bill, few pellet smokers anywhere near GMG's price range offer WiFi control. Download the GMG app to your smartphone or tablet for a point-to-point connection, enabling you to remotely turn Daniel Boone on and off; monitor and control the internal meat temp, cooking temp, and timer; and even store the time- and temperature-based profiles of your favorite recipes. For example, you can set your Daniel Boone to "Tri-Tip Beef Roast" and have it start out cooking at 225°F (105°C) until the internal meat temp hits 110°F (43°C), then crank to 500°F (260°C) for browning until the meat registers 135° (57°C), then drop the temp to 150°F (65°C) to keep it warm.
Green Mountain pellet smokers offer innovation and good quality as well as relatively low price points. The Daniel Boone model is the midsized version. It boasts an advanced digital touch-pad dual-probe controller and stainless steel grates and drip pan, and, with 13.5 inches of headroom, Daniel Boone can accommodate large turkeys and roasts. Although the WiFi option adds a hundred bucks to the bill, few pellet smokers anywhere near GMG's price range offer WiFi control. Download the GMG app to your smartphone or tablet for a point-to-point connection, enabling you to remotely turn Daniel Boone on and off; monitor and control the internal meat temp, cooking temp, and timer; and even store the time- and temperature-based profiles of your favorite recipes. For example, you can set your Daniel Boone to "Tri-Tip Beef Roast" and have it start out cooking at 225°F (105°C) until the internal meat temp hits 110°F (43°C), then crank to 500°F (260°C) for browning until the meat registers 135° (57°C), then drop the temp to 150°F (65°C) to keep it warm.

Thank you so much for the kind words! I think you would be very happy with a smaller pellet grill / smoker. The wording changes depending on how you are using the device. For instance, if you are cooking at low temperatures you will get a stronger smoke profile then if you burn a pellet smoker / grill at its higher temperature range. One thing you could do for steaks is cook them at the higher range thus being able to get a sear much like you would on a direct heated Grill service, for instance on your Weber. Another option would be to cook the steak in the reverse see your method, by bringing it up to temperature at a lower smoker setting and adding some smoke flavoring that way, then removing it and bringing the smoker up to its higher settings so you can finish off the steak with some of the effect you would achieve on direct flame. I normally do this by bringing the steaks up to about 15 degrees below where I want them to finish. Then, I finish them off at the higher temperature to where they are about 5 degrees below my target. This usually means a few minutes on each side but I use a Thermapen to be sure.
One thing we humans tend to forget amidst hustle bustle of our fast paced and commercial lives is that we should earn to live, not live to earn. So I think it is high time you ditch your shoe-box of an office behind for a day and live. Spend a day with your family at the park, or maybe catch up with your childhood friend over a beer or two and start doing barbecue. You cannot even begin to imagine how much spending some quality time with your loved ones can help you and them, revive and replenish the monotonousness. And there isn’t a better way to mingle than over a small get-together with some amazing food and great company cooked on your pellet grill.

In some ways, it’s surprising that something so small could be the culprit behind so many problems on a hi-tech cooker like a pellet grill. Then again, pellets are your grill’s fuel and using bad pellets is like using subpar charcoal in a kamado, and it can cause the same problems—too much ash is produced, making it hard to hold a steady temperature and snuffing out the oxygen supply to the fire.
So Kevin here is where you come in. Been wanting to make getting consistent Q on the table regularly and easily. Been looking at pellet poopers for about 5 years now and decided to take the plunge. Had already done enough looking a few years ago Traeger’s issues had scared me off. Several friends had them and raved but always mentioned problems. I decided from my work I don’t want to be buying someone’s, ‘we know the problems and are fixing them’ if you can find something solid for similar cost. Yoder and FEC were pretty much my finalists. So I was doing my final thoughts and found your article.
Hi Jennifer, the Traeger grill you purchased should serve you well. You can see a picture of one of them installed here. I think this is the grill style you bought. One thing the sites you’ve researched (including my own article above) might not have stressed is that Traeger recently hired a new CEO and is actively working to attain the name, reputation, and reputation for quality that they once had. I’m confident should you have any problems with your unit that they will stand behind it and take care of them for you.
Standard shipping via common carrier "Threshold Delivery" is included in the quoted price. "Threshold Delivery" includes placement inside your front door or garage. Delivery can only be made inside the front door on the ground floor of multi-level housing. Carrier will call or email to set up a delivery appointment. Please include a daytime phone number in the shipping information at the time of check out and please monitor your emails for an opportunity to set your delivery appointment. Deliveries are made between the hours of 8 AM to 5 PM, Monday through Friday, and will be scheduled as a 4 hour window. Extraordinary delivery requirements may necessitate an additional fee to the carrier. NOT INCLUDED: Placement in your room of choice, removal of packing materials and assembly are NOT included. 

This smoker offers a decent 418 square inches of grilling space. This is enough to cook around sixteen burgers or four whole chickens. If the grilling space isn’t enough, Traeger also offers a larger unit that offers the same features at a higher price range. But the medium sized one is enough to cook for large groups of people already. Built to have a high capacity, this smoker allows for multiple cooking at the same time.
The argument for bark is that it smolders really well, providing more smoke during the cook and therefore more smokey flavor. Think about it: When you put a log on the fire, the bark almost immediately begins to smoke and smolder. And therein lies the second half of the pro-bark argument: when cooking on an offset you use logs with bark, so why should pellets be any different?
Thank you for a very comprehensive review and all the helpful advice. I would like to know your thoughts about having the burn pot in the center area as in the Rec-Tec, or on the side. My only interest is smoking, not grilling, and I prefer even heat throughout the cooking chamber. How much difference does the location of the burn pot make? Thank you very much.
So, there they are: my pellet grill review of 2016-2017.These information are surely going to help you from going nuts when trying to purchase your own pellet grill. These pellet grill review will give you a clear straight forward understanding of the best and most conventional features in pellet grills in the market today. Now that you are all set thanks to the pellet grill review, go grab yours, call some friends over and have a great weekend!

The Rec Tec Bull is built for serious smoking. The stainless steel chamber doesn't have paint that will chip or peel, and the built-in Wi-Fi technology allows you to monitor your cook from anywhere in the house. And with two meat probes you'll have more flexibility when cooking different types of meals. The 40-lb. hopper and interior LED are features the backyard pros will love.
Who says bigger is always better? Our fourth contender to make it to our pellet grill review is the The Traeger TFB29LZA Junior elite grill. This petite pellet grill has been specifically designed to meet the needs of small households. Its small body makes it ideal for travelling and tailgating. It features a 300 square inch cooking surface. This pellet grill weighs just 60 pounds. You will get an LED digital, multi-position thermostat that comes with a 3 year warranty.
When you’re buying a pellet smoker vs a wood smoker, what you’re buying is convenience and simplicity of use. Whilst electric smokers are arguably more convenient than pellet based smokers because they start quicker, only need a power point and a handful of wood chips, pellet smokers are still incredibly easy to use and far more convenient than wood smokers.
There is no party like a backyard grill and BBQ party on a hot summer weekend with some good music on the back, and of course the centerpiece: the food. You see, food is a universal language. It is a way to say how much you appreciate and care for one another; a way to people’s hearts. And there is nothing more comfortable, warm and heart than some good old open grill and BBQ cooking on your pellet grill. And this is the reason you need an expert pellet grill review. 
This pellet grill has a 440 square inch cooking surface and weighs 73 pounds. It measures 36 by 18 by 39 inches in dimensions and is made out of durable steel and heavy duty 16 gauge steel construction. It has a dial-in control with an LED read-out. Its temperature reaches from 180 degrees to 500 degrees Fahrenheit. It also comes with a meat probe. This Pit Boss is a worthy name to be in our pellet grill review’ list.
I was so excited to get this grill for the weekend. It was easy to assemble and get going. It has a great place for me to keep my bbq tools and a front rack to set stuff down so I am able to easily put things on and off the grill. We made steak and lobster tails and they could not have turned out better and it came with a cookbook to know exactly how to do it!

Instead of logs, the pellet smoker is fed with food-grade cylinders of wood pellets that are an inch long and ¼-inch wide and are made of compressed hardwood sawdust. According to the best pellet smoker reviews, pellet grills are easy to use because it’s easier to maintain its temperature because of these sawdust pellets that are subjected to great heat and high pressure, which ignites lignin (natural wood glue).

I have always been a believer: “do what you love and you’ll never work a day in your life”. I’ve been lucky enough to use my professional experience in the meat industry over the past 20 years to create a business where I love to go to work. Smoking Meat Geeks is all about bringing people together that enjoy food as much as I do. We provide a place for everyone to share thoughts, ideas, and recipes; to be a go-to spot for cooking inspiration. Feel free to leave a comment, say hello, or provide any tips. There is no right or wrong input, as long as you’re engaging, you’re a Meat Geek!

Another pellet smoker from industry leaders Traeger. The Lil Tex Elite is an upscaled Junior Elite, and whilst it’s still a good quality smoker and grill with a powerful burner and excellent heat output, plus all of Traeger’s usual electronic gizmos. There’s just not enough of a difference between this and the Junior Elite, especially not when you consider the increased price tag, which is disappointing.


We did return the Traeger to Costco for a full refund. It's not that Traeger has poor customer service; they don't have any customer service. We brought a Bradley Smoker, an upright design, and it has performed much better than the Traeger. The Bradley also takes up much less space and we've placed it on a dolly so it can be rolled around. Overall, a much better solution.
After owning this grill for six months I can honestly say I don't regret my purchase. I was waiting for low temp weather to really test this grill and i must be honest i was very surprised. I grilled 400 degrees with the outside temp at 38 degrees and the grill came up to temp within 20 minutes. Last night I started a brisket in 31 degree weather cooking at 225. No problem at all, and I haven't use a thermal jacket. We have done every thing from low and slow to baking and just have been amazed at outcome. Got a couple of more tests that i want to do, but six months, it's great. Stop thinking about it, stop worrying about the price, and prepare to make some great wood fire food.
We purchased our wood pellet grill (Model TFB57CLB) from Costco in August 2017. It came with one bag of the gourmet blend pellets. We used the Traeger cookbook to try a few different recipes in the fall. Most of these involve a period of smoking followed by a period of grilling. The grill seemed to work fine at first. We used it a couple of times on warmer days in the winter and it had some trouble getting up to the desired heat level. We started using it regularly again in April 2018. I was careful to clean it and check the pellets etc. The smoking feature seemed to work alright, but when I would turn the heat up for grilling, the grill would usually struggle to get much over 225. I would resort to turning it up to 375 or more just to get it to 225 and then often it would sink back down to 180 or 160. I went to the troubleshooting guide on the manufacturer's website and checked all the components, which seemed to be working fine.
When a product is listed as Pre-Order, such product is not yet in stock but is available for advanced purchase on our site, prior to the manufacturer's public release date. Pre-Order items are shipped once in stock and the public release date arrives. You will be notified of a product's updated status by email. The expected shipment time is listed on the Product Detail page.
I’ve been grilling and smoking for many years and throughout all those years I have burned through many expensive grills. Four years before I purchased the 640 I got on the pellet smoker wagon and started my research. Finally when my daughter was getting married she ask me to cook for the wedding and gave me the perfect excuse to finally get a smoker I wanted. So getting back to the research and after 3 months of comparing I settled on the YS640. I wanted a grill, at my age, to be able to pass down to one of my kids. It was big investment but like I’ve learned in life, you get what you pay for “most” of the time. I have had this grill now, September 2018, will be 4years now. I have no regrets and would do it again. I’ve had some minor corrosion issues and after an email was promptly sent the matching paint to clean it up. I spent the time to do it right and today, a month later, today my grill looks brand new. Honestly nothing like this can be left to take care of itself. Maintenance like anything else is required. But I know this will most likely be my last grill. Thank for a great product and great follow up service. Smoke Shack.....
After about 10-15 hours of cooking, you should remove the burn cup and dump the ash. If the ash builds up it can prevent ignition. Ash also accumulates in the bottom of the unit, but doesn't impact cooking. A vacuum cleaner with a hose makes short work of it. Only a few manufacturers, such as Blaz'n Grill Works and Camp Chef have a slide out combustion cup that makes cleanup much easier, but you still have to get underneath the deflector occasionally and suck out fly ash that has scattered around the lower part of the grill body.

Hey Mike, thanks for touching base. It’s always a pleasure to connect with you, man! If you have the space, I’d go with the JB. You can always cook under your pellet smoker’s capacity, but you can never cook more than it will hold! As such, you can always find use for the extra room in the JB. It’s like the umbrella and the rain scenario – bring one and you’ll never need it. Go out without one, and it’ll pour on you! Holding temp and managing the cook is the same for each of these GMGs. You’ll have smooth going with both, I’m sure. If you are cooking in very cold temps, you might want to consider the thermal blanket GMG puts out. Helps a bit re: getting to / maintaining temp. Some folks use it all the time as they feel it keeps more smoke in the chamber. As you know, nearly all pellet smokers produce a bit less smoke than your barrel smoker will. Hope this helps, bro! Thanks for your comments!
Most people recommend the Green Mountain Grills smoker for its affordability, despite its plethora of features including Open Flame Technology, which ensures that meats are thoroughly cooked. But what impressed us the most was its Sense-Mate feature. For a budget pick, we were surprised to see that it had some of the most advanced technologies that even the most high-end products use. There’s no denying that you’ll get more than what it’s priced at!
I got my YS640 for a combination Father's Day/ Birthday gift and regardless of whether it's grilling or smoking beef, pork or chicken the results have been outstanding. I can hardly wait to break out the turkeys for the Holiday meals. The direct grilling grates leave a steak with beautiful grill marks and the use of the fruit wood pellets along with quality steaks have made for some incomparable meals. As for quality of the smoker itself, I have sons-in-law that are already jockeying for position to try to be the next to have the YS640 after my demise - - - and we're figuring that won't be for at least 20-30 years!
The Silverbac and the Silverbac original models of the Grilla Grills come with a good build. It has a stainless steel burn grate and a stainless steel firebox with a rugged exterior. It is painted with a high-temperature powder coating on a heavy-duty steel body. The seams are welded, caulked and powder coated for a three-layer weather resistance. Its lid and all the internal components are made of stainless steel, greatly improving this product’s life.
I believe the little Green Mountain Davy Crockett is the best portable pellet smoker currently on the market. Surprisingly, many of the portables out there still have an antiquated LMH controller, while Davy Crockett employs Green Mountain's advanced digital touch-pad controller, with an integrated meat thermometer that lets you check internal meat temp with the flick of a switch. Furthermore, it includes adapters to run the electronics from your car battery or cigarette lighter. And Green Mountain is aggressively—ahem, hello, price cut—promoting its WiFi capabilities, which enable you to monitor Davy Crockett from your smartphone or laptop.

Built from substantial stainless steel, the SmokePro looks bombproof and weighs a hefty 140 lbs – so it’s not portable like the Z Grills or Traeger Junior Elite. It has a stainless-steel probe to directly monitor meat, and a sensor for the grill’s internal temperature. Both read out on the LED display next to the digital controller, which goes from 160F to 500F in 25-degree increments.

"Camp Chef is excited to join the exceptional family of Vista Outdoor brands," said Ty Measom, Camp Chef President. "The opportunity to be part of this dynamic company will provide for the future growth and success of Camp Chef as a leader in our market. The hard work and dedication of Camp Chef employees, past and present, has made Camp Chef what it is today. We look forward to the opportunities ahead."
The smart-smoke technology in this grill uses an automatic electric feed system that is able to maintain a constant temperature from 180 to 450 degrees and has a hopper that can hold up to 20 pounds of pellets for extended cooking time. The digital control also handles igniting the pellets while fan-forced convection results in even cooking all around, much like rotisserie-cooked foods.
Its advanced cooking system comes with a “set and forget” temperature control system that is monitored using its programmable meat probe. Its flame broiler allows for direct and indirect cooking. It has an automatic start up and cool down feature and LG’s proprietary exhaust mechanism for even second tier cooking. Its adjustable temperature can be set from as low as 170 F to 600 F.
But as said, there are a few things we don’t like; it’s relatively small, doesn’t have a lot cooking space, and the design feels cramped. At the same time, it’s still relatively heavy at 140 lbs. For the same price, you could choose the Z-Grills Master 700D, which packs almost 25% more surface area on the rack. That doesn’t seem like much but is a significant amount of room.  Or you could just spring for the Traeger Pro 22. There have also been reports of poor quality control, and that the temperature control is very inconsistent, often swinging up and down nearly 30 or 40 degrees.
The argument against bark is that it can cause an inconsistent burn and produce excessive ash. Again, consider a log on a fire. Because they have different compositions, the bark and hardwood burn at different rates and produce different amounts of heat. Furthermore, bark doesn’t burn cleanly, it creates more ash than the hardwood. When that ash builds up, it interferes with your grill’s ability to accurately read the temperature, causing large swings. If too much of that ash builds up in the fire pot, it can cut off the oxygen and snuff out the fire.
As another criterion that we took into consideration, we felt that the pellet grill size was important to include in our selection process. One of the main reasons is because we wanted to share a wide variety of pellet grills that were designed for multiple uses. With that said, other reasons include the size and weight of the grill as well as the price. Meaning, the bigger the grill the more pricey it can become and the more it will weight depending on the material design. However, we also wanted to share compact varieties such as the Green Mountain Grill which is perfect for tailgates and small outdoor events or camping.
Many people misunderstand a pellet grill of consuming a large amount of power for its working. But it is not even remotely true. While it is true that a pellet grill will use up a good amount for power initially, but it only uses that to come to temperature and form. Once it is ready and in form, it power consumption drops so dramatically that some pellet grills use almost as little power as a light bulb; an ideal choice for keeping power costs to a minimum.
The Fast Eddy's by Cookshack PG500 Pellet Smoker is a collaborative design from respected smoker manufacturer Cookshack and competition-barbecue-circuit pro "Fast Eddy" Maurin. The FEC (Fast Eddy's by Cookshack) line has been popular with competitive teams for years. While most FEC models have a utilitarian appearance, the beautifully crafted stainless steel PG500 fits right in with your shiny outdoor kitchen.
Coming over to the cooking area, you will find 2 stainless steel grill grates that give you 702 sq. in. of cooking space with an option of the second shelf that makes it 1054 sq. in. Its tall enough for turkeys and large enough to fit 6 large-sized racks of ribs. So, hosting a bunch of people for a BBQ party, and cooking delicious meat for them, would be as easy as it could get.
But as said, there are a few things we don’t like; it’s relatively small, doesn’t have a lot cooking space, and the design feels cramped. At the same time, it’s still relatively heavy at 140 lbs. For the same price, you could choose the Z-Grills Master 700D, which packs almost 25% more surface area on the rack. That doesn’t seem like much but is a significant amount of room.  Or you could just spring for the Traeger Pro 22. There have also been reports of poor quality control, and that the temperature control is very inconsistent, often swinging up and down nearly 30 or 40 degrees.
Need Help?  Have a question or comment?1-888-827-4223Email UsGet Exclusive Offers & Expert TipsJOINTerms of UsePrivacy PolicyInterest Based AdsFor U.S. Residents Only © 2018 Ace Hardware. Ace Hardware and the Ace Hardware logo are registered trademarks of Ace Hardware Corporation. All rights reserved. For screen reader problems with this website, please call 1-888-827-4223 or email CareCenter@acehardware.com.
Pick an item that is anything but difficult to clean and store. Stay away from massive units on the off chance that you don’t need your grill to stick around in the kitchen when not being used. You may likewise need to pick one that your space can suit. And afterward, search for a model that can be effortlessly cleaned and that accompanies a deplete framework and an oil/dribble plate/gatherer.
I'm a certified BBQ Judge and found the following; The new portable Traeger Ranger seems to be not well thought out. All the cooking directions are for the large units and over cook everything in the smaller unit. All the pellet smoke is wasted, it is drawn out the back vent and very little ever reaches what you're cooking. They have a grease bucket on the back that is supposed to catch the grease but doesn't, Grease coats the inside of the bbq and runs down the sides and out of the grill landing on whatever you have the grill on. I've been using this Traeger Ranger since June 18, 2018.

Pellet grills preheat quickly, so you can start cooking almost immediately, and the pellets are available in a number of woods, for different smoke flavors. The smoke has a subtle wood-fired flavor with less of the acrid flavor that comes from standard wood or charcoal. For the maximum smoke flavor, it’s best to cook at a temperature lower than 250 degrees, while higher temperatures cook faster with less smoke.
×