In true Yoder fashion the 640 is not a fancy cooker with lots of shiny things, bells and whistles. Don't mistake that for poor craftsmanship, the Yoders are all built to the highest quality standards. They just happen to be more muscle car than sports car. Big, bad ass, built to last American muscle car that will blow the doors off the competition on your back deck or on the comp trail.
12 Month Financing: For a limited time, purchase $599 or more using the Amazon.com Store Card and pay no interest for 12 months on your entire order if paid in full in 12 months. Interest will be charged to your account from the purchase date if the promotional balance is not paid in full within 12 months. Minimum monthly payments required. Subject to credit approval. Apply now.
So, we’re here to discuss the different cooking times and temperatures for different types of meat so that you don’t overcook or undercook your meal. But for the health concious, they should avoid certain meats. It’s worth noting that we’re here to discuss the temperatures needed for slow cooking and these should not be considered as universal standards for searing or grilling.
Like other grills, pellet grills list cooking area two ways: primary cooking area, which refers to the main cooking grate, and total cooking area, which is the main cooking grate plus any secondary racks. However, since pellet grills are primarily indirect cookers, there really is no difference between cooking on the main rack or the upper rack&em;the temperature should be the same. Therefore, a smaller pellet grill with a primary grid of 450 square inches and an upper rack of 125 square inches may be a better option than a larger grill with only a 500 square inch primary grid.
You like the idea of cooking different types of foods on the grill: If you’re someone who wants to grill food other than meat, the Traeger grilling system gives you this option. With the precise temperature control of the Traeger, cooking things like fruit pies can be a successful endeavor, something you wouldn’t dare try with a propane-fired grill.
The digital controller has a temperature dial (180 F to 400 F), shutdown cycle setting and an on/off switch which is very basic. Compared to the Camp Chef, it misses out on bypass startup button, food probe, feed button, lo smoke/high smoke settings and most importantly access to the fuse. In order to change the fuse in the Traeger, you’ll have to remove both screws on the digital controller and pull out the controller.
This purchase, the customer service and the lack of understanding from Traeger Pellet Grills, LLC, has been very unfortunate.  I've since stopped payment with AMEX and Traeger is now telling AMEX that they will do nothing until they get the damaged grill back.  Well, I'm in Florida and my brother is in Virginia, and at his age is not capable of handling a Grill that weighs over 100 pounds by himself.  Additionally, he's not a "Grill Repair Man" and does not have the knowledge to tear down a Grill Body including electronics and putting it back together as assembled at Traeger.
Words like Grilling, Barbecuing and Smoking are often used interchangeably by us. However, when looking at them from a grill master’s point of view, there are some subtle methodological differences among these three: One is done with the lid up, BBQ is done in a closed circulation with the lid down, and smoking is a slow cooking process in a closed circulation.
As far as backyard cookers go, Pellet Grills are the newest products on the market. With their roots in the 1970’s, these versatile outdoor grills combine the capabilities of a traditional grill, with the wood-fired flavor of a smoker, and even the convenience of a modern oven. The “Pellet” in the name refers to the specific variety of fuel used. These are specially made cylinders constructed of compressed sawdust. The grill is powered by electricity and doles out specific amounts of pellets to maximize fuel efficiency. The primary benefit of these types of grills is their versatility. Wood pellets can be burned at all different temperatures and volumes, making it possible to sear, smoke, or slow cook a whole array of meats in an infinite variety of styles.

Actual Cooking: This flat top is a game changer for cooking. The grill heats up very fast and heats up evenly across all 4 burners. It also has traditional grill grates beneath which makes this a 2 in 1 grill. You can cook a plethora of items ranging from tacos, cheese steaks, quesadillas, eggs, pancakes, hash browns, fried rice, assortment of Chinese dishes (beef and broccoli, Mongolian Beef, Garlic Chicken with Veggies, etc), and basically anything that could be cooked in a typical cast iron pan or skillet. It heats up bread, tortillas, and buns in a matter of seconds. The flat top itself can accommodate a lot of food at once and can cook for up to 50 people per hour at max capacity. The ability to cook multiple items on the flat top at once is especially helpful for cleaning as you won't need to have multiple cooking pans or skillets to clean up afterwards. Anyone that has the ability to use this as their main cook top should do so.


Cleaning/Maintenance: The grease catcher on this flat top is pretty decent. It is located on the bottom left hand side and all the oil/grease gets caught without anything dripping elsewhere. I usually wipe the grease catcher's orifice down with a paper towel to ensure it does not get clogged up over time. Other flat-top grills have either grease catchers that drip onto the leg of the grill or have them in the back of the flat top which is a little inconvenient getting to. As for cleaning after every use, I use a stainless steel scrapper/chopper to wipe the grill clean after I am done cooking. I scrape everything down into the grease catcher. For saucy foods or foods that might stick to the flat top, I use water when the grill is still hot to scrape it off and send it to the grease catcher. Afterwards, I put a little bit of oil onto the flat top and spread it all over using paper towels to maintain the seasoning before putting the cover on. Total clean-up time and re-seasoning takes roughly 3 minutes.
We are going to take the guesswork out of it for you. Here at Grills Forever we have seared, smoked and grilled on grill after grill so you can have the latest information on what smokers are the best pellet smoker grills. These best pellet smokers can sear and cook the most delicious foods, they are easy to control and convenient to use. We took all these features and more into consideration while compiling the top 10 wood pellet smoker review.
For example, many grills use and charge for collaborating with a software application on it. I, personally, think this is an absolutely silly feature to include on a pellet grill. Yes, it does start on and off from your phone and change temperatures while you are at Switzerland enjoying Swiss cheese on a lake, but really, is it even logical? I mean, pellet grills have already made the cooking experience as easy as a dream, the least you can do is set the temperature by the click of a button on the appliance yourself! You can’t possibly be that lazy!

What’s more, as Pellet Grills are electric-powered and regulate their own fuel intake, they are a far more foolproof option than other smokers and grills which may require a large amount of maintenance and care during the cooking process. Wood pellets themselves are also incredibly versatile. Aspiring smokers can experiment with a whole array of wood varieties in order to explore the flavors that each lends to meat.


Pellets not Lighting: It’s a simple issue. There is a problem either with the connection of your lighting rod or a damaged system. Repairing the wiring, if that’s where the problem is, might be a little complicated for most. So, for the average griller, the best and the easiest option is to replace the lighting mechanism altogether. When you buy the replacement part, it will come with a detailed instruction manual that anyone can follow.
First off, in general I was a huge Traeger fan due to my brother-in-law smoking up meat and fish for us for the past 3 years and it was just damn delicious. He also just raved about his Traeger, so finally I took the plunge and purchased a Century 34 model during one their Costco road shows. Customer Service - In general I will give them 4 stars because I am talking with a human, they were seemingly very thorough when I spoke with them and didn't appear to be reading from a knowledge base article when I described the problems. I also grilled them to ensure that the Costco specific model wasn't being manufactured with subpar parts since the price was so much less than retail and seemingly more bells and whistles. More than one representative confirmed that was not the case. This is where it stops being good news.
A pellet grill like the Rec-Tec is a breeze to use; subsequently, you won’t need to manage a migraine when barbecuing or smoking. Most models now accompany an electronic start highlight, which means you don’t need to use gas or charcoal for grilling or smoking (Read here). Furthermore, with this element, you don’t likewise need to manage the temperature changes in the earth on the grounds that the unit will be lighted by its electric igniter whatever happens, and after that, it will begin warming and cooking your nourishment. Furthermore, regardless of you are a piece of a little or a major family unit, there is the correct model with the size perfect for your family’s cooking needs.

My propane smoker lived a good life, but after just 18 months it's another rusted out piece of junk that's was unsafe to use. I wanted to replace it with something that would last so I began researching the internet. I was delighted to stumble upon 1) pellet smokers and then 2) the Yoder 640. This is a premium price item that had me wondering if I should spend that much, but I was sold by the online reviews and YouTube video's. ATBBQ had it at my house in less that 5 days and the build quality, ease of use, and the food it helps produces are all second to none. I'm thrilled companies like Yoder can build the best products in the industry right here in America! Its a large investment in cooking, but worth every penny.
The digital controller has a temperature dial (180 F to 400 F), shutdown cycle setting and an on/off switch which is very basic. Compared to the Camp Chef, it misses out on bypass startup button, food probe, feed button, lo smoke/high smoke settings and most importantly access to the fuse. In order to change the fuse in the Traeger, you’ll have to remove both screws on the digital controller and pull out the controller.
This smoker comes with two cooking settings: hot and fast, and low and slow. Its Digital Elite Controller makes setting the temperature a breeze — all you have to do is turn the dial to your desired temperature, and you can leave it for the rest of the cooking process. This smoker can reach the temperature of up to 450 degrees Fahrenheit. The digital display on top of the grill lets you monitor the heat conveniently.

Even after reading the reviews and watching the videos I was still not prepared for seeing the 640 when it arrived. What a machine! A tank? Yes it is, it makes other brands look cheap and disposable by comparison. I was nervous paying a little more for a Yoder wondering if it was worth it, it was worth every penny. Have only used it a few times for ribs and chicken which turned out great. The wife said 'How much?!' when I ordered it, now she says we should have got one years ago.


Having the same problem as the rest of the group. Rec Tec, Yoder, Green Mountain, Pellet Pro, or MAK? All seem to be heavy gauge SS, Pellet Pro seems really good value, MAK and Green Mountain seem to have controllers with more features. Have a friend who bought Rec Tec 3 years ago, he cannot say enough about the good customer service and the grill. If you could only buy one (money not the issue among these 5), which one, and why?
The digital controller has a temperature dial (180 F to 400 F), shutdown cycle setting and an on/off switch which is very basic. Compared to the Camp Chef, it misses out on bypass startup button, food probe, feed button, lo smoke/high smoke settings and most importantly access to the fuse. In order to change the fuse in the Traeger, you’ll have to remove both screws on the digital controller and pull out the controller.
I bought my Traeger Pro Grill a year ago and have thoroughly enjoyed using it. The problems began when it suddenly stopped working. The warranty is a self-service warranty which means you have to service it yourself or load it up and haul it to a distributor for repair should your efforts fail. For this reason I HIGHLY RECOMMEND YOU AVOID BUYING A TRAEGER GRILL. Anytime you pay 1500 for anything a warranty should mean just that, it’s a replacement warranty. I am terribly disappointed with the response from Traeger. Please feel free to contact me should you need further clarification.

Using accurate digital thermometers to monitor cooking and internal meat temperatures is essential to being all that you can be in the backyard. Unlike the caveman-era heat estimators built into the lids of most grills and smokers, modern pellet smoker LED displays will give you the real story of what's happening in your smoker. Of course, if your smoker doesn't come with a dual-display system that monitors both cooking and meat temps, you'll still need an accurate digital meat thermometer.
I spent months checking out Memphis, Fast Eddy, Mak, and Yoder grills. I must say the Yoder is by far the most robust pellet grill of them all. I noticed many reviews with 3 or 4 star ratings for price and I must disagree; fit, finish, build quality, and material robustness of the Yoder was better than the Memphis Pro & Elite...and we all know how expensive the Memphis is.
You then simply select your desired temperature via the digital controls and relax, safe in the knowledge that the temperature will stay steady and there won't be any dreaded hot or cold spots. This consistence is achieved through the efficient temperature control system and automated auger. This ensures a deep smokey flavor is embedded in your meat every time.
This is the right choice for anyone that likes smokey flavors and cooking slow at home. It is my first experience with a pellet grill and I have read and studied them for a while. I was looking for a outdoor cooking solution that would give me the ability to cook like the pros without the super sized trailer. Finally deciding to go with the Camp Chef I haven't been disappointed. The temperature control is flawless so you can dial down the cooking process. I smoked chicken the other day and the red smoke ring was a 1/2" deep. It works like a convection oven so there are no cool or hot zones, it just keeps the heat even and consistent. I have noticed even if smoke isn't pouring out the wood flavors are present.
I would make that decision based upon desired temperature. Very few of the smokers on your list can surpass the 485 to 500 degree mark. You’ll read a lot of discussion about grill grates helping you get into those higher temperatures and that product does work. I would simply pick a smoker that can get to the desired temperature you want like the Louisiana and the Memphis. Both can exceed 500 degrees and both can hit 600 degrees without problems.

Another option is to put a griddle (or GrillGrates) on the pellet smoker when it's cranked to high heat, get it blistering-hot, add just a little oil to prevent sticking, and sear by conduction on the metal. It should take only two to three minutes per side. This is a good technique for reverse-seared meats: You start them indirect, low and slow on the cooking grate, with a little smoke, and then sear the surface with direct contact to the hot metal griddle to create a delicious brown crust. It's not as good as searing directly over hot coals or gas, but it's a good compromise.
By far, the two most popular pellet flavors are hickory and apple. Both are classic BBQ woods, and between the two you can cook just about anything. Hickory produces a moderate smoke that’s strong enough to stand up to the bold flavor of beef, but isn’t so strong that it overpowers pork or poultry. Apple, on the other hand, produces a sweet and mild smoke that complements lighter foods like seafood and vegetables, but also has enough backbone to be used with poultry and pork. Although hickory and apple are the most popular flavors, you can also pair other combinations of moderate and mild woods (such as pecan or oak with cherry or peach) to sufficiently cover all your BBQ bases.
Now, there are different materials that certain pellet grills are made from. Since steel is such a heavy duty and heavy item, some brands have opted in for more cost-efficient materials, such as a stainless-steel lid to remove some of the weight from the pellet grill. With that said, the interior grill gates are as equally important as the exterior. For example, some grill gates are made from an easy to clean porcelain material while some are designed from stainless steel to be more user-friendly and cost-effective. With that said, let’s discuss another important element to consider when it comes to a pellet grill.
The Champion Competition Pro Wood Pellet Grill and Smoker by Louisiana Grills takes outdoor cooking versatility to all new heights. A total cooking area of 3432 sq. in. (8718 sq. cm) and fully integrated multi-chamber smoking cabinets, the Champion Competition Pro is designed to be a show stopper. With direct and indirect flame grilling in the main barrel, hot smoking in the lower smoke cabinet, and cold smoking in the upper smoke cabinet, the Champion Competition Pro is the ultimate grill for the outdoor barbecue enthusiast. This grill revolutionizes grilling in three different ways: the digital control center and lid thermometer allows for precise temperature control of a dynamic range of 60°F-600°F (15°C -177°C) for grilling and smoking, the use of all-natural hardwood pellets allows you to enjoy the amazing wood flavor with the single push of a button, and a programmable meat probe that works together with the digital control center to regulate temperature.
*Big R strives for accuracy in our advertising, but errors in pricing, photography, and/or description may occur. Big R reserves the right to correct any such errors. Photography is for illustration purposes only and may not reflect actual product. Big R reserves the right to limit quantities ordered and the right to accept or decline any E-Commerce order.
It doesn’t matter what it is that you’re buying, you want to get the best bang for your buck and not pay more than you have to. We all have this same mentality when it comes to making a purchase. This is why when we see price tags that indicate something is “on sale’, we immediately think we are getting a good deal. But is that really the case? The answer is no. When it comes to buying your new pellet grill “on sale” from a distributor or retailer, it means that they are essentially reducing the markup that you have to pay. Aside from the rare instances where a retailer is selling a product as a loss leader where they are intentionally losing money on a product to get you into the store and buy other more profitable products, you will still be paying more money in the end than what the manufacturer would price the grill at if they were to sell it to you directly.

I purchased a Traeger Select Elite from Costco for both my personal residence as well as for my vacation home. I am now on the third grill at my residence. Traeger will tell you that they expect to offer Awesome customer service. I have replaced the auger assembly, the controller and now the fan. I can't get the grill up to temperature. Awesome customer service says it should be no problem. Just replace the _______ (fill in the blank). I don't think these people have ever seen a grill let alone use one. Costco (love their return policy) is about to get another one back. Am I too harsh to expect the product to perform as they say it will? I would think when you pay as much as Traeger thinks their grills are worth, that they should work out of the box. Well, quality control under the new management has gone to hell. Then they expect you to "try" all the fixes that might work on your own. This is self service, not customer service.


For a large-sized smoker, the Camp Chef SmokePro SE delivers excellent, smoky-tasting flavor that even beginners can accomplish. This is largely due to its automatic temperature control features and grease management system, allowing you relax while it cooks for you. With minimal cons (only weight and pellet price), this is a definite hit among professionals and newbies. The SmokePro SE is an unquestionable bang for your buck kind of purchase.

Rec-Tec has a strong following, and – as with the rest of the pellet grills in this review, will do you right. They’ve recently gone to an all black (no more red) look with their newer models. Though, you can probably still get the red. They have the most pellet holding capacity of any other grills pretty much, so that might be a plus for you. Getting temps back down is pretty fast… 5-10 minutes or so. I’d consider reverse searing, so long as your steaks are 1 and 1/2 inches or more. Thinner cuts won’t work. So, basically – you get the steak up to around 125-35 at around 225-250 F. Wrap it in foil. Then, crank your heat up to the highest setting, remove your steak from the foil, and sear it off on both sides to your desired doneness level. This limits the amount of grey – making for a more uniform pink from the top to the bottom of the steak.

Controlling temperature is the best way to get the desired piece of cooked meat. This smoker grill has a built-in thermostatic control and a digital thermometer, so that means you won’t have to do much guesswork during barbecue. If the sensors sense a fall in temperature, more wood pellets are added to the burner, which allows you to place the meat on grill and relax.

The online research, the model comparisons, the pricing—choosing the right pellet grill can be challenging, so much so that, by the time you settle on a grill, choosing smoker pellets often becomes an afterthought. While some people simply default to the wood pellets sold by their pellet grill manufacturer, too many others settle for the cheapest pellets available. Because, really, how much difference can the pellets make? A lot, actually.
This website has a lot of negative reviews... I mixed some salt and pepper, rubbed onto some ribs, and put on the Traeger. After about 5 hours sitting in my a/c living room, looking out the window, at perfectly managed temp, the ribs were done, perfect, juicy, with a beautiful wood smoky flavor that I've never gotten on charcoal or even in restaurants with professional pitmasters and all. I did phone Traeger when I was putting the grill together and doing the 1st burn in, there were humans there (!) and they were knowledgeable and helpful on the 1st time.

JUNK!!!!! Major defects and powder coating coming off and possibly getting my family sick. Very rude customer service telling me to just take it back to Costco! Did I mention I bought the biggest one and will need to disassemble the entire thing to fit it in my explorer! I will be sending the paint chips that came off to a lab to determine what the stuff is and if my family has been exposed to carcinogenic chemicals. A $1,000 for Chinese junk....Stay away for your families sake!!!!!
Hey Shannon – they all have their merits. Budget dictates a lot. If you’re in the $1000 or under range, Green Mountain and Rec Tec are great choices. Both have developed near cult followings, with GMG a little ahead of the curve on that front having been around a bit longer. I love the Yoders as far as moving up on the price range is concerned. Will last you forever and they offer a solid product with great support. MAK grills are just beautifully made. There’s no other way to put it. The “General” models are superbly crafted. Love that MAK offers built in cold smoking as a capability. Am I helping here or just making things worse? Hahaha.
This is obviously no revelations that temperature is the first on my list. When it comes to cooking appliances, temperature is always a key factor. However, it is not the sole reason to be on my list. The thing about temperature you need to look for in a good pellet grill is its ability to control, change and maintain it. Any grill can turn screaming hot, but only the best ones provide you with multiple temperature settings, and are able to maintain it constantly to ensure an even cooking surface where it is not too hot on the left and cold on the right. Many pellets come with special, even patented, temperature features.

If you are looking to produce competition quality barbecue in your own backyard, then look no further than the Pit Boss Deluxe Wood Pellet Grill and Smoker. This grill has the most versatile cooking system ever built. Sauté, Stir fry, Cook breakfast, or Flame broil dinner in just a few minutes. Sears and broil steaks just like your favorite steakhouse. The 820 Series offers two tiers of porcelain-coated grid construction, totaling 820 sq. inches of cooking surface, allowing you to skillfully prepare food with savory natural hardwood flavor. The Fan-forced convection can bake anything that you would normally bake in your oven. A pellet grill is hands-down the best wood-fired pizza oven that is available. Even smoke your holiday turkey!
If you are looking for the perfect spacious grill for home cooking, then this Traeger grill is yours for the taking. This is the most sold and famous model of Traeger grill in the market currently. It uses different kinds of hardwood pellets to smoke, grill, braise, bake, roast and barbecue different flavored dishes. Besides, it has a compact design that saves on storage space. It is built to last with sturdy steel construction with a powder coat finish. Additionally, it has a non-stick surface that makes it easier to clean and maintain the grill grates. Moreover, it is 418 square inches, enough for 16 burgers, 5 racks of ribs and 4 whole chickens.
Regarding getting a good draft, this is a common misconception for pellet grills. The burn pot on pellet grills receives oxygen via a fan unit. As such, there’s no need for a draft to get a measured burn in the traditional sense. Most pellet grills lack sufficient insulation / gaskets, etc to prevent smoke from leaking out of the body. So, unless you’re going with the Memphis or something that uses oven style insulation, you don’t really need a chimney at all IMHO.
It comes with some unique features, such as its proprietary “Sense-mate” technology that uses a thermal sensor to monitor the ambient temperature. If used in a cold weather, this grill fires up the turbo mode so you won’t have to wait for it to heat up before you start using it. It comes with “fan-only” mode to blow off the ash and automatically clean the grill once it has been shut off.
Hi there i want to recommend the CAMP CHEF pellet smokers you get the bang for your buck with these smokers i know a lot of you out there are turning up your noses but these smokers have all the extras at a very good price well under a $1000 customer service second to none you get the pellet clean out in the hopper they have a ash tray under the body you just pull a lever and all your burnt ash is cleaned out digital temp for the food digital temp for the chamber lo smoke and high smoke setting and it goes up to 500 degrees at 25 degree increments mine coast me $359 out the door includes shipping it dose a wonderful job holding the temps with a 10 to 15 degrees swing i bought mine at CAMP SAVER.
Consistency is the key to having the best results. If you want to make a tender brisket, your cooking temperature should be close to 250 F during the entire 12-hour cooking period. The control board is responsible for precision. There are three types of controllers – PID multi-position, non-PID one-touch, and 3-position. Check out the different types of controllers for the one that is right for you.
Editor-in-Chief Sean McCoy is a life-long outdoorsman who grew up hunting and fishing central Wisconsin forests and lakes. He joined GearJunkie after a 10-year stint as a newspaperman in the Caribbean, where he learned sailing and wooden-boat repair. Based in GearJunkie's Denver office, McCoy is an avid trail runner, camper, hunter, angler, mountain biker, skier, and beer tester.
Although these are marketed as grills, they do much more, including baking or roasting. Because they heat by convection, you might not get the grill marks that a gas or charcoal grill will give you, but you also won’t have the flame-up problems. While many pellet grills offer high cooking temperatures, the maximum depends on ambient temperature and wind. Many users wrap their grills in special insulating covers to help maintain heat, reduce fuel use, and reach the higher temperatures they desire.
×