This pellet grill has a 440 square inch cooking surface and weighs 73 pounds. It measures 36 by 18 by 39 inches in dimensions and is made out of durable steel and heavy duty 16 gauge steel construction. It has a dial-in control with an LED read-out. Its temperature reaches from 180 degrees to 500 degrees Fahrenheit. It also comes with a meat probe. This Pit Boss is a worthy name to be in our pellet grill review’ list.
I have several smokers I have used over the years. I have dialed in everyone I own over a course of trial and error. They all get great results, but require me to tend them all throughout the cook. I wanted a smoker that I could easily get to the desired temp, maintain the temp, provide good smoke flavor, and have the size to do a small or large cook, and not need me to be tending it throughout the cook. The learning curve on this smoker is super easy if you know all your temps, your first cook will give you the results your looking for. I was a little worried that I was not going to get the smoke flavor with a pellet smoker, but my brisket turned out amazing, very tender, the smoke ring was perfect. When I was searching for a new smoker I was a little shy of the Yoder based on the price, but when you figure in the ability to grill as well this became a better alternative. The quality is top tier, this is built to last a long time. I'm so glad I went with the Yoder YS640 no regrets.
Add humidity to your grilling environment while also Add humidity to your grilling environment while also adding smoker flavor. This dual smoker/humidifier can accommodate liquids and wood chips or pellets for delicious succulent foods. The even heat of the cast iron heats the liquid in its reservoir creating steam that permeates the food on the grill. The open ... More + Product Details Close
Regarding your question about a decrease in smoke flavor when using the pellet grill / smoker, I do believe you will experience a little bit of a drop off. This said, many people find the flavor from pellet grills / movers to be adequate. If you require a stronger smoke profile, you can always use one of the tube smokers that sits inside of the cooking chamber.
The MAK Pellet Boss will increase or decrease with the press of a button in 5°F increments and has a probe in the oven that keeps the temp pretty solid. As with any thermostatically controlled oven, even your indoor oven, the thermostat cycles heat on or off as needed. So it you set it for 225°F it cycles on til it hits 225°F, then off until it drops to 220°F, then on to 225°F. There are three meat probes and the Boss can be programmed to change the cooker temp when the meat hits a target. I've had one for several years outdoors in the Chicago winters and summers without a cover and no problems.
I don’t know why these cookers are referred to as grills. By definition they are not grills. Grilling involves cooking with direct heat and none of the pellet cookers I’ve seen use direct heat; they all use indirect heat. They are more accurately described as smokers/convection ovens. For me what this means is they’re useless for cooking chicken since I like my chicken cooked with crispy/burned skin. I’ve done some experimenting to get the skin to crisp up but always end up with leather skin. They have their place in outdoor cooking but grilling ain’t it. I just bought a Green Mountain and I’m still debating if I’m going to hang on to it. Shame on me for not doing more thorough research first.
Do not confuse a pellet grill for gas grills. Like the name suggests, a pellet grill obviously uses pellets for cooking its food. But do not doubt its competence with any other gas or convection appliances. It cooks just as well, if not better. And the secret to this are in its pellets. While pellets vary from brand to brand, the best ones have more wood and less binders like sawdust etc.
Camp Chef is the company that perfected the pellet grill formula that Traeger made up, hence its introduction of an effective pellet auger that dispenses pellets only when needed and a large capacity hopper that reduces the need for pellet refills (that people find really annoying). It’s economical in terms of fuel rationing even though the griller itself is quite expensive.
I've been using a pellet grill for a LONG time (Traeger for ~15 years?), so I know an upgrade when I see it. I just picked up a YS640, and it's amazing. I love removing the diffuser, adding the Grill Grates, and doing so nice searing! My first cook was a batch of rid eyes, and they were both beautiful as well as delicious. My "guest list" of people wbo want to come over for food keeps growing... Nice problem to have. Good friends, good food, good times.