Yes, no one likes to read the instruction manual. But there are many advantages of learning the specifics of your grill and reading the manual is key. Generally, you should not use water to clean your pellet smoker, so keep your hose pipe far away. These smokers have digital controllers, a motorized auger, a fan and an igniter rod for the fire pot. These parts will get destroyed if they come into contact with water. You should gently dry scrub the dirt off these parts, making sure not to disassemble any parts. Cleaning the thermostat will also prove to be essential; otherwise, it may read internal temperatures inaccurately.
Hey Oscar, based on what I think and my discussion with my buddy Shane Draper of Draper’s BBQ, you’ll probably only need to run 14 hours for a brisket cook – given the convection nature of your pellet grill. You’ll probably go about 1 lb per hour or a little less – depending on the weather and other variables you mentioned. Again, pellet cooking is a little bit give and take where you’re getting ease and a more set it and forget it cook experience in exchange for some additional fuel use.
Thank you so much for the kind words! I think you would be very happy with a smaller pellet grill / smoker. The wording changes depending on how you are using the device. For instance, if you are cooking at low temperatures you will get a stronger smoke profile then if you burn a pellet smoker / grill at its higher temperature range. One thing you could do for steaks is cook them at the higher range thus being able to get a sear much like you would on a direct heated Grill service, for instance on your Weber. Another option would be to cook the steak in the reverse see your method, by bringing it up to temperature at a lower smoker setting and adding some smoke flavoring that way, then removing it and bringing the smoker up to its higher settings so you can finish off the steak with some of the effect you would achieve on direct flame. I normally do this by bringing the steaks up to about 15 degrees below where I want them to finish. Then, I finish them off at the higher temperature to where they are about 5 degrees below my target. This usually means a few minutes on each side but I use a Thermapen to be sure.
It’s built pretty solidly, which is what you want with a portable system as it’s obviously being moved around a lot more. I’d say it’s similar in build quality to the Traeger Junior Elite, which as a top of the line smoker says all that needs to be said. If something does go wrong, there’s a two year warranty. I’d have liked more, but it’s there, and that’s good enough.
Larger, more expensive smokers run anywhere up to 900 square inches, which will basically let you feed your whole street. It’s also a whole lot more convenient when you’re planning on cooking multiple things to be able to throw every single sausage, joint of meat and rack of ribs on at once, flip ’em around and move things to the edge when they’re done.
Hey Jennifer, I think a pellet grill/smoker would make a great addition to your cooking arsenal. You can get a pellet smoker up to 450 degrees in about 10 or 15 minutes. The following article gives you a good idea of what you might do to reverse sear a nice thick steak using a pellet smoker. note, that this method employs the use of GrillGrates, which you can find easily on Amazon. Here’s the article:http://blog.greenmountaingrills.com/rib-eye-reverse-seared/
The great part about this smoker is that it is fairly light-weight, weighing in at 69 lbs, and its legs double as handles: all you have to do is fold the legs up and carry the smoker wherever you need to! Furthermore, this smoker comes with a 12V connector that you can plug into the cigarette lighter of your car, and a 12-foot alligator clips that you can connect to your car’s battery if necessary. You can take this smoker anywhere!
I bought my second Traeger Grill around Thanksgiving (my last one died after 3 months), spent most of the day assembling it only to find it didn't work. Customer service told me to reset the thermostat, I did and it shut down. I did this routine a few more times with customer service and it kept shutting down, day after day. Traeger reluctantly sent me a replacement grill and promised it would be Fully assembled (I have little use of my left hand and can't work with small parts) Well it showed up unassembled in a bunch of little boxes. Customer service told me 4 times that they would call back with a local Traeger dealer to assemble it. Four promises to have someone come out and not even a phone call. This is the worst customer service from a consumer goods manufacturer I've experienced in years! All BS, all the time! I had the pleasure of returning all the little boxes of parts today to Home Depot for a refund. I wish I had seen all the Traeger reviews 3 months ago when I bought this pile of ... Three months without a working grill because of their cheap Chinese construction. The infomercial looks good, don't do it! Hello WEBER!
****Update 12/2014: So I finally found something negative to report. Today I was cooking 2 pork butts and a brisket and discovered that this grill does not do well with wind on a brisk day (It was 45 degrees here today). When set at 250 degree, the smoker could barely make it up to 190 degrees. I was able to bypass the problem by throwing a cheap moving blanket over the grill (an $8 fix) but I think it's worth noting.
I had an American made Traeger for 6 years and after it rusted out I was looking something built for the long haul. The YS 640 is it. Built like a tank it will hold up for years and the extra steel helps retain the heat. Temperature control is spot on and recoverey after opening the lid is amazing. I thoroughly researched all my options and I could not be happier. I cooked steaks the other night in 40 degree weather and had no issues whatsoever. The grille grates are a must and leave beautiful lines. Before you buy anything else, investigate what the other cookers are made of. There really is no comparison.
Cooking Area – Search for one with a substantial cooking region. Keep in mind that pellet barbecues arrive in an extensive variety of sizes. In this manner, pick a unit that can meet your size necessities in light of its cooking territory. You don’t need to purchase an additional extensive unit in case you’re utilizing the grill for your home. Check for the physical measurements of the item and figure out which one can fit your space and stay aware of your cooking style and lifestyle.
If you live in an area where wood furnaces are used (not like down here in FL where a few heat strips will do the trick), you may also be familiar with pellet furnaces. In short, pellets compressed from sawdust and wood shavings fill a hopper and are then fed into a burn pot using an electric auger system. The auger, which is basically a long screw, delivers pellets to the burn pot based on the speed dictated by the unit’s thermostat.