I have used Bradley, Masterpiece, Green Egg, New Braunfels, Oklahoma Joe, Weber and now Traeger. So there is some experience in these comments. The “set it and forget” it is a misnomer and should not be used with Traeger (or any smoker/grill.) With Pellet Drive before you buy Read up on Er codes. The worst is when the fire pot fills up with pellets because the fire can’t keep up with the auger push and the whole cook is ruined or delayed. You have to pull everything out and basically start over while your expensive prime brisket is trying to be saved in the oven. Doesn’t matter what the weather is or wind conditions. Doesn’t matter if you stare at it and stir the hopper continuously. It will happen. Customer support at first was well you are at fault (didn’t leave the lid open on fireup for exactly 2 to 4 minutes or didn’t vacuum out the firepot between every cook) which is crazy. Finally, after so many calls over the past 6 months they are trying to make it right. Problem is, DO NOT believe the “set it and forget it.” That does not exist with any good cook. I have replaced the controller the fan and now getting a new probe. Do not waste your money. Unless someone out here in BBQ land can give me a recommendation on a product that won’t do this stay away from Pellet Drive?

It has a cooking area of 800 sq. inches and a hopper capacity of 20lbs. While that just would be fine for regular smoking, this product needs some supervision and pellet refilling for longer smoking sessions. It does not have a Wi-Fi enabled control system, though it does come with a digital control system to provide you some ease of control while cooking with this product.


According to Bruce Bjorkman of MAK, his cookers use about 1/2 pound of pellets per hour when set on "Smoke" (about 175°F). At 450°F, the high temp, they burn about 2.3 pounds per hour. This is about the same average as I have experienced on a variety of pellet eaters. The burn rate will vary somewhat depending on the outside air temp, and how much cold meat is loaded in the grill, but cooking load should not have a major impact. Cooking pellets run about $1 per pound depending on the wood flavor, brand, if you get them on sale, and if you have to pay shipping. As a point of comparison, Kingsford briquets list for about $0.75 per pound, but they don't pack the same BTUs because there are fillers. I usually buy 40 pound bags of BBQr's Delight pellets from BigPoppaSmokers.com for $45 and shipping is free to IL. That's $1.13 per pound. That means that if I cook a slab of spareribs for six hours at 225°F I will probably burn about 4 pounds at about $4.50. If I put 8 slabs in there in rib holders, and allocate 1/2 slab per person, my cost for 16 people is about $0.28 each. If I grill a mess of chicken parts at about 325°F for about 1 hour, I will use about 1.5 pounds of pellets for a cost of $1.70.

Use of the P settings in smoke mode is easy to understand. But one can also use them as a dual function feature in cook mode. Remember, in cook mode the auger idles when the temperature is correct, but the P settings continue to function in idle mode. Ortech recommends the P2 setting as the default idle rate in cook mode. However, as one gains experience, the P settings can be used to improve the grills performance. For example, when using high temperature settings, select P1 or P0 to reduce auger off time and maintain strong, steady heat. If you have trouble hitting low temperatures on a sweltering day, increase the P setting to increase auger off time. It does not have a significant effect on smoke production. The basic rule remains: Low heat = more smoke, high heat = less smoke.
The Vulcan is a Picnic Time original design The Vulcan is a Picnic Time original design and the ultimate tailgating cooler and propane barbecue set in one. Don't be fooled by other similar looking items on the market. Only picnic time's Vulcan features a PVC cooler that conveniently nests inside the compartment that houses the portable propane BBQ. ...  More + Product Details Close
Is it customization? I called before I order my YS640 and told them I wanted my grill grates made out of expanded stainless steel, and a few other small things done to ""personalize"" my grill so it was just the way I wanted it. ""No problem. The added materials will cost extra, and shipment will a week so we can fabricate your grates."" Try getting that with a Chinese import!
Thank you all for a great site and an informative discussion. I am a newbie to smoking and presently have a charcoal grill for when I have more time and a gas grill for a fast meal. Its time to replace my gas grill so I am looking at alternative options. Is a pellet grill overkill, or a timely expedition, if I want to grill a couple steaks or chicken breasts during week nights? I’d also be interested in smoking larger hunks of meat (and ribs!) less often, but am wondering if a pellet grill can cover both? How long does it take a pellet grill to get to temp (e.g. 450°)? With the indirect heat, can you get char marks on your meat? Thanks in advance for the info!

Pellet grills come in various sizes from the portable types for tailgating to the extra-large units for commercial use. If you are someone who wants to be able to take your smoker on the go, be it camping, partying or any other event you’ll want something that’s easy to lift and has wheels to facilitate movement. If you have lots of parties and gatherings at home, then you might want something bigger. Its all up to what your needs are.
Typically, most portable grills would give up certain features just to maintain their portability, but this wood pellet grill from Traeger actually had more than what other top grills have to offer. Out of all of our features, it managed to tick 85% off the review. Its digital controls, versatile cooking features, and decent cooking space (perfect for outdoor adventures) all make it our best portable pick.
This is the single main advantage of a pellet smoker. Unlike charcoal, gas or wood fired smokers you don’t need to do anything with fuel except make sure it’s full when you start. This means no more having to go back and check fuel levels, no fluctuating temperatures, no spending ten minutes setting up charcoal and getting it at the right temperature, and no random heat variance giving you oddly cooked food ’cause you set it all up wrong.
While the Traeger Lil-Tex does offer similar features as our top pick, such as a digital LED temperature control system and an auto-dispensing auger, there was one missing feature which we thought was necessary. This product has a smaller grilling area and lacks a removable upper rack, which gives you less grilling and prep space. I should mention that the unit does come in a bigger 700 square inch version for $200 more, as well as a smaller version that costs less. If this smoker is too big or too small for you, there are always other options available. Compared to our top pick, it’s also more expensive despite offering similar specs. Aside from that, this is a very efficient and reliable smoker – might even have been the best if our top pick wasn’t available on the market.
With their portable model, Traeger has their own version of the classic 'tailgater'. Still fairly hefty at a little over 60 pounds, this grill is still far and away the most lightweight model Traeger offers. The legs fold up for ease of storage and transportation. As with all other Traeger products, temperature controls allow grillers to use the Tailgater as either a conventional grill or a smoker.
Kevin, Im about ready to pull the trigger – im pausing for a moment to consider your thoughts as you mentioned Grilla Silverback or Camp Chef. How do these compare to the Rec Tec on quality and price? (as they are less than Rec Tec) And reverse sear…how well does this work on pellet grill, ie how long does it take to go from 200 cooking temp to 500 searing temp (with grill grates)? Thank you for your time

Loved the article and read the entire thing. Thank you so much for taking the time to write such an in-depth piece to help the rest of us out. With that said, I now want one of each!! It’s really so difficult to purchase one without being able to compare the taste side by side for each. We also just bought one of the Traeger’s on the last day of a Costco show. We have LOVED the taste, and aren’t looking back, from a pellet perspective that is. However, we’ve already had a couple of issues that concern me from a longevity and a safety perspective. So we’re going to return it, and ‘upgrade’ to something more substantial. I was leaning pretty hard toward Yoder, and then after reading the article, the Memphis really intrigued me (could have something to do with being born there, and raised on southern pulled pork). And then, Fast Eddy came into the picture. Any advise on how to make a decision without being able to conduct taste comparisons, which is really the most important thing. (We’ve been smoking a brisket and pork shoulders every week, with the occasional steak and veggies. So we’d like something that does both smoking and grilling, so both important, with the smoking component being the feature we’ll use a bit more of.)
Yoder's Variable Displacement Damper is another unique feature: Essentially, it's a metal plate that may be moved from left to right along the lower smoke box. Positioned all the way left, it concentrates heat directly over the fire pot for conductive searing with optional aluminum GrillGrates. Move it back to the right for even heat across the entire smoke box. Yoders are sold primarily through independent retailers.
This little smoker is just right for people who want small capacity and/or need a compact device for their condo patios; and despite its small size (or, perhaps, because of it) it's also one of the best pellet smokers for the money. Many of our readers who already have other outdoor cookers like to add Davy Crockett to their lineup, especially if they have everything but a pellet smoker.
Also own a Big Steel Keg which I love! Didn’t want an egg or a Primo while I was up north WY & CO as I had to many friends complain about cracking when trying to use them in cold weather! Many times at Thanksgiving or Christmas I have cooked on any or all of these devices at -5 to -10. It can be done but with a strong wind it is quite a challenge! My Weber (been thru a couples) and my Keg still have high ratings for great steaks and burgers. But for low and slow you are pushing it to get there and my friends with the ceramic style units say it takes some practice and close attention. What I don’t like about and Egg or my Keg is if you do need to end up feeding the fire on a long cook it is a real serious challenge!
Normally you will get 1- 3 years of warranty for the top pellet smokers from different companies. Traeger will serve you with a 3-year warranty while Camp Chef will give you only 1 year of warranty. Considered this the safe period for your pellet grill, so take advantage. If you own a top quality smoker then you may need not to think of any replacement within 5 years of buying.
I have found that using the upper shelf gets more airflow around the meat than the lower shelf. I asked the AmazingRibs.com science advisor Prof. Greg Blonder about the problem (he has a MAK 1 Star). He explained that smoke sticks to cool surfaces and wet surfaces, and the surface of meat warms and dries out after a few hours. When he wants more smoke flavor he uses a strong smoke wood like hickory or mesquite, he starts with cold meat, and then he keeps the meat moist by painting or misting it with apple juice or a mop like Lexington Dip or East Carolina Mop or Texas Mop Sauce. A awter pan can help because the water condenses on the cool meat and attracts smoke. Read his detailed research on the subject in my article on the Science of Wood and my article on Basting.
just received my new YS-640 two weeks ago and I absolutely love it. The shipping process and delivery was just as described. The delivery guy unloaded it off the truck, and wheeled the pallet into my garage. Everything was perfect. I am very impressed with the build quality...this thing is a tank. So far have smoked ribs and a brisket, and grilled chicken breasts. The grill heats up much faster than I expected. Temperature holds very steady over the long cooks. I love having the built in probe ports. Still figuring out and tweaking the baffle to control different cooking zones. Only negative thing I say is it can be difficult to manouver in tight quarters because it's so heavy and only the small caster wheels turn. So if you need to move your smoker around a lot, consider the comp cart.
I had to cancel my order today. I called this morning, however no one at their office could provide a satisfactory answer or response to my order. I actually was asked to provide a second copy of the invoice pink slip which I had already done so. Very disappointed with your company's sales rep that sold me the smoker at the Timnath Colorado store location. She guaranteed that the grill would be shipped out in three days and I would receive it before Easter, my daughter's birthday weekend for a party.
All of GMG’s like of product lines like the Daniel Boone and Jim Bowie come with similar features. In fact, the Daniel Boone will always be a better alternative to the Davy Crockett. However, the Daniel Boone line isn’t winning any spot in our budget pick due to its higher price tag. With its build and quality, it does become one of our honorable mentions, if not the pick; and the Davy Crockett continues to be the top choice for the grillers on budget.

Product is decent but customer service really didn't help me out when they sent me a wrong accessory part that was ordered by their customer service department. Explained that the representative misunderstood my request for an inside shelf  but I was sent outer shelf which I have already . Tried to be fair and asked them to pay for the return shipping so I could return it back. They said we will gladly return your $ . Well till this day after numerous calls and false promises for the credit return .. there still is no refund. They seem to care but actually they did nothing. It's been 3 months of calling. Sorry to say we are Done with this company. If they can't settle a small concern and have A + service then don't bother! Good thing they are not the only smoker on the market. Shop around folks.

I purchased my unit new this last weekend, and had the privilege of working with the owner directly. Extremely polite and informative gentleman who is straightforward and wants you to buy what you think is best. He was not pushy at all and doesn't need to be. The product sells itself. I have a friend who has a Traeger and I have grilled/smoked with him on several occasions. There is a reason this grill weighs significantly more than the Traeger. If you are truly going to invest this amount of money in a grill, please make sure you are completely happy with your investment by purchasing this Yoder grill.

With 440 square inches of cooking space, an auger-fed pellet delivery system, and a digital LED thermostat and controller, your cooking will be simple, whether it’s burgers, a whole turkey, or racks of ribs. The side shelf is a convenient place for cooking tools or plates while the bottom shelf can hold spare bags of pellets or jugs of sauces out of the way.
×