Our Privacy Promise, Terms of Service, Code of Ethics. AmazingRibs.com promises to never sell or distribute any info about you individually without your express permission, and we promise not to, ahem, pepper you with email or make you eat spam. We are GDPR (the General Data Protection Regulations as passed by the European Union). GDPR requires that we be willing to delete any info we have about an EU resident if you request it. We go a step further. We extend this right to anyone, EU resident or not. For more about our privacy promise, code of ethics, terms of service, and how we operate to insure you unbiased info, click here.

In some ways, it’s surprising that something so small could be the culprit behind so many problems on a hi-tech cooker like a pellet grill. Then again, pellets are your grill’s fuel and using bad pellets is like using subpar charcoal in a kamado, and it can cause the same problems—too much ash is produced, making it hard to hold a steady temperature and snuffing out the oxygen supply to the fire.


One option is to put a griddle or a frying pan on the grill, high heat, get it blistering hot, add just a little oil to prevent stickling, and sear by conduction on the metal. It should only take two to three minutes per side. This is a good technique for reverse seared meats. You start them indirect, low and slow, with a little smoke, and then Maillard the outside in a hot pan or on a griddle. No, it's not cheating. It's making food better.

Pellet cookers usually have an auger or another feed mechanism that pushes the pellets into a burn pot typically about the size of a beer can ripped in half. An igniter rod sits in the bottom of the pot and when you turn on the grill it glows like the element on an electric stove. As the pellets ignite, a fan blows to feed them oxygen, and the igniter shuts off. The Traeger L'il Tex, an inexpensive model, draws 300 watts an hour while the igniter rod is on in the first four minutes, then it drops down to 50 watts an hour for the duration of the cook session, less than a standard light bulb.

Louisiana Grills was one of the first companies to muscle in on Traeger's one-brand show. The smallish CS 450 is one of its more popular models. In 2014, Louisiana upgraded all of its pellet smokers to include digital touch-pad controllers with integrated meat probes. Set it and forget it; the thermostat will maintain cooking temperature just like your indoor kitchen oven does. As a safety feature, the meat probe can be set for your desired target temp. When the internal meat temp rises to within 10°F of the target, the controller automatically drops the smoker down to 170°F (77°C) to avoid overcooking.


Sometimes an inexpensive, less efficient pellet blend might be just fine for burgers or chicken breasts. Other times, you may want to step it up with a premium flavored pellet where whole turkeys, prime rib roasts, or a nice brisket can really shine. No matter what you read in any grouping of pellet grill reviews, know this: pellets are not all made equally. You will wind up with one or two “go to” brands over time that you simply prefer – sometimes for their efficiency (leaving little ash), others for their flavor.
So, I say go for the best pellet grill you can get within your budget. I reviewed the little GMG Davy Crockett pellet grill recently and was impressed. At just under $400, it’s a good option. That said, I would like to see them put the unit on fold down legs with casters or some other option to make it easier to move around. You’ll see what I mean in the post. Hope this helps.
12 Month Financing: For a limited time, purchase $599 or more using the Amazon.com Store Card and pay no interest for 12 months on your entire order if paid in full in 12 months. Interest will be charged to your account from the purchase date if the promotional balance is not paid in full within 12 months. Minimum monthly payments required. Subject to credit approval. Apply now.
Hi Joshua – Rec-Tec makes a solid product. I can’t say a bad thing about them. I think you’d be very happy with the Silverbac. Email Shane Draper – Pitmaster for Grilla Grills at pitmaster@grillagrills.com. He’s super quick with responses and can answer all questions re: Grillas. The Traeger pro series is a solid buy as well. You can check them out at Ace Hardware Stores or via stores acting as dealers for the pro model (find these on the Traeger website). I have the smaller Traeger 22 pro model and have been very happy so far. Regarding controllers, my verdict is still out on whether they’re what you need. It’s almost getting to a point where I “want” some temp swing, especially at the lower settings, in order to get a bit more smoke from the cooker. 15 degrees either way on temp is pretty normal. You might find that this is the case, even when controller units “read” steady. Pellet grills all feed pellets into burn pots in cycles. So some swing is inevitable. Hope this helps.

Wood pellets are small pieces of hardwood made from compressed sawdust from hardwood. Generally, some wood pellets made for room heating and stoves are produced using some form of binding agent like glue and other additives, which would leave a bad taste and flavor when used for cooking. However, for modern-day grilling, wood pellets are made of pure wooden sawdust and sometimes a little bit of vegetable oil to help it burn. So, nowadays, wood pellets are even better than the real wood chips for grilling.


I filed my complaint with American Express. AMEX was absolutely AWESOME......!!! I gave AMEX copies of everything I sent Trager and it's CEO who never answered me. AMEX gave them 30 days to respond and they did not. So the grill was FREE.!!!!!!, and I could care less. Tells you a lot about their CEO and their method of doing business. CEO is Multi-Milllonare living in Salt Lake City and is just playing the numbers!!!!! Hot shot from a HeadPhone company, Skull Candy, who usually gets away with ignoring customers. Clearly don't care about customer satisfaction. Buy another makers grill. Save yourself a lot of headaches. Louisiana Grills are much better quality.
Hey Charlie – I’d leave that grate wide open if you want maximum heat. If the grates are only over the burn pot, then you can do sort of a two zone cook (indirect vs direct heat) by putting a thicker steak, chop, or piece of chicken on the ‘non direct’ side to get up to a temp that’s 15 or 20 degrees lower than your target. Then, finish off over the burn pot area. Just one idea.
The Fast Eddy's by Cookshack PG500 Pellet Smoker is a collaborative design from respected smoker manufacturer Cookshack and competition-barbecue-circuit pro "Fast Eddy" Maurin. The FEC (Fast Eddy's by Cookshack) line has been popular with competitive teams for years. While most FEC models have a utilitarian appearance, the beautifully crafted stainless steel PG500 fits right in with your shiny outdoor kitchen.
This is a nice article for people new to pellet grill/smokers. Like jennifer, we have a vermont cast ing cast iron gas grill that has ‘rotted out’ internally. Calls to vermont cast ings has resulted in ‘we no longer support, make or sell parts for grills made before 2008’ and other run arounds. As a result we are looking for other options. We like the cast iron grills and grill heat but are considering other options, (Webber, Pellet, gas).
The Ortech has two knobs. The large one, the "Cook Control" has settings for: Off, Smoke, 180, 225, 250, 275, 300, 325, 350, 375, and High. One smoker manufacturer says that the "Smoke" setting is about 160°F and "high" is about 525°F, but both can vary due to ambient temperature, humidity, fuel type and quality of the smoker. Another knob, a teensy weensy knob to the right of the LED screen looks more like a push button. Labeled "SMOKE" and called the "Smoke Control Knob", it is meant to turn, not push, and it controls the pellet feed rate with auger on/off sequences indicated by "P settings". The P settings range from P0 to P15.
In reading through the comments section, it seems the recommendations have shifted over time. As it stands today, which smoker would you go with and why: GMG Jim Bowie, Traeger Pro 34, or the RecTec? I like the cooking space of the Traeger Pro 34, but the other 2 seem to have more bells and whistles. I’ve been smoking about 5yrs, so not a pro but not a beginner. Currently have a 10+ year old Traeger Lil Tex elite hand-me down that is ready to give up the ghost. Would appreciate your thoughts!
I purchased my first Traeger Grills over a year and a half ago and now I am on my third grill. I have had the most amazing experience grilling, smoking and baking. I do everything on my Traeger. It accurately holds the temperature, starts up automatically and has convection which cooks my food evenly and thoroughly. I recommend this grill to anybody who’s looking for a amazing cooking experience with little effort and really likes to show off to their friends how good their food tastes. My favorite part is being able to walk away from the grill and not have to babysit it so I can do overnight briskets without even checking them. I love it.
Because the burn pot is small, there is usually a hot spot directly over it. Some units have an optional perforated section above the burn pot so you can put the meat over direct flame, but the ones I've tested still do not sear properly. And there is no way to set up a 2-zone cooking system with a cool zone. As with most other grills and smokers, the differences between lower and upper racks is not huge, so think of it as one heckuva indirect heat convection smoker with precision temperature control.

With the upcoming and already existing new features, you can achieve an easier and much better smoking experience than ever before. Always look for features that can help bring out the real taste of food, and give you more control and convenience. Keep visiting this page because we will always be the first ones to bring you the newest and the best news about the innovations in grills and smokers.


I got my YS640 for a combination Father's Day/ Birthday gift and regardless of whether it's grilling or smoking beef, pork or chicken the results have been outstanding. I can hardly wait to break out the turkeys for the Holiday meals. The direct grilling grates leave a steak with beautiful grill marks and the use of the fruit wood pellets along with quality steaks have made for some incomparable meals. As for quality of the smoker itself, I have sons-in-law that are already jockeying for position to try to be the next to have the YS640 after my demise - - - and we're figuring that won't be for at least 20-30 years! 

Hey Chris, IMHO the Blazing Pellet Smoker looks like a solid unit. There’s a good review of it here. I think between the units I might give them a run. Yoder makes quality stuff, and if made in the USA is important to you, they fit as do the Blazings. All this said, if you’re basically using the pellet smoker like a Cambro, you could opt to save a little money and go with the Rec-Tec. Good customer service and solid following.
Even after reading the reviews and watching the videos I was still not prepared for seeing the 640 when it arrived. What a machine! A tank? Yes it is, it makes other brands look cheap and disposable by comparison. I was nervous paying a little more for a Yoder wondering if it was worth it, it was worth every penny. Have only used it a few times for ribs and chicken which turned out great. The wife said 'How much?!' when I ordered it, now she says we should have got one years ago.

Just like your kitchen oven, a pellet grill must keep a consistent temperature in order to produce great food. To get tender brisket, the temperature needs to stay as close as possible to 250°F for the entire 12-plus hours its cooking. A pellet grill’s ability to do that is largely determined by its control board, which is essentially the brains of the pellet grill. There are different types of controllers, and their precision and consistency varies. Most can hold a consistent temperature in ideal conditions, but not all controllers can maintain a tight temperature in the cold, wind, and rain.


I recently purchased a a Smoke Hollow pellet grill from Sam’s. Seems like quality is good and it was recommended by a friend. Temperature control has issues. I called for customer service a couple of times and they sent a new thermostat. Still can’t get temperature to to hold at setting. Am I missing something? Told to start and let preheat for 10 minutes and then move to desired temperature. Tried setting new thermostat at 190 and let it go for 15 minutes and it was back at 230 when I checked it. Any suggestions?
The Dyna-Glo Compact Charcoal Bullet Smoker boasts versatile The Dyna-Glo Compact Charcoal Bullet Smoker boasts versatile cooking options and thorough heat distribution in a compact space. The removable middle section offers grilling and smoking functionality. This smoker offers a maintenance free cooking experience with a high capacity galvanized steel charcoal and ash chamber. For easy internal access simply ...  More + Product Details Close
So far this smoker is fabulous! There is a learning curve, and this is not a "set it and forget it" smoker. You have to make sure you don't run out of pellets as the smoker will shut down. Tried a pork butt, but I wasn't watching it close enough, so I had to finish it in the oven. Still delicious. Next made some boneless skinless chicken breasts which turned out wonderfully.
The flame broiler uses a digitally controlled burn system. Its Digital Control Center lets you set the temperature ranging from 170F to 600F with ease. The desired temperature is set and maintained through an electric auto-start and fan-forced air mechanism. These, in addition, give that flavorful smoky taste to all of your foods. The auger automatically feeds pellets into the smoker, so you can pretty much let it take care of everything.
Hi Joshua – Rec-Tec makes a solid product. I can’t say a bad thing about them. I think you’d be very happy with the Silverbac. Email Shane Draper – Pitmaster for Grilla Grills at pitmaster@grillagrills.com. He’s super quick with responses and can answer all questions re: Grillas. The Traeger pro series is a solid buy as well. You can check them out at Ace Hardware Stores or via stores acting as dealers for the pro model (find these on the Traeger website). I have the smaller Traeger 22 pro model and have been very happy so far. Regarding controllers, my verdict is still out on whether they’re what you need. It’s almost getting to a point where I “want” some temp swing, especially at the lower settings, in order to get a bit more smoke from the cooker. 15 degrees either way on temp is pretty normal. You might find that this is the case, even when controller units “read” steady. Pellet grills all feed pellets into burn pots in cycles. So some swing is inevitable. Hope this helps.
****Update 12/2014: So I finally found something negative to report. Today I was cooking 2 pork butts and a brisket and discovered that this grill does not do well with wind on a brisk day (It was 45 degrees here today). When set at 250 degree, the smoker could barely make it up to 190 degrees. I was able to bypass the problem by throwing a cheap moving blanket over the grill (an $8 fix) but I think it's worth noting.
Standard shipping via common carrier "Threshold Delivery" is included in the quoted price. "Threshold Delivery" includes placement inside your front door or garage. Delivery can only be made inside the front door on the ground floor of multi-level housing. Carrier will call or email to set up a delivery appointment. Please include a daytime phone number in the shipping information at the time of check out and please monitor your emails for an opportunity to set your delivery appointment. Deliveries are made between the hours of 8 AM to 5 PM, Monday through Friday, and will be scheduled as a 4 hour window. Extraordinary delivery requirements may necessitate an additional fee to the carrier. NOT INCLUDED: Placement in your room of choice, removal of packing materials and assembly are NOT included.
To start using the grill, pour wood pellets into a hopper (pellets are usually are made from compressed sawdust). Press the start button to ignite the pellets, which are fed into the fire box with an auger, where a controlled number of pellets are lit and burned (depending on the temperature setting selected). The auger adjusts the number of pellets entering the fire box to maintain the desired temperature.
-Warranty-(Forgive my soapbox here, folks.) I'd give it 5 stars if Camp Chef would give it a real warranty. One year is pathetic and WAY below the industry standard. Camp Chef, I know you are reading this because you guys are too excited about your great new product to not pay attention to feedback like this. Nut up and stand behind your awesome product. Why would anybody buy a product from an industry newcomer with no track record when you yourself are only willing to stand behind it for 1 lousy year?... Especially when the "industry leader" will guarantee their product for 3 years?!?! You are communicating that you have 1/3rd the amount of trust in your product that Traeger does. That's terrible! You should exceed what they are offering just to make the point in the industry! At a minimum, you should at least match their warranty just so it doesn't become a stumbling block to potential customers. Look, you basically took the lil tex and said "ok boys, so how can we make this better?!?" You did that! You totally knocked it out the park! Why cheap out with the warranty?!? As a customer, it makes me nervous that you know something I don't.
This is the right choice for anyone that likes smokey flavors and cooking slow at home. It is my first experience with a pellet grill and I have read and studied them for a while. I was looking for a outdoor cooking solution that would give me the ability to cook like the pros without the super sized trailer. Finally deciding to go with the Camp Chef I haven't been disappointed. The temperature control is flawless so you can dial down the cooking process. I smoked chicken the other day and the red smoke ring was a 1/2" deep. It works like a convection oven so there are no cool or hot zones, it just keeps the heat even and consistent. I have noticed even if smoke isn't pouring out the wood flavors are present.
Hello Mark! Thanks for commenting here. The Kalamazoo Hybrid Grill looks like a BEAST! If you can swing it, I’d go for it. I truly enjoyed cooking on the Memphis Grill, which is to date the most high end pellet grill I’ve used. It offered a nice blend of professional grade convection with the wood fire taste of the pellets. The Kalamazoo hybrid really does seem to offer one step beyond with the addition of charcoal and wood chunks. I see that Derrick Riches of About.com stands behind the Kalamazoo brand. You’re hard pressed to get a better endorsement of a grilling product than that! Keep me posted at kevin@bbqbeat.com and let me know how your search goes! 🙂
Beef: For ground beef items such as patties and pies, the ideal temperature would be 250 F. If trying to smoke some steak, we’d suggest 225 F. For both these temperatures, the food should be allowed to cook for around 1 hour to 1 and a half, depending on your preferred doneness. Alternately, for steaks, you can reduce the temperature further, increasing the cooking time for more tender but less juicy results.
I spent months checking out Memphis, Fast Eddy, Mak, and Yoder grills. I must say the Yoder is by far the most robust pellet grill of them all. I noticed many reviews with 3 or 4 star ratings for price and I must disagree; fit, finish, build quality, and material robustness of the Yoder was better than the Memphis Pro & Elite...and we all know how expensive the Memphis is.
The Ortech has two knobs. The large one, the "Cook Control" has settings for: Off, Smoke, 180, 225, 250, 275, 300, 325, 350, 375, and High. One smoker manufacturer says that the "Smoke" setting is about 160°F and "high" is about 525°F, but both can vary due to ambient temperature, humidity, fuel type and quality of the smoker. Another knob, a teensy weensy knob to the right of the LED screen looks more like a push button. Labeled "SMOKE" and called the "Smoke Control Knob", it is meant to turn, not push, and it controls the pellet feed rate with auger on/off sequences indicated by "P settings". The P settings range from P0 to P15.
A pellet hopper is what you put your pellets in. The grill will automatically help itself from the hopper and use it to maintain the temperature you want it to. More heat requirement will use more pellet, and less heat will use less. What you need to make sure is that you have a good sized pellet hopper so that your grill can keep using from it and you do not have to keep refilling the hopper too often. There are pellet grills out there that are powerful and gentle enough to be cooking for hours, and sometimes overnight, all thanks to its large pellet hoppers that keep replenishing and refueling the fire all throughout.
Apart from the aforementioned problems, you might face some minor issues like the smoker staying hot for hours in the end even after your cooking is over and it’s turned off? It’s better to check out the backdraft preventing cooling fan for your grill. Although this wouldn’t cause any major issues with your grilling experience, it’s a safety feature that is always worth checking out and fixing.
So Kevin here is where you come in. Been wanting to make getting consistent Q on the table regularly and easily. Been looking at pellet poopers for about 5 years now and decided to take the plunge. Had already done enough looking a few years ago Traeger’s issues had scared me off. Several friends had them and raved but always mentioned problems. I decided from my work I don’t want to be buying someone’s, ‘we know the problems and are fixing them’ if you can find something solid for similar cost. Yoder and FEC were pretty much my finalists. So I was doing my final thoughts and found your article.
This smoker has cooking area measuring 560 sq. inches, large enough to allow you to smoke food for your friends and family. This is also enough to give you the best grilling experience, as we’ve found after reviewing the top products from Camp Chef. It also has a useful rack where you can keep your smoked food hot while your waiting for your whole meal to come together or that one couple who always arrive late for the party.
Cleaning/Maintenance: The grease catcher on this flat top is pretty decent. It is located on the bottom left hand side and all the oil/grease gets caught without anything dripping elsewhere. I usually wipe the grease catcher's orifice down with a paper towel to ensure it does not get clogged up over time. Other flat-top grills have either grease catchers that drip onto the leg of the grill or have them in the back of the flat top which is a little inconvenient getting to. As for cleaning after every use, I use a stainless steel scrapper/chopper to wipe the grill clean after I am done cooking. I scrape everything down into the grease catcher. For saucy foods or foods that might stick to the flat top, I use water when the grill is still hot to scrape it off and send it to the grease catcher. Afterwards, I put a little bit of oil onto the flat top and spread it all over using paper towels to maintain the seasoning before putting the cover on. Total clean-up time and re-seasoning takes roughly 3 minutes.
Looking for a pellet grill to do all sorts of cooking with. I am between a Rec Tec, Camp Chef Woodwind, Gorilla and Yoder. Steaks, burgers, chicken, ribs, brisket, vegetables, etc. All in one. And want to have the option to sear meat, veggies as well. Ive seen so many different reviews my head is spinning. My budget is $700-$1,000 but willing to go up if necessary. I hear some can sear, some take too long to heat up, some dont hold the temp consistently. I am a low maintenance so ease of use important. Does not have to be portable.
The Smokepro comes with many of the extras that define the Camp Chef line of products, such as the easy-to-use ash removal system as well and an interior fan. This model comes with easy-to-use controls and an LED temperature readout so you can monitor internal temperature at all times, even if you're cooking at night. The unit also comes with a convenient meat probe for ensuring that perfect finish.
Once you start paying more than $500, you’re looking at a big boy professional level machine. It’s going to be big enough that you don’t have to worry about having the neighbours over as well as the family. You’re also looking at more expensive sensors and thermostats, so you get a more consistent temperature, which leads to a much better end result, and there’s generally some sort of cleaning assist built in, which makes cleanup and putting it away at night so much easier.
Does anyone know how to set up a pellet grill? Since pellet grills are a bit less common than a regular conventional gas grill, we had to conduct a bit of research and realized that pellet grills are as easy to set up, they just have more components. The components of the grill include a lid, which is designed to cover the contents of the grill as well as keep the heat in. Other than that, the ‘hopper’ is known as the area of the grill where an individual places the wood pellets and the grill drips the pellets onto the fire to keep the heat going.
PG24 by Camp Chef is the best choice for any expert smoker. Its reasonable price and amazing features make it a good prolonged investment. It comes with lots of nifty features that facilitate, smoking, grilling and searing in your backyard. For all these reasons, in our pellet smoker review, we consider this smoker as the top choice for the serious BBQ buffs.
†Advertiser Disclosure: Many of the card offers that appear on this site are from companies from which CreditDonkey receives compensation. This compensation may impact how and where products appear on this site (including, for example, the order in which they appear). CreditDonkey does not include all companies or all offers that may be available in the marketplace.

The Rainier is also hearty as hell. It survived banging around in the bed of my truck for four years. And I didn’t exactly baby it, cramming it into the limited storage space in my truck with paddles, helmets, and all manner of gear. But I never worried that it wouldn’t fire up to cook another meal. Once, one of the stubby rubber legs popped off as I was pulling the Rainier out of my truck. The stove sat crooked for a weekend, but I eventually found the leg and simply screwed it back on.

From grilled beef, salmons to grilled turkeys I love them all. My passion for grilling delicacy gradually built during the time I was living with my parents. My family members especially my mother was a great fan of grilled dishes to and from the love of food. I started preparing smoked food with my mom. This bonding helped me to know more and more about to smoke, grill delicacies and also with smokers. So, in a word you can tell me a BBQ lover.

Whenever pellet grill owners complain about temperature swings or losing their fire mid-cook, the first question we ask is “What pellets are you using?” Many times it’s a cheap, low-quality brand that produces excessive ash, which can interfere with the sensors that help regulate cooking temperatures. In that case, fix is simple: use better pellets that burn cleanly and regularly clean any residual ash from the grill. Often that’s all it takes, and the next time we hear from the customer it’s to order more pellets.
I purchased a Traeger Lil Tex 22 yesterday. I “grilled” a whole chicken. It overshot the temperature by nearly a hundred degrees which wasn’t a bad way to crisp up the bird but I was afraid it was going to melt itself down so I shut it down. I was up by 5 this morning to smoke a pork butt for pulled pork sandwiches. My wife’s family is coming over for dinner tonight and time being a concern I fired up the “smoker”. It snowed 12 inches last night so the next hour I was shoveling my walks. Imagine my surprise when I checked on the Traeger and it had shut itself off . The meat was colt to the touch. I read through the instructions to make sure I started it up correctly and I did. I removed the meat and restarted the smoker. It smoked for awhile then quit. The temperature never got above 140. I called Traeger technical support twice and each rep gave me a different answer as to why it wasn’t working. After 3.5 hours I gave up on the Traeger for a more conventional method. I purchased the Traeger for the the set and walk away feature. It let me down!! It is 34 degrees outside today so I will wait until it warms up to try again. Should it fail me again I will sell it for scrap! So far I am not impressed. My wood smoker takes time but it is reliable.
×