They had the field to themselves for a few years, but the idea was too good to go unimitated, and with the digital age came the electronic controller that allowed Traegers and others to create a system that had a thermostat in the cooking chamber that would tell the fan and auger when to do their thing. Today there are more than a dozen manufacturers making increasingly sophisticated machines.
REC-TEC, also known as Rec Tec, has been in business for more than 7 years. Its pellet grill offers up to 702 square inches of the cooking surface real estate, beating out the Pit Boss and its 700 square inches by (only) about 2 inches of extra space. Its grills can also calibrate themselves in 5° increments and its pellet hopper is capable of holding 40 pounds of pellets (no constant refills required).
Have you reviewed at all the Grilla Silverbac? If so, does it not make your list because it isn’t as good a quality as those you have picked? I mean, when I look online for reviews of those who have bought them I haven’t found anyone disappointed with theirs, but perhaps they haven’t been out as long to have a track record? I’m so confused at this point as to which to buy with PID or no PID (some say smoke does better without one), thickness of metal, etc.
Cleaning/Maintenance: The grease catcher on this flat top is pretty decent. It is located on the bottom left hand side and all the oil/grease gets caught without anything dripping elsewhere. I usually wipe the grease catcher's orifice down with a paper towel to ensure it does not get clogged up over time. Other flat-top grills have either grease catchers that drip onto the leg of the grill or have them in the back of the flat top which is a little inconvenient getting to. As for cleaning after every use, I use a stainless steel scrapper/chopper to wipe the grill clean after I am done cooking. I scrape everything down into the grease catcher. For saucy foods or foods that might stick to the flat top, I use water when the grill is still hot to scrape it off and send it to the grease catcher. Afterwards, I put a little bit of oil onto the flat top and spread it all over using paper towels to maintain the seasoning before putting the cover on. Total clean-up time and re-seasoning takes roughly 3 minutes.
REC TEC Grills was born in Augusta, Georgia in 2009 by lifelong friends Ray Carnes and Ron Cundy. The pair made it their commitment to build high quality grills and sell them at reasonable prices. But that was only the beginning of their story. The rest of the promise was to treat everyone like family and provide them with world-class customer service. With those two fundamentals in place, the REC TEC Family was born and the REC TEC Lifestyle started to flourish. Your feedback as members of the REC TEC Family and your living the REC TEC Lifestyle has helped this family grow and become that special bond that binds us all together. Thank you to all of our current and future REC TEC Family members. It just would not be the same without you all.
This smoker comes with two cooking settings: hot and fast, and low and slow. Its Digital Elite Controller makes setting the temperature a breeze — all you have to do is turn the dial to your desired temperature, and you can leave it for the rest of the cooking process. This smoker can reach the temperature of up to 450 degrees Fahrenheit. The digital display on top of the grill lets you monitor the heat conveniently.
Regardless, it’s worth mentioning the basic types of pellets available on the market to get you started. First there are the hardwood pellets, made from the sawdust from any specific type of hardwood, such as ash, cherry, maple, etc. Then there are different organic hardwood blends: a combination of different types of wood shavings and dust, giving them a customized, special flavoring. For beginners, we’d suggest getting a premium blend, just to be on the safe side (because you can’t go wrong with these). Even then, we’d like to mention a few types of pellets commonly used for different purposes:
The Elite's digital control panel is a sophisticated touch-pad PID controller that holds set temps with more accuracy than most kitchen ovens. It's simple to operate and offers an integrated meat probe and some useful programming options. For example, you can set it to cook your brisket up to 200°F (93°C) and then drop to a lower cooking temp to keep it warm without overcooking.
There’s so much about this grill to love, but one aspect that gets RAVE reviews is the customer service. Rec Tec has pretty much the best customer service in the industry. First off, there’s a 6 year warranty, meaning, they expect their product to perform. But in the unlikely case that you have issues, their customer service is incredibly fast to respond, is available even on the weekends, and believe it or not, the owners even provide their cell phone numbers so they can help you through a problem when you’re stuck. Incredible!
Kevin- I’m in the process of researching to get my husband a grill for Christmas. I’m torn between the 820 you mentioned above and the Traeger Pro Series. As far as I can tell they are basically the same except that you get a larger cooking area on the pit boss for the same price you pay for a small cook space in a traeger. I would like to spend around $600 on the grill but would possibly go up to $800 and want 500 sq in cook space or greater. Which do you prefer? Pit Boss, Traeger or another brand?
There are several types of grills and these are charcoal, gas, wood, electric smokers, open fire grill, and pellet grill. Each of them offers different benefits. In terms of comparison, pellet grill is still superior because it is the combination of all such grills. You can use it to smoke that way charcoal grill does. You enjoy the wood flavor of wood grill using pellets, and it is also electrically and electronically-operated.
Cleaning and Maintenance: Any individual who’s taken a stab at cleaning a pellet grill before sees exactly that it is so hard to get all the ash out after use. This unit gives you a less demanding access to the burn pot. It also includes a trap door which permits you to clean the unit without digging through the ashes and oil. Cleaning the unit is by and large significantly less demanding when compared with the normal charcoal grills.
My husband used my two cast iron dutch ovens to make corned beef, but neglected to wash out the pots afterward. Needless to say, when I discovered the ruination of the years of seasoning destroyed by the salt brine, I wanted to cry. This product is so much better than using vegetable oil or shortening as I have done in the past. It seals the surfaces well and does not leave a sticky residue. Hope it gets back to at least an approximation of the old coating. Only time will tell.
If you’re gonna set it and leave it to do the magic, you’re going to have to be careful, too. A major contributor to how long you can leave a smoker is how many wood pellets the pellet hopper holds. Pellet smokers run the gamut in how much fuel they use per hour, with anywhere from half a pound to two pounds of pellets being standard. Always check how much the model you’re looking at holds, and make sure that it’s going to last long enough, especially if you plan on leaving your smoker to cook whilst you do other things, especially if you’re going away from home. It’s simple math, and better that than coming home to a bunch of chargrilled ashes.
Kevin- super helpful article. Thanks! I just moved from a big city small apartment with no grill to a house in the country. Most essential purchase is the grill. I’m really on the fence. I like the idea of a pellet grill, but in reality- I’m mostly cooking burgers, fish, steaks, scallops, and veggies. The brisket and ribs will be more of a special occasion. From an economical perspective, am I better buying a gas grill and just getting one of those smoke tubes to add some flavor? From many of the online comments, it seems like the pellet grills benefit from additional smoke anyway, and though you can get additional grates for searing, seems like a square peg in a round hole. The gas grill is sort of the tried and true, and way more economical. Those $500 entry level pellet grills seem a little scrawny, and the next level up is a cool $grand. I’m really on the fence, and getting pressure to “just buy the darn thing” to consummate the move to the country! However the pellet grills seem like the new shiny object and have my curiosity. Any advice? PS- love the website! Thanks, Cary
This unit will not let even a single pellet go to waste. No need of worrying whether you’re out of pellets or not. You can carry pellets at a maximum of 20 pounds, with the digital thermostat ensuring the pellets are being used properly. This saves you loads of cash and gives you smoking food simultaneously without wasting time in refilling pellets.
Even and fast cooking – this is the common feedback of the new and past users of this pellet grill cooker. Although some of them would say that the temperature is inaccurate, they can still manage to adjust everything well by means of its digital temperature controller. Additionally, you may need to add more pellets if you will set the temperature on a high setting.
Well built and compact, this smoker and grill still has a 300 square inch cooking space, and is generally big enough to fit a small turkey inside, so it’s ample for six to eight people. It’s really easy to use, with an automated electric start, front mounted thermometer and idiot proof digital controls that make this so simple, an absolute beginner could walk up to it, have a quick play around and start cooking.
When you’re buying a pellet smoker vs a wood smoker, what you’re buying is convenience and simplicity of use. Whilst electric smokers are arguably more convenient than pellet based smokers because they start quicker, only need a power point and a handful of wood chips, pellet smokers are still incredibly easy to use and far more convenient than wood smokers.
My budget range is $1200-$1500. The same as the cost of the XL Primo or BGE. I’ve looked at the Rec-Tec. They look like a great deal. I did notice that they were made in china. Also read they assemble them in Ga. I have concerns with the durability of the lower priced ones. I looked at the Fast Eddie PS 500 also. Now that one is cool. Those are the two I have looked at. The Yoders are getting above what I want to spend.
The first thing to consider before purchasing a pellet smoker is your budget. This will allow you to buy the best pellet smoker for the money. If you are a beginner, you do not need to get an expensive unit in order to produce results. However, if you have some experience and you want to take your smoking to the next level, you may look into a more expensive model with the goal of getting some of the features you want.
One comment I see a lot in various forums like Pellet Heads Forum is that you want as much efficiency as you can get. As with lump charcoal, this means burning as clean of a cook as you can with as little ash as possible. Different pellet mixes will produce differences in what you get in this area, and the cooker you’re using will dictate this to some degree as well.