The monster of the Traeger Pellet Grill line, the XL boasts 850 square inches of cooking space, which is big enough for a small whole hog or 16 racks of ribs. At around $2,000USD, this is Traeger's largest and most expensive pellet grill. The pellet hopper holds more than 42 pounds of pellets in front of the cooker, under what serves as a work space. This is big enough for catering or competing, but ultimately it is still a Traeger which means a little less than ideal quality.
Pit Boss have made this heavy duty beast as a semi-professional pellet based smoker, and it shows. It’s absolutely massive, with a colossal amount of cooking space and a lot of tech that makes using it a serious pleasure. It’s actually probably too big for most households, but if you need the most cooking space possible, this is the biggest on our list.
I have used Bradley, Masterpiece, Green Egg, New Braunfels, Oklahoma Joe, Weber and now Traeger. So there is some experience in these comments. The “set it and forget” it is a misnomer and should not be used with Traeger (or any smoker/grill.) With Pellet Drive before you buy Read up on Er codes. The worst is when the fire pot fills up with pellets because the fire can’t keep up with the auger push and the whole cook is ruined or delayed. You have to pull everything out and basically start over while your expensive prime brisket is trying to be saved in the oven. Doesn’t matter what the weather is or wind conditions. Doesn’t matter if you stare at it and stir the hopper continuously. It will happen. Customer support at first was well you are at fault (didn’t leave the lid open on fireup for exactly 2 to 4 minutes or didn’t vacuum out the firepot between every cook) which is crazy. Finally, after so many calls over the past 6 months they are trying to make it right. Problem is, DO NOT believe the “set it and forget it.” That does not exist with any good cook. I have replaced the controller the fan and now getting a new probe. Do not waste your money. Unless someone out here in BBQ land can give me a recommendation on a product that won’t do this stay away from Pellet Drive?
It comes with some unique features, such as its proprietary “Sense-mate” technology that uses a thermal sensor to monitor the ambient temperature. If used in a cold weather, this grill fires up the turbo mode so you won’t have to wait for it to heat up before you start using it. It comes with “fan-only” mode to blow off the ash and automatically clean the grill once it has been shut off.
As both a fuel source and flavor enhancer, wood pellets can affect everything from how well your pellet grill performs to how good the food tastes. And while one might assume that because all wood pellets look alike that they’re all the same, which pellets you use can make a big difference. These 6 tips will help you choose quality smoker pellets that will keep your pellet grill performing its best and producing great wood-fire flavor.
I don’t know how many meals I cooked on that thing, but it’s been enough to make me a hero and de facto camp chef among my friends. I seared up a tri tip large enough to feed four hungry kayaking buddies at the Salmon River Festival one year, then covered it with foil and cooked it on indirect heat for one of the best steaks of my life, which we happily consumed in the middle of nowhere. The grill also perfectly charred onions and peppers to deliver a mountain of chicken and beef fajitas to a crowd of ten. I still get compliments on that one. 
I don’t know why these cookers are referred to as grills. By definition they are not grills. Grilling involves cooking with direct heat and none of the pellet cookers I’ve seen use direct heat; they all use indirect heat. They are more accurately described as smokers/convection ovens. For me what this means is they’re useless for cooking chicken since I like my chicken cooked with crispy/burned skin. I’ve done some experimenting to get the skin to crisp up but always end up with leather skin. They have their place in outdoor cooking but grilling ain’t it. I just bought a Green Mountain and I’m still debating if I’m going to hang on to it. Shame on me for not doing more thorough research first.

The Tailgater 20 Series Freestanding Grill is one of the best wood pellet grills from Traeger for those who like to cook away from home. It’s small and lightweight enough that you can load it in your car for tailgating before the big game, cooking while camping or grilling at the park. The ash bucket collects all ash created, which makes cleaning up before heading home easier.
Kevin: I have a gas smoker but would like a wood pellet smoker. I’m looking at Traeger Lil Tex (due to price) but I read about Blazn Grill Works, Grand Slam, made in USA, stainless steel grates and a control unit that is very good. Cost about $1195, can’t find dealers so called and talked with the owner. What I read on web site sounds good. He claims on his short video that his auger is the best and doesn’t put torque on the drive due to the design. Any thoughts on this unit? Any advice would be appreciated. Still looking at the Yoder YS640 as price is very similar.
With their portable model, Traeger has their own version of the classic 'tailgater'. Still fairly hefty at a little over 60 pounds, this grill is still far and away the most lightweight model Traeger offers. The legs fold up for ease of storage and transportation. As with all other Traeger products, temperature controls allow grillers to use the Tailgater as either a conventional grill or a smoker.
Hey Charlie – I’d leave that grate wide open if you want maximum heat. If the grates are only over the burn pot, then you can do sort of a two zone cook (indirect vs direct heat) by putting a thicker steak, chop, or piece of chicken on the ‘non direct’ side to get up to a temp that’s 15 or 20 degrees lower than your target. Then, finish off over the burn pot area. Just one idea.
Cleaning up after grilling is every cook’s dreaded part of the process, but this pellet grill simplifies that. Its warming rack comes with a patented ash-catcher system, the Ash Can Cleanout System, that allows for an easier cleanup of the unit. Additionally, it also features a grease drip disposal system that comes with a bucket. You won’t have to waste precious time cleaning up afterward!
Also own a Big Steel Keg which I love! Didn’t want an egg or a Primo while I was up north WY & CO as I had to many friends complain about cracking when trying to use them in cold weather! Many times at Thanksgiving or Christmas I have cooked on any or all of these devices at -5 to -10. It can be done but with a strong wind it is quite a challenge! My Weber (been thru a couples) and my Keg still have high ratings for great steaks and burgers. But for low and slow you are pushing it to get there and my friends with the ceramic style units say it takes some practice and close attention. What I don’t like about and Egg or my Keg is if you do need to end up feeding the fire on a long cook it is a real serious challenge!
You need some temperature control in your grilling system: Even though most propane and charcoal grills include a temperature gauge, they’re not precise. Because the pellet Traeger grill works more like an oven, cooking at a precise temperature setting is a lot easier to do. It’s not quite as precise as the oven in your kitchen, but the Traeger system’s temperature control is surprisingly accurate most of the time. Some manufacturers of low cost pellet grills only offer low, medium, or high temperature settings.
I only just learned about “wood pellets” recently when my husband and I were researching ways to heat the small mountain cabin we just moved into a few months ago, and I had no idea there were so many options for pellet grills. Wow! I hadn’t even know these existed to consider them, and now your reviews have me wanting to try one out. You’ve offered amazingly detailed and positive information on each model listed to help buyers make an informed decision. Your writing style is so fun and upbeat, I can only imagine that your backyard and backyard gatherings rock! Thanks for giving me food for thought on our next grill, Nate. (And for making me hungry, too! lol)
Many other features, like its automatic control and built-in meat probe have made us select this smoker as the top one in our pellet smoker review. And the most amazing fact is the price. In the price range (see the price here), we never thought that we could get all these features and benefits. We took all the top smokers into considerations like the Rec Tec smokers, but this PG24 by Camp Chef can beat all through its performance and affordability.

Although these are marketed as grills, they do much more, including baking or roasting. Because they heat by convection, you might not get the grill marks that a gas or charcoal grill will give you, but you also won’t have the flame-up problems. While many pellet grills offer high cooking temperatures, the maximum depends on ambient temperature and wind. Many users wrap their grills in special insulating covers to help maintain heat, reduce fuel use, and reach the higher temperatures they desire.
×