Great reviews. I have been lately looking into pellet poopers. I currently own a large Big Green Egg and a Pit Barrel Grill. My Egg has limited space. On the PBC (Pit Barrel Cooker) I can cook a ton of food as it uses hanging meat method. But it has zero temperature control on it. A set lower vent and that’s it. You have to adjust the lid to get the temps up. I have adjustable rings for my Egg that allows for increased capacity. Eggs are great smokers, grills and ovens. I do have a FireBoss temp controller for the Egg which will allow a set it and forget operations. Wifi controls also. With that being said, I am looking for increased capacity in my cooks. I was seriously considering a XL Primo Oval or a XL BGE. Then I found these pellet poopers. After reading this blog and other reviews I found some limitations. One the lack of smoke flavor. Now with my Egg I add chunks of wood into the lump for smoke flavor. Same with the PBC. The PBC has different smoke flavor as the fats and juices from the meat drip on the hot coals which ignite (according to PBC’s website) and produce a smokey flavor in the meat. I’ve read two ways to increase the smoke flavor in Pellet Poopers. One is to start at a lower temp for a few hours, then crank it up to cooking temps. Two is the smoke tubes or Mojo Bricks. My question is do these techniques work? One review on the smoking tube said that they really didn’t make that much of a difference. Another issue was for grilling and the lack of direct heat. Grill Grates would eliminate this concern correct? My understanding of Grill Grates is that they provide a way to direct grill in an indirect environment. That’s a limitation with both of my cookers. The Egg can Indirect or Direct grill. Not both. Yes I can remove the indirect piece and set up the Egg for direct grilling, but you risk burnt fingers even with welders mitts on. Wouldn’t the Grill Grates on a Pellet Pooper solve this problem? Allowing you to slow cook that steak to say 10 degrees shy of your temp range then sear it on the grill grate for the a couple of minutes on each side to get it to your desired temp range? Or go the other way, sear first for a few minutes per side then indirect cook it to the desired temp?

Thankfully the popularity of pellet grills spurred many new pellet fuel manufacturing companies to enter the industry.  There are also some very big names in the grilling world that have seen the light and are now producing pellets as well.   This has helped the availability of pellets for sure, but we are still not to a point where pellets are commonplace in stores in all areas.
Final Verdict: If you have the capability to cook on this full-time, then I recommend doing so. You will save your kitchen and house from excess grease and smell. It can cook most items relatively fast and easy once you get accustomed to cooking on a flat top. The only thing it can't do is cook sauces or bake items. I even recommend it to folks who don't eat typical greasy foods. This requires very little oil and can use all sorts of cooking oil. All of my food dishes have been cooked well and I constantly have people asking about this flat top. Clean up is a breeze and will save you from needing to clean skillets and pans. This is an essential cookware that every household should have.
The single biggest advantage though, especially for beginning outdoor chefs, is that when you’re paying this much, damn near everything is automatic. As an example, if we look at our number one choice, the Camp Chef PG64 pellet smoker, literally everything can be controlled by the built in systems, so I could grab a friend who’d never cooked anything more complicated than boxed mac and cheese over, give em a five minute masterclass and be confident that the automatic systems would do most of the heavy lifting when it came to getting everything right.
However, it does not mean that you stop grilling with wood pellets. You can minimize this risk by avoiding flare-ups and over-charring the meat. If the meat over-burns then it does not only spoil the taste but is a risk to your health. Moreover, the flavored wood pellet smoke is also a risk, even though it can enhance the taste of the food. This is because it contains carcinogenic elements that are unhealthy for you. One such element is the polyaromatic hydrocarbons or PAHs. Besides, you can find this element is most processed food products but its concentration is high in wood smoke.
Speaking of competition cooks, you’ll find that many competition BBQ pitmasters who use Pellet grills as their primary means of cooking are among the more well rested come Saturday. The next step we’ll cover in this selection of Pellet Grill Reviews is getting your pellet grill / smoker up and running. Again, what you may not see in may Pellet Grill Reviews is repeated mention that you’re not going to get that “deep smoke” flavor profile using a pellet smoker. Though, this can be achieved by using something like the Amazen Pellet Tube Smoker 12″.
Keep your Pellet Grill and Smoker fired up Keep your Pellet Grill and Smoker fired up with Camp Chef’s Premium Hardwood Pellets. Made of 100% natural hardwood these food grade pellets are an excellent way to add that unique smoky flavor. Choose from 4 distinct flavors. Smokehouse Hickory impart a rich and smoky bacon-like flavor to all meats ...  More + Product Details Close
×