BBQ pellets are 100% natural hardwood, but that doesn’t necessarily mean the pellets are 100% of the type of wood listed on the bag. When you buy cherry wood chips or chunks, that wood is 100% cherry wood. However, when you buy cherry wood pellets, they’re usually a blend of cherry and another wood, such as oak or alder. While that may sound deceptive, there are good reasons for this practice.
I called Treager the next day just to find out what happened.  The customer service guy way REALLY nice.  He said, "Don't worry.  We stand behind our product 100%."   Wow was I impressed!   He told me he would email me instructions on how to make a claim.   He even told me he would send me a new thermometer ( my Christmas present one was destroyed by the fire).   He did everything as promised!
According to Bruce Bjorkman of MAK, his cookers use about 1/2 pound of pellets per hour when set on "Smoke" (about 175°F). At 450°F, the high temp, they burn about 2.3 pounds per hour. This is about the same average as I have experienced on a variety of pellet eaters. The burn rate will vary somewhat depending on the outside air temp, and how much cold meat is loaded in the grill, but cooking load should not have a major impact. Cooking pellets run about $1 per pound depending on the wood flavor, brand, if you get them on sale, and if you have to pay shipping. As a point of comparison, Kingsford briquets list for about $0.75 per pound, but they don't pack the same BTUs because there are fillers. I usually buy 40 pound bags of BBQr's Delight pellets from BigPoppaSmokers.com for $45 and shipping is free to IL. That's $1.13 per pound. That means that if I cook a slab of spareribs for six hours at 225°F I will probably burn about 4 pounds at about $4.50. If I put 8 slabs in there in rib holders, and allocate 1/2 slab per person, my cost for 16 people is about $0.28 each. If I grill a mess of chicken parts at about 325°F for about 1 hour, I will use about 1.5 pounds of pellets for a cost of $1.70.
In smoke mode the controller is no longer controlled by the thermometer, it merely switches the pellet feeding auger on and off. On time is 15 seconds, off time ranges from 45 seconds at P0, to 165 seconds at P15. Temp and smoke are controlled by the duration of off time: the auger always runs at the same speed. More smoke is produced at higher P settings and lower temp settings because longer off times allow the pellets to smolder. At P0 in smoke mode or "High" in cook mode the auger replenishes the pellets at a faster rate, creating more flame, less smoke.
First off, in general I was a huge Traeger fan due to my brother-in-law smoking up meat and fish for us for the past 3 years and it was just damn delicious. He also just raved about his Traeger, so finally I took the plunge and purchased a Century 34 model during one their Costco road shows. Customer Service - In general I will give them 4 stars because I am talking with a human, they were seemingly very thorough when I spoke with them and didn't appear to be reading from a knowledge base article when I described the problems. I also grilled them to ensure that the Costco specific model wasn't being manufactured with subpar parts since the price was so much less than retail and seemingly more bells and whistles. More than one representative confirmed that was not the case. This is where it stops being good news.
PG24 by Camp Chef has a weight of 124 lb with a pellet hopper that has 20-pound capacity. That’s so large, you won’t need to worry of getting more before your meal is done. This approach allows you to have the ultimate cooking experience. When the temperature drops, one wood pellet is released. This convenience can’t be found in other grill types, like gas or charcoal.
The Camp Chef SmokePro’s automatic features definitely set it apart and make it truly a “set it and forget it” kind of unit. It makes use of an electric auto-igniter system that lets you start grilling with just one button. The automatic auger instantly dispenses pellets to maintain the desired temperature and use your pellets the most efficient way.
Bring the savory simplicity of the SmokePro XT Pellet Grill to your back patio and change the way you cook outdoors. Just like your kitchen oven, the SmokePro XT automatically maintains whatever temperature you set, so you don't have to worry about over or under-cooking your meal. The SmokePro XT Pellet Grill comes standard with Smart Smoke Technology to evenly distribute wood-fired flavor into every bite. Skip the tedious cleaning routine associated with traditional pellet grills thanks to the Simple Ash-Cleanout System. Simply dump the ash after every cook and save yourself hours of cleaning and enjoy better flavor on your next meatsterpiece as a result. The SmokePro XT can tackle anything from fatty pork butts to quick and easy burgers. Shop the Camp Chef SmokePro XT today and see for yourself why Camp Chef is the way to cook outdoors.
I purchased a Traeger Elite Grill from the website. I use the grill one time and it worked fine. A couple of weeks later we fired up the grill to cook some steaks. Approximately 10 minutes into cooking the auger stopped working. We had to finish our meal cooking it on the stove. I looked at the troubleshooting guide and the steps needed to be taken. To determine what was wrong you basically needed to dismantle the electric box and auger housing. I am not an electrician Nor a mechanic and feel this is excessive for a consumer to have to do.

This presumably has the most exact temperature perusing of any grill right now available. Accompanying a cookbook, a simple get together, and a decent outline, the PG24 is definitely justified even despite the cash. I enjoyed the decision of a wood screw framework rather than a suction framework, since it spares cash on pellets, and manages temperature better. For those needing to get into pellet grilling, this would be an astounding decision.
The cooking process is made a lot more convenient with this smoker. To start cooking, all you need to do is flip the Traeger on/off switch, and you’re good to go. Then, you can simply set your desired temperature through the digital controls. Enjoy your time and relax while you leave the unit to do everything else. With its efficient temperature control system and automated auger with an induction fan, heat remains constant throughout the cooking process. You’ll have evenly-cooked foods that have that mouth-watering smoky flavor in no time.
Let's just say I really love to cook! Especially BBQ. I've had the YS640 a couple months now and can't say enough great things about it! I've grilled ,smoked and high temp roasted with excellent results! After week's of comparing and watching videos I know I made the right decision. There's just no comparison to the Chinese makes and the over priced stainless steel models. I considered the MAK smokers but at double the price couldn't justify it. For the price and USA build quality there isn't anything that can touch the Yoder!
Wood pellets are small pieces of hardwood made from compressed sawdust from hardwood. Generally, some wood pellets made for room heating and stoves are produced using some form of binding agent like glue and other additives, which would leave a bad taste and flavor when used for cooking. However, for modern-day grilling, wood pellets are made of pure wooden sawdust and sometimes a little bit of vegetable oil to help it burn. So, nowadays, wood pellets are even better than the real wood chips for grilling.
Hey David, Is there a particular reason why the Grilla grills interest you? I tend to find they’re great smokers, just expensive for what they are. If you’re working with limited space (say smoking on a condo balcony) then the Grilla models vertical footprint can make all the difference between having a smoker or not. But for the price, and for a standard model smoker, the Traeger models tend to be better all around.
"The Camp Chef transaction aligns with Vista Outdoor's strategy to deliver long-term value through acquiring complementary, market-leading brands that will benefit from Vista Outdoor's balance sheet, distribution network, and sales and marketing expertise," said Chairman and Chief Executive Officer Mark DeYoung. "Led by an entrepreneurial management team, Camp Chef has a nimble and responsive product development process. Camp Chef continues to grow its market share in the outdoor cooking category, and the brand serves many of our current consumers who are engaged in a wide variety of outdoor pursuits. Acquiring Camp Chef strengthens our leadership position in outdoor recreation, allows us to enter the growing camping and outdoor cooking market, and the brand's effective multi-product, multi-channel strategy increases our presence across both brick-and-mortar and ecommerce distribution platforms."
I only just learned about “wood pellets” recently when my husband and I were researching ways to heat the small mountain cabin we just moved into a few months ago, and I had no idea there were so many options for pellet grills. Wow! I hadn’t even know these existed to consider them, and now your reviews have me wanting to try one out. You’ve offered amazingly detailed and positive information on each model listed to help buyers make an informed decision. Your writing style is so fun and upbeat, I can only imagine that your backyard and backyard gatherings rock! Thanks for giving me food for thought on our next grill, Nate. (And for making me hungry, too! lol)
Certain statements in this press release, including statements regarding the expected future financial performance of Camp Chef and the impact of that performance on Vista Outdoor, constitute forward-looking statements as defined in the Private Securities Litigation Reform Act of 1995. The words 'believe', 'expect', 'anticipate', 'intend', 'aim', 'should' and similar expressions are intended to identify such forward-looking statements. All such forward-looking statements involve estimates and assumptions and are subject to a number of risks and uncertainties, many of which are beyond Vista Outdoor's control, which could cause actual results to differ materially from the expectations described in the forward-looking statements. Among those risks and uncertainties are: assumptions regarding demand for Camp Chef's products; the risk that the anticipated benefits and cost savings from the transaction may not be fully realized or may take longer than expected to realize; the ability of Vista Outdoor to retain and hire key personnel and maintain relationships with customers, suppliers and other business partners of Camp Chef; costs or difficulties related to the integration of the business following completion of the transaction; and changes in the business, industry or economic conditions or competitive environment. Vista Outdoor undertakes no obligation to update any forward-looking statements. For further information on factors that could impact Vista Outdoor, and the statements contained herein, please refer to Vista Outdoor's most recent Annual Report on Form 10-K and any subsequent quarterly reports on Form 10-Q and current reports on Form 8-K filed with the U.S. Securities and Exchange Commission.
The Pit Boss Company manufactures an extra-large pellet grill with 700 square inches of cooking surface. It closest competitor in pellet smoker largeness is the 7-year veteran known as Rec-Tec. It has probably one of the largest cooking surfaces (or the largest at that) in the pellet grill and smoker industry. It approaches grilling with the idea that sometimes bigger really is better, at least in terms of cooking more meats at the same time.
The great part about this smoker is that it is fairly light-weight, weighing in at 69 lbs, and its legs double as handles: all you have to do is fold the legs up and carry the smoker wherever you need to! Furthermore, this smoker comes with a 12V connector that you can plug into the cigarette lighter of your car, and a 12-foot alligator clips that you can connect to your car’s battery if necessary. You can take this smoker anywhere!
JUNK!!!!! Major defects and powder coating coming off and possibly getting my family sick. Very rude customer service telling me to just take it back to Costco! Did I mention I bought the biggest one and will need to disassemble the entire thing to fit it in my explorer! I will be sending the paint chips that came off to a lab to determine what the stuff is and if my family has been exposed to carcinogenic chemicals. A $1,000 for Chinese junk....Stay away for your families sake!!!!!
I bought my second Traeger Grill around Thanksgiving (my last one died after 3 months), spent most of the day assembling it only to find it didn't work. Customer service told me to reset the thermostat, I did and it shut down. I did this routine a few more times with customer service and it kept shutting down, day after day. Traeger reluctantly sent me a replacement grill and promised it would be Fully assembled (I have little use of my left hand and can't work with small parts) Well it showed up unassembled in a bunch of little boxes. Customer service told me 4 times that they would call back with a local Traeger dealer to assemble it. Four promises to have someone come out and not even a phone call. This is the worst customer service from a consumer goods manufacturer I've experienced in years! All BS, all the time! I had the pleasure of returning all the little boxes of parts today to Home Depot for a refund. I wish I had seen all the Traeger reviews 3 months ago when I bought this pile of ... Three months without a working grill because of their cheap Chinese construction. The infomercial looks good, don't do it! Hello WEBER!
One of the most common problems people encounter with pellet grills is abnormal temperature fluctuations—the controller is set to 250°F, but the grill is dropping to 200°F then climbing to 325°F. Usually people assume that it's a mechanical issue and either the controller or RTD probe need to be replaced. However, very often the problem is far simpler and the solution far easier.

This is a nice article for people new to pellet grill/smokers. Like jennifer, we have a vermont cast ing cast iron gas grill that has ‘rotted out’ internally. Calls to vermont cast ings has resulted in ‘we no longer support, make or sell parts for grills made before 2008’ and other run arounds. As a result we are looking for other options. We like the cast iron grills and grill heat but are considering other options, (Webber, Pellet, gas).
My wife and I were one of the first buyers of the YS640 in 2010. We had owned a couple of gas grills that, of course, eventually rust out. My wife saw the YS640 at the Kansas State Fair and called me and said that I HAD to look at this smoker! At first, the smoker had many problems--inaccurate temps, huge swings in temps, etc. Don and Joe kept working on the problems and installing updates--never charging us for updates or service calls. Finally, in about March of 2011, they installed the update that really was the solution. Since then, the YS640 has been a consistent workhorse that does everything as advertised. Built like a tank. built to last. Don and his staff stuck by his product and by his customers. In this day and age, customer service is uncommon. By the way, I thought the YS480 would have been big enough, but my wife said, "our family isn't getting smaller,".....I'm very glad we got the 640 and the second shelf. I have needed it many times. Thanks Don!

Extremely high build quality. It's heavy. Solid. Nothing flexes or bends. The temp displayed is very accurate when referenced with a thermometer. My only complaint is that the 2-piece diffuser should either be standard equipment, or an optional upgrade at order time (in exchange with the stock diffuser). The 2-piece diffuser is a MUST HAVE accessory. Cleaning the firepot is a messy pain the A** without the 2-piece diffuser. I didn't think I would need it, But I ended up ordering it about 6 weeks after receiving my YS640. I also highly recommend the direct grilling grates. I was able to get rid of my gas BBQ because the direct grilling feature works so well on the YS640.

Rec Tec has always been known for making advanced Rec Tec wood pellet grills coming in at a higher price. However, some of the popular models come in smaller sizes, like Trailblazer 340 or Bullseye 380. However, compared to their capacities and features, the products in our top ten lists would be better choices. So, among its products, the RecTec Bull 700 is the only one that falls in our Honorable Mentions.
Secondly, make sure you pay attention to the controls and temperature settings. As well as a thermostat, higher quality smokers come with meat thermometers built in. As you cook, the internal temperature of your meat is going to rise, and unless you’ve got a meat thermometer, there’s no way of knowing exactly how hot it’s got. If you don’t know why this is bad, when you let food sit too hot for too long, you run the risk of drying it out. You’ll undo all of your good work, plus it just tastes bad.
To solve this problem, several companies have come up with alternative ways to expose food to the flame by allowing you to use the small area directly above the fuel pot. It's still not as good as a charcoal or sear burner, but better than the designs that are strictly indirect. Check out the Memphis Elite, Fast Eddy's by Cookshack PG500, and the Yoder YS640 for this feature. Camp Chef also recently introduced its Woodwind pellet smoker, which has a super-hot gas-fueled sear box attached to the right side.

The argument for bark is that it smolders really well, providing more smoke during the cook and therefore more smokey flavor. Think about it: When you put a log on the fire, the bark almost immediately begins to smoke and smolder. And therein lies the second half of the pro-bark argument: when cooking on an offset you use logs with bark, so why should pellets be any different?
The Camp Chef PG24S lets you set the smoker to your desired settings so you can leave it to relax while it does the rest for you. With an advanced digital temperature chip, it steadily monitors the temperature, achieving a constant cooking temperature at all times. Dual LED temperature displays allow you to easily check the temperature of the food kept inside your smoker without losing any heat. With an auto-dispensing pellet hopper that can hold around 18 pounds, your pellets are used efficiently. The grill can work in temperatures that range from 160F to 400F.
Purchased the YS640 about a month ago. So far I have cooked nine pork butts, three racks pork back ribs, one beef brisket and four thick cut New York steaks on it. I am very pleased with the results of these cooks. I have an upright propane smoker, Weber kettle, propane grill and so far the YS640 has out performed all three of those in ease of use and flavor performance. I can get almost the same flavors with my others, but takes more work and babysitting. Also want to mention that the YS640 is built to last. I noticed the ruggedness and excellent USA craftsmanship immediately upon arrival. Some reviewers think maybe the YS has a steep price, but I think its justified due to its construction and craftsmanship. It would be difficult to make something of this caliber for any less. A couple minor things to note is you will have to play with the damper a bit to learn the heat distribution, but after learning it, its not a problem. Doesn't put quite as strong as a wood flavor on the food as my upright propane smoker, but it puts the right amount and I have no complaint here. I would and have already recommended the YS640 to friends and acquaintances. If you have spent long hours smoking foods and know the correct flavors that they should be, your not going to be disappointed with this cooker!
I have several smokers I have used over the years. I have dialed in everyone I own over a course of trial and error. They all get great results, but require me to tend them all throughout the cook. I wanted a smoker that I could easily get to the desired temp, maintain the temp, provide good smoke flavor, and have the size to do a small or large cook, and not need me to be tending it throughout the cook. The learning curve on this smoker is super easy if you know all your temps, your first cook will give you the results your looking for. I was a little worried that I was not going to get the smoke flavor with a pellet smoker, but my brisket turned out amazing, very tender, the smoke ring was perfect. When I was searching for a new smoker I was a little shy of the Yoder based on the price, but when you figure in the ability to grill as well this became a better alternative. The quality is top tier, this is built to last a long time. I'm so glad I went with the Yoder YS640 no regrets.
I called Traeger to discuss their 10k Commercial smoker. The fellow who answered was polite but not helpful. He said, "You need to call our commercial division. They can answer any question you might have," and gave me the number. This is literally how the conversation went when phone was answered. Me: "Hello I was hoping to talk to someone there about your 10k commercial smoker." Him: "What state you live in?" Me: "Texas." Him: "We don't ship direct to Texas anymore, you will need to call one of our dealers." CLICK. So I am thankful I found out now as there is no way in hell I will spend 10k with Traegar.
The seventh pellet grill to achieve its place in our pellet grill review is the YOYO wood pellet grill and smoker. It is a 679 square inch griller (1 cooking surface) with 2 level cooking levels surface. This pellet grill weighs 170 pounds. It maintains temperature from 180 degrees to 475 degrees Fahrenheit. Another feature of this pellet grill is that, it has a digital thermostat controller and comes with the assembly tool kit included.
Hey Ben! Cool re: your Camp Chef! Pellet smokers produce a light smoke as compared to stick burners, gravity fed smokers, Ugly Drum Smokers, etc. Most feel that the smoke provided is enough. If you need more – check out the Amazn Tube Smoker. You can find the Tube Smoker and Cookin’ Pellets via this link. Look for the Pellet Smokers and Pellets links.

When it comes to the material design of a pellet grill, the material is one of the most important aspects to consider for many reasons. First of all, the material has to be able to withstand extremely high temperatures and also be able to cook properly without the heat escaping the grill. With that said, the exterior or the grill has to be able to withstand high temperatures so the color does not peel, rust, or other defects. With that in mind, we discovered that all pellet grills have to be designed from some of the most important materials in the industry, so they can withstand the test of time. Alongside this, pellet grills are built to last so individuals can enjoy them for years to come. When it comes to the exterior craftsmanship of a pellet grill, the most common material is a powerful steel construction. Steel is also known as one of the most powerful and durable materials in the industry today. However, steel does rust if it is exposed to water. Therefore, many quality brands have powder coated the steel so it can be water resistant and does not rust easily.


Fast forward to today.   Finally got my new Traeger running again.  Had an issue with the smoker temperature.   So I called the toll free Traeger customer service line.   Low and behold, who answers my call at Traeger customer service?  Frank!   He is still nasty and ended the conversation with "Hopefully you do not burn your grill up again!"   Nice guy!   Dude, being a smart aleck didn't exactly earn you any points.  You should be ashamed of your self!
Of course, we recommend our pellets and have proven them to work fantastically with all of our grills, but we would never be short-sighted enough to say that our owners must only use our pellets.  That just seems a bit, well, wrong.  From our testing and customer feedback, the following brands all worked very well:  B&B, BBQrs Delight, Cooking Pellets.com, Lumberjack and Smoke Ring.
Hey Ben – thank you for your comment. From a retail user standpoint, I think you’d be happy with either a Yoder or FEC. I really like the PG 500 for the purpose that you’re looking at. Best of both worlds it seems the more I’m looking at it. You can see how they approach grilling steaks in this video. You can incorporate the use of GrillGrates in either pellet grill. Both companies make their units in the USA. Both have great reputations. I’m just partial to Cookshack’s pellet smokers over Yoder as I know more folks who use them.
This is the right choice for anyone that likes smokey flavors and cooking slow at home. It is my first experience with a pellet grill and I have read and studied them for a while. I was looking for a outdoor cooking solution that would give me the ability to cook like the pros without the super sized trailer. Finally deciding to go with the Camp Chef I haven't been disappointed. The temperature control is flawless so you can dial down the cooking process. I smoked chicken the other day and the red smoke ring was a 1/2" deep. It works like a convection oven so there are no cool or hot zones, it just keeps the heat even and consistent. I have noticed even if smoke isn't pouring out the wood flavors are present.
Even if you’ve got a meat thermometer at home, it’s not a bad idea to pick up a smoker with one built in. This is because the built in thermometers send their readings straight to the smokers computer and it automatically adjusts how it’s cooking based not just on how hot it is inside, but how this affects what you’re cooking. Now, unless you’re Gordon Ramsey you probably can’t tell what’s going on inside that turkey you’re cooking, so this is obviously a major plus.
I paid $700.oo for my Traeger. My heating element went out in 2 BBQ seasons. Not good considering the price I paid. It's just me, so it's not like it was in overkill. Bi-weekly meal give or take? Smokes fur shit!! Planned on some good'ol smoked salmon (cause I like to fish for salmon), or some pheasant jerky (cause I have Springers, and I hunt pheasant***) NOT HAPPENING. The only smoke there is...is when you start the damn thing. If you want smoke flavor, you have to add artificial smoke flavor from a bottle. Conventional outside oven heated by wood pellets. If you want BBQ this is not the way to go. If you want smoke this is not the way to go. If you want to leave something inside the oven to cook outside your house....this is the way to go. Wasted $

Hi i would like to buy my boyfriend a good quality smoker but can’t seem to find one that’s small for people just starting out with smoking for our small backyard. Does anyone have any suggestions? I don’t want to invest too much to start incase it’s too difficult to use or we find we don’t like it. I’ve read some reviews on little smokers that catch on fire and that worries me since we live in a townhouse. I figured someone on here would know of a well made brand that is on the smaller/less expensive side.
×