Because most Traeger grills make use of an Ortech digital temperature controller that’s precise within about 15 degrees of your setting, they may not be precise enough for the type of cooking you want to perform. If so, some pellet grill manufacturers, such as MAK, Yader, and Memphis, can give you temperature control within about 5 degrees of the setting. These types of grills use multiple temperature probes inside the cooking area to guarantee the temperature remains consistent. And some of these high-end brands can reach a higher cooking temperature (such as 600 or 700 degrees Fahrenheit) versus the Traeger family of grills (usually around 450 or 500 degrees). Additionally, MAK, Memphis, and Yader grills are made in the United States, while some parts of Traeger grills are made in China.

This unit will not let even a single pellet go to waste. No need of worrying whether you’re out of pellets or not. You can carry pellets at a maximum of 20 pounds, with the digital thermostat ensuring the pellets are being used properly. This saves you loads of cash and gives you smoking food simultaneously without wasting time in refilling pellets.
Pellet cookers usually have an auger or another feed mechanism that pushes the pellets into a burn pot typically about the size of a beer can ripped in half. An igniter rod sits in the bottom of the pot and when you turn on the grill it glows like the element on an electric stove. As the pellets ignite, a fan blows to feed them oxygen, and the igniter shuts off. The Traeger L'il Tex, an inexpensive model, draws 300 watts an hour while the igniter rod is on in the first four minutes, then it drops down to 50 watts an hour for the duration of the cook session, less than a standard light bulb.
My traeger has had some good moments but it very unreliable. I really do not enjoy cooking with it. I have no confidence in the temp readings and the smoke control. Every time I open the lid the temp drops like 200 degrees. I'll smoke at the "smoke" setting but as soon as I turn it to 225 it spikes to like 300-500 degrees. Wtf? I thought this POS was supposed to be a set it and forget it type smoker. Very unreliable. Temp fluctuates so much and if there is even a slight breeze the temps just go up and down up and down. The pellet feeder is garbage. It will all the sudden just start smoking like crazy because the pellets have jammed into the burner. Completely ridiculous smoker. I use it still but only when I can sit and watch the feeder. The guys comment below is true about the feeder always just using the middle pellets. I always have to check it and push the pellets to the center. Some simple engineering would change this. Never again will I purchase a traeger. There are much better options out there and better price.

One final word of caution when it comes to pellet pricing.  If you see a price on pellets that seems too good to be true, there’s probably a reason for it. If the pellets you got an amazing deal on creates twice as much ash, doesn’t burn as well, generates wild temp swings and ends up ruining a $65 brisket were they worth it?  What about if that flame out or temp swing cost you a whole pit full of meat and ruined the family reunion the next day?  We are all for saving money as much as anyone, but perspective is key here.  We are in no way saying that great pellets cannot be had for pennies per pound, but we are definitely saying, that if those pennies saved are not on a proven brand that you can trust then it’s probably not a bet worth taking.


This is a nice article for people new to pellet grill/smokers. Like jennifer, we have a vermont cast ing cast iron gas grill that has ‘rotted out’ internally. Calls to vermont cast ings has resulted in ‘we no longer support, make or sell parts for grills made before 2008’ and other run arounds. As a result we are looking for other options. We like the cast iron grills and grill heat but are considering other options, (Webber, Pellet, gas).
Most people recommend the Green Mountain Grills smoker for its affordability, despite its plethora of features including Open Flame Technology, which ensures that meats are thoroughly cooked. But what impressed us the most was its Sense-Mate feature. For a budget pick, we were surprised to see that it had some of the most advanced technologies that even the most high-end products use. There’s no denying that you’ll get more than what it’s priced at!

We’re people like you, people who love outdoor cooking—the food, the fun, the time with family and friends. We’ve turned that passion into expert knowledge and an unmatched selection of BBQ and grilling products. Any question, big or small, we can help. From your first click to your next call, whether you’re interested in backyard BBQ or an outdoor kitchen, we have what you need and same-day ship nearly every order from our huge in-house inventory.
The hopper capacity is the same as the Traeger Lil’ Tex Elite 22, but what sets it apart is the “Pellet Hopper Drain Chute Technology”. So if you are looking to try a different wood or just storing the grill for a long time, then all you need to do is hang a bucket on the chute and pull out the knob to catch the pellets… and before you know, the tedious task will be over, leaving you with nothing but love for your Camp Chef Grill.
REC TEC Grills was born in Augusta, Georgia in 2009 by lifelong friends Ray Carnes and Ron Cundy. The pair made it their commitment to build high quality grills and sell them at reasonable prices. But that was only the beginning of their story. The rest of the promise was to treat everyone like family and provide them with world-class customer service. With those two fundamentals in place, the REC TEC Family was born and the REC TEC Lifestyle started to flourish. Your feedback as members of the REC TEC Family and your living the REC TEC Lifestyle has helped this family grow and become that special bond that binds us all together. Thank you to all of our current and future REC TEC Family members. It just would not be the same without you all.
Hey Drew – thank you for your comment. All told, most pellet grills are going to average about 1.2 to 1.5 lbs per hour. of pellets per hour at 225, and closer to 1.75 lbs. as you get up to 275. It’s tough to gauge, which is why you are probably seeing different figures across the web. Ambient temperature and pellet composition play a role as well as grill temp. Sorry I don’t have better information for you.
The argument for bark is that it smolders really well, providing more smoke during the cook and therefore more smokey flavor. Think about it: When you put a log on the fire, the bark almost immediately begins to smoke and smolder. And therein lies the second half of the pro-bark argument: when cooking on an offset you use logs with bark, so why should pellets be any different?
I spent a lot of time researching smokers before committing to the 640. I wanted something that can basically be left alone, produce good results and be durable. The 640 meets and exceeds those goals. It is built like a tank, and weighs about as much. I needed two people to help me assemble and move it. Assembly was straiightforward and took about 90 minutes. I have about 4 cooks on it and cannot be happier with the results.

Hey Shannon – they all have their merits. Budget dictates a lot. If you’re in the $1000 or under range, Green Mountain and Rec Tec are great choices. Both have developed near cult followings, with GMG a little ahead of the curve on that front having been around a bit longer. I love the Yoders as far as moving up on the price range is concerned. Will last you forever and they offer a solid product with great support. MAK grills are just beautifully made. There’s no other way to put it. The “General” models are superbly crafted. Love that MAK offers built in cold smoking as a capability. Am I helping here or just making things worse? Hahaha.
What’s more, as Pellet Grills are electric-powered and regulate their own fuel intake, they are a far more foolproof option than other smokers and grills which may require a large amount of maintenance and care during the cooking process. Wood pellets themselves are also incredibly versatile. Aspiring smokers can experiment with a whole array of wood varieties in order to explore the flavors that each lends to meat.
Second, It would be just my wife and me BBQing so I’m looking small. I’m considering the REC TEC Mini Portable Wood Pellet Grill (RT-300) after reading your reviews. Having only ever BBQed with hard wood coals on a Webber, is there going to be a taste fall-off going to the pellet grill as far as charring and/or smoke? I’d hate to spend that kind of money and get bland steaks. Really, steak is all we ever cook outside, though that would probably change with a nice grill.
Actual Cooking: This flat top is a game changer for cooking. The grill heats up very fast and heats up evenly across all 4 burners. It also has traditional grill grates beneath which makes this a 2 in 1 grill. You can cook a plethora of items ranging from tacos, cheese steaks, quesadillas, eggs, pancakes, hash browns, fried rice, assortment of Chinese dishes (beef and broccoli, Mongolian Beef, Garlic Chicken with Veggies, etc), and basically anything that could be cooked in a typical cast iron pan or skillet. It heats up bread, tortillas, and buns in a matter of seconds. The flat top itself can accommodate a lot of food at once and can cook for up to 50 people per hour at max capacity. The ability to cook multiple items on the flat top at once is especially helpful for cleaning as you won't need to have multiple cooking pans or skillets to clean up afterwards. Anyone that has the ability to use this as their main cook top should do so.
Now comes the best part about pellet smokers: they can conveniently do all these three. Coming with a large cooking space and a lid, the top rated pellet smokers would allow you to keep them open or closed, depending on what results you are looking for. With a dedicated space for putting your charcoal, you can use it as a charcoal grill, smoker or a barbecue. Or you can use it like a kitchen oven using the direct fire from the firepot. Finally, it does what it was made for – pellet smoking. Using small hardwood pellets running over the firepot in a corner, this smoker uses a fan to distribute the heat and smoke throughout the grilling area. This indirect heat ensures that the food is slow-cooked and smoked over long periods of time.
The SG and ZG are not exactly the same though. Just from the pictures I can see that the bases are different. The SG has L-shaped legs and a bottom shelf while the ZG has square legs that are larger than the DLX legs but no bottom shelf. There were also different specs for many features. I took a picture of the ZG spec sheet at the store and compared it to the SG specs on the website and there are slight differences in capacities. For example ZG 3778 cubic inch - SG 4859, grilling area ZG 776- SG 811, hopper volume ZG 18 lbs - SG 22, ...
Meanwhile, it also has a 15-pound pellet capacity comparable to Camp Chef SmokePro (not as large but big enough to eliminate continuous wood pellet refills) and folding legs for better portability. However, certain users who’ve already bought their own REC TEC Grills Mini Portable Pellet Grill have complaints about it, like inconsistent heat distribution of the grill and poor quality control (certain grills break down easily).

I’ve seen a lot of pellet smokers over the years, and it’s easy to say that out of every one, the RecTec is without a doubt a beast. It combines exceptional cooking performance with fantastic build quality and a thoughtfulness of design that you just don’t see in other smokers. Or a lot of other products. Not only that, but it’s one of the easiest smokers I’ve ever used, with professional quality cooking literally at the push of a button
One thing we humans tend to forget amidst hustle bustle of our fast paced and commercial lives is that we should earn to live, not live to earn. So I think it is high time you ditch your shoe-box of an office behind for a day and live. Spend a day with your family at the park, or maybe catch up with your childhood friend over a beer or two and start doing barbecue. You cannot even begin to imagine how much spending some quality time with your loved ones can help you and them, revive and replenish the monotonousness. And there isn’t a better way to mingle than over a small get-together with some amazing food and great company cooked on your pellet grill.
In smoke mode the controller is no longer controlled by the thermometer, it merely switches the pellet feeding auger on and off. On time is 15 seconds, off time ranges from 45 seconds at P0, to 165 seconds at P15. Temp and smoke are controlled by the duration of off time: the auger always runs at the same speed. More smoke is produced at higher P settings and lower temp settings because longer off times allow the pellets to smolder. At P0 in smoke mode or "High" in cook mode the auger replenishes the pellets at a faster rate, creating more flame, less smoke.

They had the field to themselves for a few years, but the idea was too good to go un-imitated, and soon competitors began popping up. In the early days, most pellet smoker controllers had only three settings—low, medium, high (LMH)—and there was no temperature probe in the oven to create a feedback loop. So, whether you were smoking a few slabs of ribs on a scorching summer day or six pork butts during a blizzard, the controller only knew pellet-feed on and off times for its standard settings. It had no information on the actual temperature inside the cooking chamber.
This cooker is still the best value for the dollar for pellet grills I have been looking again for a larger rig, but haven't found one better. If you are looking for an entry level pellet grill this is the one you want. Don't be discouraged by the reviews that talk about leaking smoke or not sealing well because it does leak smoke everywhere. Look at the pic I attached to my review you can see it for yourself it does, but isn't it silly to buy a smoker that doesn't smoke. If you ever go to a BBQ competition you will see most of their smokers leak smoke also.

This presumably has the most exact temperature perusing of any grill right now available. Accompanying a cookbook, a simple get together, and a decent outline, the PG24 is definitely justified even despite the cash. I enjoyed the decision of a wood screw framework rather than a suction framework, since it spares cash on pellets, and manages temperature better. For those needing to get into pellet grilling, this would be an astounding decision.


I purchased a Traeger Elite Grill from the website. I use the grill one time and it worked fine. A couple of weeks later we fired up the grill to cook some steaks. Approximately 10 minutes into cooking the auger stopped working. We had to finish our meal cooking it on the stove. I looked at the troubleshooting guide and the steps needed to be taken. To determine what was wrong you basically needed to dismantle the electric box and auger housing. I am not an electrician Nor a mechanic and feel this is excessive for a consumer to have to do.
The entire system was designed in order to make smoking fun and easy. Cleanup is easy, getting everything going is easy, and food turns out great every time. The main cooking area 292 in.², which means you can cook a lot at one time. Since it uses convection technology, the smoky hot air can circulate around the food in order to cook everything evenly.
Even and fast cooking – this is the common feedback of the new and past users of this pellet grill cooker. Although some of them would say that the temperature is inaccurate, they can still manage to adjust everything well by means of its digital temperature controller. Additionally, you may need to add more pellets if you will set the temperature on a high setting.
I brought my YS640 to Mexico on a friends recommendation, he was right. I takes the complexity of smoking away but this is not the reason why I got it. We live in south of the Sonoran desert and we are over the 100F most of the year, its almost impossible to stay close to your smoker to watch the fire and temperature. Plus, wood is not as easy to get in the desert. Since I got it, I have been selling food on Sundays, I was sold out since day one. Flawless food time after time. I am planning to get the old time offset cooker to smoke in the winter just for fun. There is really no need for it.
Cleaning and Maintenance: Any individual who’s taken a stab at cleaning a pellet grill before sees exactly that it is so hard to get all the ash out after use. This unit gives you a less demanding access to the burn pot. It also includes a trap door which permits you to clean the unit without digging through the ashes and oil. Cleaning the unit is by and large significantly less demanding when compared with the normal charcoal grills.
Overall, I think you would be happy with the smaller smoker / grill. I really like what Green Mountain grills has done with the Davy Crockett model, and that is the unit I have personally. That said,Rec-Tec makes a great product, and some people prefer the cart stand it comes with rather than the fold up legs that Green Mountain grills uses on the Davy Crockett modeling. Either choice would be good for you if you are looking for a smaller unit. I am of course speaking about the mini version of the Rec-Tec. The larger version is excellent as well.
Multi-position Controller - A step up from 3-position controllers, multi-position controllers feature a knob with temperature settings that go from 180°F to 420°F in 25° increments and may have an LCD display. In addition to more settings, these controllers offer more temperature control. However, they also run on fixed cycles and can only maintain about +/-20°F in ideal conditions—in cold windy weather they are less accurate and reliable. Some versions of these controllers have inputs for meat probes that can monitor food temperatures.
The computer controlled system maintains the smoker temperature with a high degree of precision so you don’t have to deal with fluctuations. With the optional (definitely a must) temperature probe you can put your meat in the smoker, set the desired target temperature and the FEC will take it from there. Once the target temperature is reached the smoker temperature will drop into a holding position until you are ready to remove your barbecue.
×