Thank you so much for the kind words! I think you would be very happy with a smaller pellet grill / smoker. The wording changes depending on how you are using the device. For instance, if you are cooking at low temperatures you will get a stronger smoke profile then if you burn a pellet smoker / grill at its higher temperature range. One thing you could do for steaks is cook them at the higher range thus being able to get a sear much like you would on a direct heated Grill service, for instance on your Weber. Another option would be to cook the steak in the reverse see your method, by bringing it up to temperature at a lower smoker setting and adding some smoke flavoring that way, then removing it and bringing the smoker up to its higher settings so you can finish off the steak with some of the effect you would achieve on direct flame. I normally do this by bringing the steaks up to about 15 degrees below where I want them to finish. Then, I finish them off at the higher temperature to where they are about 5 degrees below my target. This usually means a few minutes on each side but I use a Thermapen to be sure.
I believe the little Green Mountain Davy Crockett is the best portable pellet smoker currently on the market. Surprisingly, many of the portables out there still have an antiquated LMH controller, while Davy Crockett employs Green Mountain's advanced digital touch-pad controller, with an integrated meat thermometer that lets you check internal meat temp with the flick of a switch. Furthermore, it includes adapters to run the electronics from your car battery or cigarette lighter. And Green Mountain is aggressively—ahem, hello, price cut—promoting its WiFi capabilities, which enable you to monitor Davy Crockett from your smartphone or laptop.
Is it food quality? All of my foods are the best I have ever grilled. The ribs are nearly falling off of the bone, yet still moist! In the past, if I tried to get them to that point, they would have been very dry. All of my meats have been moist with a lightly smoked flavor. My breads perfectly crusted on the outside, moist inside with a perfect crust!
The Ortech has two knobs. The large one, the "Cook Control" has settings for: Off, Smoke, 180, 225, 250, 275, 300, 325, 350, 375, and High. One smoker manufacturer says that the "Smoke" setting is about 160°F and "high" is about 525°F, but both can vary due to ambient temperature, humidity, fuel type and quality of the smoker. Another knob, a teensy weensy knob to the right of the LED screen looks more like a push button. Labeled "SMOKE" and called the "Smoke Control Knob", it is meant to turn, not push, and it controls the pellet feed rate with auger on/off sequences indicated by "P settings". The P settings range from P0 to P15.
I always encourage consumers to get to know a little bit about a brand and company before purchasing a product from them. What differentiates a smart consumer from a consumer is preparedness. Get to know about the company history, its commitment to consumers, its consumer service, after-sales services and warranty. It is also a great idea if you can go through consumer ratings and reports the company’s pellet grill review before buying it. Do not just fall for intelligent marketing and chic packaging. Get you facts checked; remember it is your hard earned money on the line.
By far, the two most popular pellet flavors are hickory and apple. Both are classic BBQ woods, and between the two you can cook just about anything. Hickory produces a moderate smoke that’s strong enough to stand up to the bold flavor of beef, but isn’t so strong that it overpowers pork or poultry. Apple, on the other hand, produces a sweet and mild smoke that complements lighter foods like seafood and vegetables, but also has enough backbone to be used with poultry and pork. Although hickory and apple are the most popular flavors, you can also pair other combinations of moderate and mild woods (such as pecan or oak with cherry or peach) to sufficiently cover all your BBQ bases.

Food not cooking evenly or at desired times: It’s worth checking out the health of the fans in your pellet grill. Usually, if the fan is unable to distribute the heat properly throughout the whole smoker, these problems occur. Fans are relatively inexpensive and very easy to replace. Even if you see the fan working and still getting these problems, it might be that the fan is working intermittently or at slower speeds that it needs to. Have it replaced: it would be the best course of action and won’t be heavy on your wallet.


Using accurate digital thermometers to monitor cooking and internal meat temperatures is essential to being all that you can be in the backyard. Unlike the caveman-era heat estimators built into the lids of most grills and smokers, modern pellet smoker LED displays will give you the real story of what's happening in your smoker. Of course, if your smoker doesn't come with a dual-display system that monitors both cooking and meat temps, you'll still need an accurate digital meat thermometer.
What we loved most is that it has a trap door to allow burn pot cleaning after every cooking. It lessened our job of cleaning this pellet smoker by 60%. It is more than amazing because from our research we know that a feature like this will cost twice as much as the Camp Chef. Honestly, this has emerged as our key point when we selected this smoker to be the best in our review.
The Elite's digital control panel is a sophisticated touch-pad PID controller that holds set temps with more accuracy than most kitchen ovens. It's simple to operate and offers an integrated meat probe and some useful programming options. For example, you can set it to cook your brisket up to 200°F (93°C) and then drop to a lower cooking temp to keep it warm without overcooking.
DS, I have a green mountain grill. besides that for any pellet smoker cook your chicken at a high heat otherwise the skin will be rubbery. doesnt have to be a direct flame to get it crispy. I set my GMG to 425 flip it after 8 mins pull it at 170 crispy perfection. if you want more smoke flavor, smoke it at 150 for an hour then crank it up to 425 to finish it. I was upset with my rubbery skin when i first used it as well but i got some good advice from the pros. chicken doesnt need to be cooked low and slow to tenderize it like pork and beef does. it doesnt have the tissues or muscles that need to be broken down like beef and pork
Coming over to the cooking area, you will find 2 stainless steel grill grates that give you 702 sq. in. of cooking space with an option of the second shelf that makes it 1054 sq. in. Its tall enough for turkeys and large enough to fit 6 large-sized racks of ribs. So, hosting a bunch of people for a BBQ party, and cooking delicious meat for them, would be as easy as it could get.
Just started shopping around for a pellet smoker. Am also going to need a new gas grill soon. Stopped in at the local BBQ supply store today and they showed me the Memphis Pro and said it would function well for both smoking and cooking steaks/burgers. Price point on that one is pretty high. Would any of the others reviewed above offer similar functionality? Do you have a recommendation of which will work well for both functions? I live in KS so kind of like the idea of sticking with the local guys from Yoder, but Fast Eddys in OK isn’t too far away either. Thanks.
Grilla Grills are not only great with their puns, but also great with their products. Since we compiled a list of top 10, getting rid of this product from our review was a very difficult choice. Silverbac Pellet Grill, along with several others from our honorable mentions list, has been tied with our advanced pick. Therefore, we were forced to place this on our honorable mentions list. With its traditional barrel-shaped design and astounding colors, they’d look nice in your backyard should they be your top choice.
I've had it for right at a year as of the time of this review, and I absolutely LOVE IT. Normally I am of the opinion that you should overspend to get the better product, but I am 100% satisfied with the SE. I've gone through almost 200# of pellets in a year and I've successfully smoked three briskets, pork in various forms, a bunch of whole chickens, salmon, and probably some other thing I'm not thinking of. The show-stopped for me is bacon-wrapped dove breasts. I smoke them for an hour and then finish them on my grill. They are out-of-this-world amazing.
3-Position Controller - 3 position controllers, also called LMH controllers, have just 3 temperature settings—low, medium, and high—which correlate to roughly 225°F, 325°F, and 425°F. They feed pellets in fixed cycles that are determined by which setting you choose. With just three settings to choose from, though, you have less control over cooking temperatures than more advanced controllers. These controllers are often found on lower priced pellet grills.

To sear a steak you need direct radiant heat. I don't care if you can heat the air to 1000°F, it is still indirect heat and that does not deliver as much energy as direct radiant heat. It's physics, but not hard to understand. In short, heat is not the same as temperature. It feels hotter at 80°F if the sun is shining on you than if it is 80°F in the shade. I discuss the concept in more detail in my article on thermodynamics of cooking.


Smoking v. Grilling more about the temp you’re cooking at than how it’s heated. Smoking happens below 300F most of the time. The Sawtooth Pellet Grill can get to 550F-600F at the top end so it’s more of a grill at that point that smokes. I’ve grilled burgers and fajitas and other stuff like you would a gas grill. Works great and it’s made in the US!
Hello.. You recommended a couple weeks ago to go with a GMG grill and that is the one I’m going with. I’m just a little torn between the DB and JB. They are only $150 apart but I’m not sure if the bigger size is worth the money when I can spend that on a cover and some pellets. Do you think the bigger size is worth it for a back yard smoker with the occasional party? I know people say bigger is better but I went bigger with my previous barrel smoker and it was much harder to keep an even temp with the bigger size. I would have went smaller given the chance. Thanks for any input!
My traeger has had some good moments but it very unreliable.  I really do not enjoy cooking with it.  I have no confidence in the temp readings and the smoke control.  Every time I open the lid the temp drops like 200 degrees.  I'll smoke at the "smoke" setting but as soon as I turn it to 225 it spikes to like 300-500 degrees. Wtf?  I thought this POS was supposed to be a set it and forget it type smoker.  Very unreliable.  Temp fluctuates so much and if there is even a slight breeze the temps just go up and down up and down.  The pellet feeder is garbage.  It will all the sudden just start smoking like crazy because the pellets have jammed into the burner.  Completely ridiculous smoker.  I use it still but only when I can sit and watch the feeder.  The guys comment below is true about the feeder always just using the middle pellets.  I always have to check it and push the pellets to the center.  Some simple engineering would change this. Never again will I purchase a traeger. There are much better options out there and better price.
The PK-360, with 360 square inches of cooking space, this rust free, cast aluminum charcoal grill is durable and easy to use. Four-way venting means it's easy to set up for two zone cooking with more control than single vent Kamado grills. It is much easier to set up for 2-zone cooking than any round kamado. Beautifully designed and completely portable. Meathead says it is his preferrred grill.

Maintenance is an issue. There are moving parts on these grills. Moving parts eventually break. There is an auger with a motor, and a fan with a motor. There are proprietary electronics systems on these babies. Augers clog. Motors burn out. Electronics have bugs or fail. Especially when exposed to rain, snow, hot, and cold. When they fail, will the manufacturer have a replacement part?
First impression was this thing isn't built like a mass produced unit, it's more like something you would expect from a master fabricator. The assembly instructions were incredibly detailed, and the way it was packaged made it really easy. It takes a little time to get temp steady for low smoking, but once it's there it seems to be pretty steady. So far absolutely impressed with everything about this cooker, and made in the USA!!!
Kevin- super helpful article. Thanks! I just moved from a big city small apartment with no grill to a house in the country. Most essential purchase is the grill. I’m really on the fence. I like the idea of a pellet grill, but in reality- I’m mostly cooking burgers, fish, steaks, scallops, and veggies. The brisket and ribs will be more of a special occasion. From an economical perspective, am I better buying a gas grill and just getting one of those smoke tubes to add some flavor? From many of the online comments, it seems like the pellet grills benefit from additional smoke anyway, and though you can get additional grates for searing, seems like a square peg in a round hole. The gas grill is sort of the tried and true, and way more economical. Those $500 entry level pellet grills seem a little scrawny, and the next level up is a cool $grand. I’m really on the fence, and getting pressure to “just buy the darn thing” to consummate the move to the country! However the pellet grills seem like the new shiny object and have my curiosity. Any advice? PS- love the website! Thanks, Cary
REC TEC Grills was born in Augusta, Georgia in 2009 by lifelong friends Ray Carnes and Ron Cundy. The pair made it their commitment to build high quality grills and sell them at reasonable prices. But that was only the beginning of their story. The rest of the promise was to treat everyone like family and provide them with world-class customer service. With those two fundamentals in place, the REC TEC Family was born and the REC TEC Lifestyle started to flourish. Your feedback as members of the REC TEC Family and your living the REC TEC Lifestyle has helped this family grow and become that special bond that binds us all together. Thank you to all of our current and future REC TEC Family members. It just would not be the same without you all.
Yo, Kevin! Hope that you can soon review one of my all-time favorite purchases, the Traeger Li’l Tex Elite Smoker/Grill. After using it for a couple of months, I gave away my two year old gas-grill to my grandson. We’ve done chicken, turkey, pheasant, lamb, all kinds of beef, pork and sausages including some wonderful ribs and brisket. Our Easter Rib Roast turned out terrific as did the chunks of assorted sausages that we did for another family get-together. I was never a big fan of grilling until we got our Traeger. Both Traeger and the web-sites like yours are full of great recipes and ideas.
Thanks for your question! I think you’ve actually selected the grill that I’d recommend too. The Camp Chef pretty much has it all. It’s quality, it’s priced nicely, it does a great job smoking… and honestly, that ash cleanout feature is pretty much something that I wouldn’t want to do without. Especially if you’re new to pellet grilling, anything that makes the job smoother and simpler will be appreciated!
Everyone has their price range, but don’t confuse cheap for affordable. As with other types of grills, there are plenty of inexpensive pellet grills that seem attractive at first glance, especially if you're looking to save a little money. However, while a cheap pellet grill might save you a little money up front, it's going to cost you more in the long run. Parts will rust, components will break down, and you will likely find yourself replacing some or all of that affordable grill within five years. Ultimately, you're better off investing a little more money up front and get a quality grill that will keep years to come.
Therefore, for a reliable and consistent meal/ grill every time, go for the Traeger grill. It is easy to set and control the temperatures, thus the results are always as expected. Besides, a novice griller can master its use immediately, as it is a complete digital experience. On the same note, it can do a lot more than just grilling. You can use it to smoke, barbecue, braise, roast, and bake, all through the digital control system.

Please Note: If you select Express or Expedited shipping, your order must be received and credit must be approved by 12:30 p.m. EST, or it may not be processed until the next business day. Expedited shipping is available for select products. You can view complete shipping options for your product in your shopping cart. The estimated delivery date for your order will be provided on the order review page prior to completing the order.
I always encourage consumers to get to know a little bit about a brand and company before purchasing a product from them. What differentiates a smart consumer from a consumer is preparedness. Get to know about the company history, its commitment to consumers, its consumer service, after-sales services and warranty. It is also a great idea if you can go through consumer ratings and reports the company’s pellet grill review before buying it. Do not just fall for intelligent marketing and chic packaging. Get you facts checked; remember it is your hard earned money on the line.
Most old-timers will tell you that a buildup of soot and grease will improve the taste of your food. This does not prove true, in fact, it’s not good for you and can even be dangerous. At Grills Forever we want your grilling experience to be the best and safe. Therefore, before any cooking session, always clean your grill to optimize its performance and prevent any off-flavors. Check the grease pans or collectors before smoking because the collector could be full and overflow, starting a fire. If there is a grease chute then clean it for sure.
When looking at a pellet grill also consider the material its made from. A majority of pellet grills on the market are made from painted steel. However, the quality of that steel and the paint can vary. A good high-temp powder coat paint can stand up to high heat without blistering or flaking. This is essential, because once the steel is exposed, it will rust. Even if the grill body is painted well, you have to look inside. The fire pot and diffuser plate have the potential to corrode and are two of the most common parts that need replacing. With some painted steel grills, such as Traegers®, you can can upgrade the grill and hopper lids to stainless steel, as well as the firepot, diffuser, and drip pan.
***Update: 11/2014: It's been a year now and I still adore this little grill. I've got a kamado and 3 different kettles and this is by far the most convenient and easy to use. The smoke rings this guy puts on a brisket are amazing and the flavor is the perfect balance of wood flavor without overpowering the meat. I've researched about 15 different pellet grills and I still can't find a better value than what this grill offers
Hey Ben! Cool re: your Camp Chef! Pellet smokers produce a light smoke as compared to stick burners, gravity fed smokers, Ugly Drum Smokers, etc. Most feel that the smoke provided is enough. If you need more – check out the Amazn Tube Smoker. You can find the Tube Smoker and Cookin’ Pellets via this link. Look for the Pellet Smokers and Pellets links.
Choosing the one perfect pellet grill that could change your cooking experience is easier said than done. There is just so know you have to know before committing to it. Though I did give you a run-through of all the basic and important things to look for in a pellet grill before buying one, it is still a scratch on the surface. It is tiring to have to go from store to store to find the quality ones that you can choose from. So, to come to your rescue once again, I will now give you the some pellet grill review.
“We love pellet grills but didn’t like the designs of the models on the market. They are more like an oven than a grill. MAK Grills are designed to be the best in class. You get outstanding BBQ flavor and safe cooking with real wood, along with an automatic lighting and fuel feed system. Simply turn the grill on and you’re cooking in minutes! Our direct heat FlameZone ® feature is pioneering the industry for “gas grill like” cooking without the hassle of flare-ups and burned food.” — MAK Grills
×