Like other grills, pellet grills list cooking area two ways: primary cooking area, which refers to the main cooking grate, and total cooking area, which is the main cooking grate plus any secondary racks. However, since pellet grills are primarily indirect cookers, there really is no difference between cooking on the main rack or the upper rack&em;the temperature should be the same. Therefore, a smaller pellet grill with a primary grid of 450 square inches and an upper rack of 125 square inches may be a better option than a larger grill with only a 500 square inch primary grid.

Because the wood pellets are the grill’s fuel, you should pay careful attention to the pellet hopper, the chamber that holds the pellets. You want a large enough hopper to hold all the pellets you need for a single cooking session. Look for a hopper with at least an 18-pound capacity if you want to slow cook for longer periods without having to refill the hopper.
In the second year, the grill quit working. The auger turns and the heating rod gets hot but the grill shuts itself off within minutes. I think it is the controller but I've had the same experience as others: emails and phone calls to Traeger's customer service are unanswered. My wife just wants to return it to Costco but I'd rather fix it. Given the lack of response and the poor quality of the electronics, I'm starting to come around to my wife's point of view.

Third, we’re experienced: We have burnt our foods and fingers; and while we were at it, we learned from our mistakes. In doing so, we’ve managed to become the best and mastered the art to perfection. So, we went through the same learning curves that you did or might do. So, we’re aware of the things that matter and we’re going to impart that knowledge with you, so that you don’t make the same mistakes as us.
Because the burn pot is small, there is usually a hot spot directly over it. Some units have an optional perforated section above the burn pot so you can put the meat over direct flame, but the ones I've tested still do not sear properly. And there is no way to set up a 2-zone cooking system with a cool zone. As with most other grills and smokers, the differences between lower and upper racks is not huge, so think of it as one heckuva indirect heat convection smoker with precision temperature control.
Hey Jay – Yoder makes a great product. Price not being an option, I’d probably go MAK, Memphis Pro (I go back and forth between the two personally!), then the Yoder. I’ve heard good things about the Louisiana pellet grills, just haven’t featured them here so haven’t done a lot of in-depth research. I’m inclined to rate it below the ones I just mentioned – but not by tons. I will say that if American Made is a factor, MAK, Memphis, and Yoder are a go there.
Hey Eric! Man, thank you for the kind words. While I don’t post every day, I do try to make what I share with you guys as informative as possible. To that end, your words mean a lot. Now, the pellet release option is a great feature to have on any pellet smoker. In cases where you don’t have one, I suggest using a small shop vac you use just for pellet removal. Works great. But the quick release chute option saves a ton of time and effort for sure. Not what I’d call a deal breaker if a pellet smoker you like doesn’t have one. However, I’d like to see it become standard on pellet smokers for sure!
Today, all serious players in the pellet smoker market have switched to digital thermostatic controllers that dictate pellet-feed commands based on a temperature sensor inside the cooking box. Just like with the oven in your kitchen, you set the desired cooking temperature, and the heating system kicks on and off to maintain that set point. An LED display shows your set temp, and most models allow you to toggle between set temp and actual temp readings from the internal thermostat. Actual temperatures will fluctuate a bit as the controller switches on and off to hover around your set temp, but many sophisticated touch-pad controllers can maintain tighter tolerances than your indoor oven. Some pellet controllers also have integrated probes that let you monitor the internal temperature of whatever you're smoking. Wireless remote control and monitoring from your smartphone or tablet are also increasingly common. (You can learn more about pellet smokers on AmazingRibs.com.)

One other thing to know about the wonder of pellet grills is that they come with pellet hoppers, varying in capacity from brand to brand, that accommodates and use the pellets you put it accordingly and automatically as per the heat setting, eliminating the need to refill the hopper manually so frequently. So throw on some lamb ribs on to those hot grills, and go enjoy some cold beer while the pellet grill does the rest for you! 

Camp Chef's Woodwind Pellet Smoker is a quality smoker and super searing grill wrapped up in one. As I mentioned above, though pellet smokers are often referred to as pellet grills, most have a limited grilling capability at best. To fill this gap, in 2017, Camp Chef introduced its optional LP gas Sear Box, which can be added to any of its current SmokePro pellet smokers. Woodwind is a package deal that comes standard with the Sear Box and sells for about $50 less than a SmokePro with the optional Sear Box. As a bonus, Camp Chef is one of the few brands on the market with an ash-removal system that deposits ash in a cup under the smoke box for easy disposal.
Overall, I think you would be happy with the smaller smoker / grill. I really like what Green Mountain grills has done with the Davy Crockett model, and that is the unit I have personally. That said,Rec-Tec makes a great product, and some people prefer the cart stand it comes with rather than the fold up legs that Green Mountain grills uses on the Davy Crockett modeling. Either choice would be good for you if you are looking for a smaller unit. I am of course speaking about the mini version of the Rec-Tec. The larger version is excellent as well.
The Fast Eddy by Cookshack is an American designed and manufactured Pellet Grill with a riveted stainless steel body and solid digitally controlled system to maintain the consistent temperature. The name of the game here is sturdy reliability. What it lacks in little extras like wifi controls it makes up for inconsistency. Whether you're smoking, grilling, or searing, the Fast Eddy performs.
The Pit Boss really is the boss with its 700 square inches of cooking surface. The space alone isn’t what makes the Pit Boss 71700FB one of the best wood pellet smoker available. If you thought the Traeger TFB29LZA Junior Elite Grill had a lot of space at 300 square meters, then get more than double that with Pit Boss (the Rec Tec grill below beats it by only 2 inches).
Hey John – great question. My experience is that I use maybe 8 lbs of pellets for a 7 or 8 hour cook at 275 degrees. Pellet grills are relatively fuel efficient. The brand of pellet you choose will play into this. Cost for pellets varies by manufacturer, similar to charcoal. I think you’ll find them very efficient if you’re just firing them up for high heat, shorter grilling sessions.
Dealers are happily selling these while Traeger is aware per 1-800 call that they need to replace thousands of drip pans/heat exchangers on units that have been shipped because the ones in the units shipped allow heat to fluctuate widely. Traeger recommended NOT USING THIS BRAND NEW GRILL until I receive the replacement part which they will not receive until the last part of August and they will not commit to expedited shipping when they finally ship.
Other elements of the grill are the legs, which come in varies designs and construction materials. The automatic ignition starter to start the fire as well as the digital controller where individuals can achieve up to six different cooking methods ranging from grilling to baking and smoking. With that said, one of the most important aspects that we highly recommend individuals to consider is a green with a grease bucket or an ash cleanout design that vents out all of the ash sediment from the grill.

Pellet cookers usually have an auger or another feed mechanism that pushes the pellets into a burn pot typically about the size of a beer can ripped in half. An igniter rod sits in the bottom of the pot and when you turn on the grill it glows like the element on an electric stove. As the pellets ignite, a fan blows to feed them oxygen, and the igniter shuts off. The Traeger L'il Tex, an inexpensive model, draws 300 watts an hour while the igniter rod is on in the first four minutes, then it drops down to 50 watts an hour for the duration of the cook session, less than a standard light bulb.
Every outdoor cooking enthusiast wants an affordable pellet smoker that has all of the key features that even a high-end unit would have. In most cases, this is just a dream and a result of false advertising, because most impressive smokers typically cost a hefty sum of money. The Z Grills Wood Pellet Grill and Smoker claims to be a reasonably-priced smoker that offers top-of-the-line features, and many users have agreed with those claims. With this pellet smoker review of the Z Grills Wood Pellet Grill and Smoker, we’ll find out if it really does what it claims to do.
I am currently using a Bradley Smoker, which is basically an electric oven with a smoke generator that makes tons of smoke, using special Bradley Smoker pucks (of compressed saw dust). A tall cylinder hold a stack of pucks, and the smoke generator pops a new puck into the oven every 20 minutes or so (when the pucks are about 80% burned). Managing temps is not as difficult as a stick burner, but nothing like advertised with these pellet burners (like the Rec Tec).
Actual Cooking: This flat top is a game changer for cooking. The grill heats up very fast and heats up evenly across all 4 burners. It also has traditional grill grates beneath which makes this a 2 in 1 grill. You can cook a plethora of items ranging from tacos, cheese steaks, quesadillas, eggs, pancakes, hash browns, fried rice, assortment of Chinese dishes (beef and broccoli, Mongolian Beef, Garlic Chicken with Veggies, etc), and basically anything that could be cooked in a typical cast iron pan or skillet. It heats up bread, tortillas, and buns in a matter of seconds. The flat top itself can accommodate a lot of food at once and can cook for up to 50 people per hour at max capacity. The ability to cook multiple items on the flat top at once is especially helpful for cleaning as you won't need to have multiple cooking pans or skillets to clean up afterwards. Anyone that has the ability to use this as their main cook top should do so.
Kevin, Im about ready to pull the trigger – im pausing for a moment to consider your thoughts as you mentioned Grilla Silverback or Camp Chef. How do these compare to the Rec Tec on quality and price? (as they are less than Rec Tec) And reverse sear…how well does this work on pellet grill, ie how long does it take to go from 200 cooking temp to 500 searing temp (with grill grates)? Thank you for your time

It also has the standardized dial-in digital control with LED readout (not to the point that it has WiFi like the Green Mountain Grills Davy Crockett Pellet Grill, but still quite convenient). However, it’s rated low on this list because of poor quality control. Too many customers ended up with bad Pit Bosses that have inconsistent temperature control (going all the way to 615° Fahrenheit).
It offers 700 sq. in. of cooking space and a powerful thermostat for a higher price, but makes up for it as soon as you start cooking on it. Also, it has a stunning design with the bull horns, which sets it apart yet again. But if you find yourself not spending as much and could do with a lesser cooking space, then the Camp Chef PG24 is a no-brainer for you.
Even after reading the reviews and watching the videos I was still not prepared for seeing the 640 when it arrived. What a machine! A tank? Yes it is, it makes other brands look cheap and disposable by comparison. I was nervous paying a little more for a Yoder wondering if it was worth it, it was worth every penny. Have only used it a few times for ribs and chicken which turned out great. The wife said 'How much?!' when I ordered it, now she says we should have got one years ago.

Whenever pellet grill owners complain about temperature swings or losing their fire mid-cook, the first question we ask is “What pellets are you using?” Many times it’s a cheap, low-quality brand that produces excessive ash, which can interfere with the sensors that help regulate cooking temperatures. In that case, fix is simple: use better pellets that burn cleanly and regularly clean any residual ash from the grill. Often that’s all it takes, and the next time we hear from the customer it’s to order more pellets.
I have ate a few peoples cooking that have won at the Royal, Houston and Memphis in May. They have all had one thing in common, I didn’t put one drop of sauce on them and they had not been sauced on the Q before serving! The restaurant Cackle and Oink is just a ways from where we live and the owner Aaron Vogel is there regularly. I have tasted all his sauces and they are very good, but the 3 times I have been there, his sauces never touch my ribs and brisket! Aaron does say, if you like this you need to try my competition food (which I will at one of the competitions he is in locally). None of the KCBS, Houston or Memphis in may winners Q had even a hint of ash or bitter smoke flavor. They also had a very light smoke profile. They also all say they cook over well burned down wood.

The flame broiler uses a digitally controlled burn system. Its Digital Control Center lets you set the temperature ranging from 170F to 600F with ease. The desired temperature is set and maintained through an electric auto-start and fan-forced air mechanism. These, in addition, give that flavorful smoky taste to all of your foods. The auger automatically feeds pellets into the smoker, so you can pretty much let it take care of everything.
Right off the bat I could tell this smoker was made in America! While putting it together the holes actually matched up! ATBBQ- beat the 5-6 week lead time and delivered in two weeks out to California. This thing is a beast- the heavy weight I was looking for in a smoker and it has the most consistent temp I have ever had with a pellet grill. I messed up on the first pellet grill that starts with a "T" and should have started out with the Yoder YS640. If you are on the fence or wondering if it's truly worth the cash. All I can say is yes...YES it is. Pull the trigger and order this now- you won't be disappointed. I don't work for Yoder or ATBBQ- I'm just a experienced BBQ'r that could not be happier! Thanks Yoder and ATBBQ,
Great reviews. I have been lately looking into pellet poopers. I currently own a large Big Green Egg and a Pit Barrel Grill. My Egg has limited space. On the PBC (Pit Barrel Cooker) I can cook a ton of food as it uses hanging meat method. But it has zero temperature control on it. A set lower vent and that’s it. You have to adjust the lid to get the temps up. I have adjustable rings for my Egg that allows for increased capacity. Eggs are great smokers, grills and ovens. I do have a FireBoss temp controller for the Egg which will allow a set it and forget operations. Wifi controls also. With that being said, I am looking for increased capacity in my cooks. I was seriously considering a XL Primo Oval or a XL BGE. Then I found these pellet poopers. After reading this blog and other reviews I found some limitations. One the lack of smoke flavor. Now with my Egg I add chunks of wood into the lump for smoke flavor. Same with the PBC. The PBC has different smoke flavor as the fats and juices from the meat drip on the hot coals which ignite (according to PBC’s website) and produce a smokey flavor in the meat. I’ve read two ways to increase the smoke flavor in Pellet Poopers. One is to start at a lower temp for a few hours, then crank it up to cooking temps. Two is the smoke tubes or Mojo Bricks. My question is do these techniques work? One review on the smoking tube said that they really didn’t make that much of a difference. Another issue was for grilling and the lack of direct heat. Grill Grates would eliminate this concern correct? My understanding of Grill Grates is that they provide a way to direct grill in an indirect environment. That’s a limitation with both of my cookers. The Egg can Indirect or Direct grill. Not both. Yes I can remove the indirect piece and set up the Egg for direct grilling, but you risk burnt fingers even with welders mitts on. Wouldn’t the Grill Grates on a Pellet Pooper solve this problem? Allowing you to slow cook that steak to say 10 degrees shy of your temp range then sear it on the grill grate for the a couple of minutes on each side to get it to your desired temp range? Or go the other way, sear first for a few minutes per side then indirect cook it to the desired temp?

As both a fuel source and flavor enhancer, wood pellets can affect everything from how well your pellet grill performs to how good the food tastes. And while one might assume that because all wood pellets look alike that they’re all the same, which pellets you use can make a big difference. These 6 tips will help you choose quality smoker pellets that will keep your pellet grill performing its best and producing great wood-fire flavor.


Traeger wood pellet grills pack big hardwood flavor, from sweet cherry, to savory mesquite, into everything you grill, smoke, bake, roast, braise, & BBQ. Traeger’s wood pellets are made with 100% pure, natural hardwood giving you authentic flavor and nothing else. Grilling has never been easier—just set it and forget it and let the Traeger work its wood-fired magic.
Wood pellet grills look like standard barbecue grills but some with a separate firebox for making smoked meats that will also let you smoke vegetables and other ingredients. As Traeger and Pit Boss both get good reviews from customers, it’s important that you look at the top features of this grills and how each company compares in relation to those features.
I have several smokers I have used over the years. I have dialed in everyone I own over a course of trial and error. They all get great results, but require me to tend them all throughout the cook. I wanted a smoker that I could easily get to the desired temp, maintain the temp, provide good smoke flavor, and have the size to do a small or large cook, and not need me to be tending it throughout the cook. The learning curve on this smoker is super easy if you know all your temps, your first cook will give you the results your looking for. I was a little worried that I was not going to get the smoke flavor with a pellet smoker, but my brisket turned out amazing, very tender, the smoke ring was perfect. When I was searching for a new smoker I was a little shy of the Yoder based on the price, but when you figure in the ability to grill as well this became a better alternative. The quality is top tier, this is built to last a long time. I'm so glad I went with the Yoder YS640 no regrets.
Ever since my visit(s) to All Things BBQ in Wichita, my heart has belonged to the Yoder Smokers. I had researched many comparable size smokers, and guess what - they really are not comparable. The smoker started first time, quickly, and heated up well. I did ribs as my first foray and they were as perfect as my meager talents could get them. The fact that this smoker weighs in at almost 360 pounds speaks volumes as to how well built and how heavy gauge the metal is( something severely lacking in most other smokers). I had the extra shelf put in and the cooking space is easily double what I had seen in other smokers about the same dimensions. Hats off to All Things BBQ for the high quality Yoder smokers they so proudly distribute!!
Lauded for its amazingly accurate cook temperatures and times and for affording cookers a real “unfair advantage” at competitions (according to those who lose to them)  – Fast Eddy’s Cookshack Pellet Smokers rank among the very best available on the market today. I love the history of Fast Eddy’s pellet grills. In 1986, Ed Maurin (Fast Eddy) – a retired KCMO Fire Fighter – cooked his first American Royal event. From that point on he was hooked on BBQ and on coming up with the very best way to ensure its production. By 1998 the first of his Fast Eddy’s pellet smokers was released to the market, and he was off to winning competitions and helping those who bought his cookers do so as well.
×