Due to the lower oxygen at 9200 FASL, I cannot keep the smoker hot and I cannot get it above 250 Deg. F. I seem to be limited due to the diameter of the smoker…just can’t get enough coals and air to get and maintain temps. Therefore, I want to buy a new smoker, on that will regulate temperature at temperatures of 200 – 450 deg F. Any experience or guidance for a smoker brand and type (wood pellet, charcoal, or electric) at high altitudes? i am looking for a smaller size smoker unit.
To cook food using a pellet grill, put the pellets into a hopper. When you turn it on, the igniting rod will burn pellets in the fire. The motor-driven auger will then supply the fire pot with pellets from the hopper. The ratio that auger delivers pellets to fire pot depends on the settings you control. If you set it at a high temperature for a longer period of time, the auger will keep on feeding the fire pot with pellets. However, if you are slow-cooking and set a low-temperature one, the feeding and delivery of pellets will also slow down.
Just like your kitchen oven, a pellet grill must keep a consistent temperature in order to produce great food. To get tender brisket, the temperature needs to stay as close as possible to 250°F for the entire 12-plus hours its cooking. A pellet grill’s ability to do that is largely determined by its control board, which is essentially the brains of the pellet grill. There are different types of controllers, and their precision and consistency varies. Most can hold a consistent temperature in ideal conditions, but not all controllers can maintain a tight temperature in the cold, wind, and rain.
PID Controllers - The most sophisticated type of pellet grill controller, PID controllers use complex algorithms to achieve and maintain the desired temperature within a few degrees. They, too, feature LCD display and one-touch buttons for setting the temperature in 5° increments. However, unlike controllers that use fixed cycles, a PID controller continuously measures the grill’s temperature then adjusts its cycle, adding pellets when necessary to hold the correct cooking temperature throughout the cook. Because they’re more sophisticated, PID controllers can accommodate programmable meat probes that have the ability to automatically lower the grill’s temperature when food is done.
Also own a Big Steel Keg which I love! Didn’t want an egg or a Primo while I was up north WY & CO as I had to many friends complain about cracking when trying to use them in cold weather! Many times at Thanksgiving or Christmas I have cooked on any or all of these devices at -5 to -10. It can be done but with a strong wind it is quite a challenge! My Weber (been thru a couples) and my Keg still have high ratings for great steaks and burgers. But for low and slow you are pushing it to get there and my friends with the ceramic style units say it takes some practice and close attention. What I don’t like about and Egg or my Keg is if you do need to end up feeding the fire on a long cook it is a real serious challenge!
Pellets work so well with the ease of use of a pellet grill because they’re 100% all-natural. They don’t have binders, chemicals, fillers, or petroleum products within them. They serve as a source of compact energy (8,500 BTU per pound) and smoke flavor. Most importantly, there’s little to no ash from them. Compared to coals, there are no flare-ups involved.
Any retail store that you visit, regardless of the product you are intending to purchase, has a supply chain that these products go through before reaching their final destination. There are certain costs associated with getting the product from the manufacturer to you that get tacked onto the price tag of the product. These additional costs can include aspects such as transport fees, warehouse handling, packaging, and display. Therefore, the price tag you see when the product reaches you isn’t just covering a small margin on top of the absolute base price of the product. It has been marked up to cover the additional costs listed above in order to reach you.
Wood pellets are an all natural product. No petroleum products in them, no fillers, chemicals, or binders. They are an excellent source of smoke flavor and compact energy, 8,500 BTU per pound. No hot coals, no flareups. There is also very little ash: 10 pounds of pellets will produce about 1/2 cup of ash. All the rest is converted to energy and combustion gases. I clean out the bottom of the ones I tested after about 10 cooks. At high temps there is very little smoke, at low temps the pellets smolder and produce superb but understated smoke flavors. Click here for more about pellets.
Take your outdoor cooking to the next level with the Camp Chef Pellet Grill and Smoker. Designed with the home griller in mind, built-in features simplify the process of smoking. The included digital temperature readout takes the guesswork out of the cooking process. An advanced digital temperature chip gives a more steady smoke and temperature, eliminating large temperature swings and giving a more consistent cooking temperature. Our patented Ash Can Cleanout System makes clean up the easiest out there. The Pellet Grill and Smoker features range from innovative digital smoker controls to dual temperature sensors. Discover the real secret of award winning BBQ cooks, low and slow smoking.
Product is decent but customer service really didn't help me out when they sent me a wrong accessory part that was ordered by their customer service department. Explained that the representative misunderstood my request for an inside shelf but I was sent outer shelf which I have already . Tried to be fair and asked them to pay for the return shipping so I could return it back. They said we will gladly return your $ . Well till this day after numerous calls and false promises for the credit return .. there still is no refund. They seem to care but actually they did nothing. It's been 3 months of calling. Sorry to say we are Done with this company. If they can't settle a small concern and have A + service then don't bother! Good thing they are not the only smoker on the market. Shop around folks.
The Yoder YS640 is 32 inches wide, weighs 313 pounds, and is said to have a cooking range of 150 to 600°F (65 to 315°C). Yoder is known for heavy-duty competition smokers, and the thick, 10-gauge-steel cooking chamber on this model is durable and great for heat retention. It comes with a sophisticated proprietary digital controller, which Yoder asserts is not based on any off-the-shelf temperature controller of any sort. Yoder states that it designed the board from scratch around a general-purpose micro-controller chip and wrote its own code from the ground up in an attempt to provide superior flexibility, efficiency, and accuracy.
I filed my complaint with American Express. AMEX was absolutely AWESOME......!!! I gave AMEX copies of everything I sent Trager and it's CEO who never answered me. AMEX gave them 30 days to respond and they did not. So the grill was FREE.!!!!!!, and I could care less. Tells you a lot about their CEO and their method of doing business. CEO is Multi-Milllonare living in Salt Lake City and is just playing the numbers!!!!! Hot shot from a HeadPhone company, Skull Candy, who usually gets away with ignoring customers. Clearly don't care about customer satisfaction. Buy another makers grill. Save yourself a lot of headaches. Louisiana Grills are much better quality.
If you don't buy this cooker and spend more than $600 on any cheap thin steeled cooker. By year 2 you will realize you paid for quality that lasts. I joke that no one would steal it because it weighs so much. But it's my baby and it's double locked. I promise you in a year you will look at your wife or family and say "That's the best purchase I ever made!" It's impressive, no one makes a better product. If u buy Traeger or any other cooker. In 3 years you will regret not spending the money on a luxury machine. Yoder is the best of the best. Yoder is who the other guys want to be. I would buy it again tomorrow! Don't have regrets. You won't regret this purchasem
The major issue is the size. It’s the smallest smoker at this price range, and barely bigger than the Junior Elite. Considering the price difference in the two, it’s hard to justify the extra expense, and when you compare it to the other smokers at this level, the Lil Tex seems more than a little lackluster. There’s less cleaning options, less automation, less cooking space. Just less of everything.
Hey Brad, you’ve got 3 great grills there. Rec Tec has the edge on Pellet quantity. I like the build quality and support on the Grilla a bit better, especially with the extra insulation and updated comp wheel set up. Figure 10 min or so to get to top temps. Just remember to drop to around 300 F temp setting before going into the shut down cycle on any pellet grill if you’re cranking it up to the highest setting.
You want longevity in a pellet grill: As the Traeger brand name has been around for a few decades, you can have some peace of mind that you’re purchasing a grill that should have replacement parts available for the foreseeable future. And Traeger grills tend to have good longevity ratings, working in top condition for several years, as long as you follow the manufacturer’s maintenance recommendations.
Grilla Grills are not only great with their puns, but also great with their products. Since we compiled a list of top 10, getting rid of this product from our review was a very difficult choice. Silverbac Pellet Grill, along with several others from our honorable mentions list, has been tied with our advanced pick. Therefore, we were forced to place this on our honorable mentions list. With its traditional barrel-shaped design and astounding colors, they’d look nice in your backyard should they be your top choice.
Similarly, online retailers like Amazon add to the cost of your products as well. When you order from Amazon the manufacturer has to pay a hefty fee to Amazon, even if the manufacturer of your grill ships it to you directly from their factory. So, while the grill may ship to you directly, Amazon usually takes around 15% of the total price, meaning that the manufacturer has to factor that cost into their margin as well.
A charcoal unit is going to provide a more powerful authentic smoke flavor when compared to a pellet smoker.Electric pellet smoker reviews show that gas smokers and pellet smokers are comparable in that they both can be set to a particular temperature and left alone. The one advantage that a pellet smoker has over a gas smoker is that with a pellet smoker, you can actually say that you are cooking with wood because the pellets are compressed wood.
You visited your friend’s house and saw his amazing pellet smoker. Now you want one. But you don’t want just any pellet smoker. You want the best pellet smoker that you can afford. Now, you could spend a lot of time reading hundreds of pellet smoker reviews, or you could spend a few minutes going over this comprehensive guide that we have prepared.
This unit will not let even a single pellet go to waste. No need of worrying whether you’re out of pellets or not. You can carry pellets at a maximum of 20 pounds, with the digital thermostat ensuring the pellets are being used properly. This saves you loads of cash and gives you smoking food simultaneously without wasting time in refilling pellets.
My Egg will last past my lifetime. And I have a lifetime warranty on it as well. I don’t want to plunk down good money(even $500 is good money if you think about it) to have a grill of no use in 5 years. I guess I’m looking for a do it all grill. Not that I need one to do it all, heck I can use my Old Smokey to grill up some mean steaks and burger and hotdogs if need be.
Up next to find its place in our pellet grill review is the REC TEC’s mini portable pellet grill. It has a 341 square inch cooking surface with 180 degrees to 550 degrees Fahrenheit temperature limit, with 5 degrees increment. But it can easily reach 600 degrees Fahrenheit in full mode. It has a satisfactory pellet hopper capacity and has folding legs. It is great for travel and movement as it is compact and small in size.
Who says bigger is always better? Our fourth contender to make it to our pellet grill review is the The Traeger TFB29LZA Junior elite grill. This petite pellet grill has been specifically designed to meet the needs of small households. Its small body makes it ideal for travelling and tailgating. It features a 300 square inch cooking surface. This pellet grill weighs just 60 pounds. You will get an LED digital, multi-position thermostat that comes with a 3 year warranty.
I do have a question for you that i didn’t already find answered… How important do you feel a pellet release option is for a pellet fed BBQ? I have only found 3 models that have it; Traeger, Cabela’s Pellet Grill, and Camp Chef. It seems to me that this would almost be a must to make things easier to clean up when done smoking. What are your thoughts on the pellet release, and then your thoughts on these 3 pellet grills.
You prefer a direct heat method of grilling: The Traeger grill uses an indirect heating source, much like an oven, so you won’t be able to sear meat, as many people like to do when grilling a steak. The Traeger system is better for those people seeking more of a smoker type of cooking system, although you can sear your meat by using a frying pan with a little oil initially before you finish cooking it with the Traeger grill. You can use the frying pan on a stove top burner or on the surface of the Traeger grill.
So far this smoker is fabulous! There is a learning curve, and this is not a "set it and forget it" smoker. You have to make sure you don't run out of pellets as the smoker will shut down. Tried a pork butt, but I wasn't watching it close enough, so I had to finish it in the oven. Still delicious. Next made some boneless skinless chicken breasts which turned out wonderfully.
So, I say go for the best pellet grill you can get within your budget. I reviewed the little GMG Davy Crockett pellet grill recently and was impressed. At just under $400, it’s a good option. That said, I would like to see them put the unit on fold down legs with casters or some other option to make it easier to move around. You’ll see what I mean in the post. Hope this helps.
The cleanout for both the pellets and ash is a huge perk to the grill. The patented “Easy Ash Cleanout” does not require the user to take apart the grill. Instead, they simply have to twist and dump the container. The 18lb pellet hopper is similarly an easy cleanout. The stainless steel also makes it easier to clean the grill because of the steel’s properties.
Ninth spot to make it to our compilation of the pellet grill review is the Louisiana pellet grill. It has 2 cooking levels and a total 1061 square inch cooking surface. The Louisiana pellet grill has got porcelain cast iron main grids and porcelain steel removable upper cooking grid. It also has a digital controller centre. This grill weighs around 173 pounds and is made with high quality material that is going to last you a life!
Now, jump ahead to my actually trying to get my Traeger replaced. Per the email, I called Traeger customer service expecting the same service I received right after Christmas. NOPE! I spoke with Frank (Carson) I believe. He did everything from accuse me of shutting my grill off and turning it back on incorrectly (impossible since I was in the house) to not cleaning my grill. Neither of which were correct. He basically made me feel like my grill was unsafe! His attitude was HORRIBLE! He was rude and condescending. A nightmare to work with!
I'm a certified BBQ Judge and found the following; The new portable Traeger Ranger seems to be not well thought out. All the cooking directions are for the large units and over cook everything in the smaller unit. All the pellet smoke is wasted, it is drawn out the back vent and very little ever reaches what you're cooking. They have a grease bucket on the back that is supposed to catch the grease but doesn't, Grease coats the inside of the bbq and runs down the sides and out of the grill landing on whatever you have the grill on. I've been using this Traeger Ranger since June 18, 2018.
Aside from durability, a well-built pellet grill has another significant advantage: It will perform better. High-quality materials and good construction allow the grill to retain heat better, making it more efficient and providing better pellet consumption, even in cold weather. Furthermore, it's unlikely that a brand offering a cheaply made grill invested much time designing it to maximize airflow or engineering a control board that can hold a tight temperature.
With the summer right around the corner, it’s about that time of the year that consumers are thinking about hosting outdoor picnics and having their friends and family in the backyard. Now, to make this year special, many people are flocking towards purchasing pellet grills. In efforts to assure our readers that each grill on today’s list is the absolute best, we performed an update on this buying guide. Included in this update, readers will get to learn about the criteria that we used to evaluate each grill and a list of answers to some commonly asked questions. Before the summer arrives, check out this update!
This is a great pellet smoker! With a few minor tweaks, this thing would be perfect. Ribs, brisket, chicken, pulled pork, sausage, you name it and it comes off of the grates awesome. I've had mine since 2012 and would recommend that you purchase a spare thermocouple in case your's bites the dust in the middle of a smoke (replaced my thermocouple twice since 2012). This thing is built solid with longevity as a guarantee. The customer support at Yoder is unbelievable as well. I have gotten phone calls from them at 8am on Sunday morning when my first thermocouple gave up in 2014. Made in the USA with a commitment on customer support that has been incomparable to anything I've ever purchased! It's a bit pricey compared to the competition but does an amazing job. "The Sauce", with Chef Tom, is a huge help for those just getting their feet wet in pellet smoking. He does an amazing job by keeping it simple and flavorful!
Hey Brad, you’ve got 3 great grills there. Rec Tec has the edge on Pellet quantity. I like the build quality and support on the Grilla a bit better, especially with the extra insulation and updated comp wheel set up. Figure 10 min or so to get to top temps. Just remember to drop to around 300 F temp setting before going into the shut down cycle on any pellet grill if you’re cranking it up to the highest setting.
So, we’re here to discuss the different cooking times and temperatures for different types of meat so that you don’t overcook or undercook your meal. But for the health concious, they should avoid certain meats. It’s worth noting that we’re here to discuss the temperatures needed for slow cooking and these should not be considered as universal standards for searing or grilling.
To start using the grill, pour wood pellets into a hopper (pellets are usually are made from compressed sawdust). Press the start button to ignite the pellets, which are fed into the fire box with an auger, where a controlled number of pellets are lit and burned (depending on the temperature setting selected). The auger adjusts the number of pellets entering the fire box to maintain the desired temperature.
-Warranty-(Forgive my soapbox here, folks.) I'd give it 5 stars if Camp Chef would give it a real warranty. One year is pathetic and WAY below the industry standard. Camp Chef, I know you are reading this because you guys are too excited about your great new product to not pay attention to feedback like this. Nut up and stand behind your awesome product. Why would anybody buy a product from an industry newcomer with no track record when you yourself are only willing to stand behind it for 1 lousy year?... Especially when the "industry leader" will guarantee their product for 3 years?!?! You are communicating that you have 1/3rd the amount of trust in your product that Traeger does. That's terrible! You should exceed what they are offering just to make the point in the industry! At a minimum, you should at least match their warranty just so it doesn't become a stumbling block to potential customers. Look, you basically took the lil tex and said "ok boys, so how can we make this better?!?" You did that! You totally knocked it out the park! Why cheap out with the warranty?!? As a customer, it makes me nervous that you know something I don't.
I had my Traeger grill now at least a week. Not really satisfied because every time I use it it does good for about a hour then it starts to cool down very quickly. Have to turn it off and start over and over again. This take all day to do this. I should not have to do this all day. Just a waste of pellets. Done wasted a whole bag of pellets. Called customer service. They tell me do the same thing. I think a grill should not do this. The meat I cook sometimes is not cooked. Have to start over again. All of this I have described take hrs. Have to stay outdoor to babysit. This grill should not have to do this. That tell me the grill is not good.
I have owned my YS640 for about 9 months now. Before I bought this I researched smokers/grills for about 2 years because I had very little experience with them & cooking in general. With the help of a few good websites I have produced some great food. There is a ton of room to cook on & the heat stays pretty much where you want it. Only a few issues I have had is that where the stack mounts to the side of the grill it drips. I did have a scratch on mine from the shipper & when I called about it I was sent a can of matching high temp paint very quickly. One thing that I like the most about this smoker is it is heavy. You can tell that this thing was built to last.
Before talking about its features, we need you to close your eyes and ask yourself these questions: Does it grill? Does it smoke? Can it ever replace a gas grill? Does it work like a charcoal grill? Now, open your eyes and listen to the answer: Yes. With GMG Daniel Boone’s motto “Think Everything”, you can be certain that it will provide the all-in-1 solution you seek.
Traeger's, unlike other models, have a temperature probe, these sensors tell it if the temperature is too low and automatically feeds more pellets to the fire. You can set up the temperature in 5-degree increments. Other brands and cheaper versions only offer three settings low, medium and high. There is no sensor to monitor the temperature. If you are purchasing a pellet grill it is because you can set it and forget it. If you plan to hoover then it makes more sense to use a standard smoker or to transform your grill into a smoker.
When starting on a grilling project, it’s important to know at what temperatures should a food be allowed to settle inside a pellet grill before it reaches its desired doneness. Of course, the time it spends on the grill also plays a major role in it, but you have to understand that cooking on a high heat for long time periods can leave the meat charred while on a low heat can turn it into soft and mushy.
When buying an item as important as a grill, it is evident that an individual should look for the best quality for what they desire as well as learn properly what are the best in the industry. With that in mind, pellet grills are even more unique than a regular grill because of the design and the way the grill functions. With that said, the quality of a pellet grill is the first criteria we took into consideration because there is a slew of different elements that have to ensure the grill is made of the best possible quality design. With that in mind, one important aspect of quality design that we took into consideration is how all of the functions are built. Meaning, we wanted to make sure that no area was designed and manufactured in a cheap way. Other than that, one method in which we figured out the best quality grills is how the grill cooked and how the items tasted. However, since we cannot buy every single grill and spend weeks cooking steaks and vegetables, as nice as that sounds, we relied a lot on individual reviews and what people had to say about that particular grill.
Thanks for all the great information. This article was very useful on my most recent purchase. Sorry for the long book but tends to be my style of sharing. Hope others get some use out of my lessons learned. Killing (literally, dried out, burned, inedible) a thousand dollars or so of briskets over the last 20+ years should help some save a little pain as they are stepping out.
Hey Pete, first thanks for your kind words. Traeger pellet grills fell off a bit quality wise over the past several years. That said, they’ve hired a new CEO – formerly from the Skull Candy Head Phone company – who brought that company’s valuation up considerably. I see them making moves to get back to their roots… aligning themselves with some of the more well known names in BBQ again. From a build quality, they’re making solid pellet grill bodies using fairly heavy steel. The area I’d like to see them improve on is the controllers they use. Right now, GMG is making great strides in claiming some of the entry level pellet smoker market share away from Traeger. This is due to a superior PID controller, advances in built in Wi-Fi monitoring, and outstanding customer service.
While using and running a pellet grill is child’s play, catching the right offer on pellet grills can be a hassle for consumers who have little to know clue about it can prove a costly bargain. Knowing your facts prior to buying one is always a good a smart idea. My pellet grill review will do the best it can to educate you on the things you need to look out for when purchasing your perfect grill. Here are a few heads-up:
This is the right choice for anyone that likes smokey flavors and cooking slow at home. It is my first experience with a pellet grill and I have read and studied them for a while. I was looking for a outdoor cooking solution that would give me the ability to cook like the pros without the super sized trailer. Finally deciding to go with the Camp Chef I haven't been disappointed. The temperature control is flawless so you can dial down the cooking process. I smoked chicken the other day and the red smoke ring was a 1/2" deep. It works like a convection oven so there are no cool or hot zones, it just keeps the heat even and consistent. I have noticed even if smoke isn't pouring out the wood flavors are present.
If you get it that BBQ is more than burning hotdogs on a propane grill, you could likely benefit from The BBQ Beat podcasts. Kevin interviews the best Pitmasters in the country. They share their knowledge, stories, and experiences. There is something to be learned in each podcast. So if you're serious about your bbq, check out these podcasts. They are time well spent.
Wattage – With the right amount of wattage by your side, you will easily reach the temperature required, and it will stay there provided that you are providing enough pellets for it to make use of. Anything north of 1200W will easily be able to cover all your requirements, but as a rule, it’s ideal to be sheltered than sorry, so it can’t hurt to purchase a unit with a bigger Wattage than you might suspect you’ll require.
For beginner outdoors chefs and guys buying their first smoker, that’s an invaluable bit of knowledge. Knowing that no matter what you do, as long as you follow the standard set up, you’re going to produce professional quality meat with ease, which is why smokers like the ones below are the best choice for anyone looking at buying their first pellet smoker.
Personal review of the Traeger: The auger fed the pellets after the fire pot went out making a large pile up which caused it to catch fire and burn up my grill. I had to use a fire extinguisher to put out the flames and prevent my house from catching fire. I sent Traeger the description of damages with photos. After much waiting and no response from the management team regarding my Traeger grill we gave up. The service team was very responsive but lacked any authority to make decisions to fix the grill. We worked with the service team for awhile having a different person each time respond and request information and photos that were already provided. Then, we got passed up to the management which is highly ineffective because we never heard from them, even after an email requesting an update. We really did like our Traeger grill and had high hopes that since it was under warranty and caught fire due to a failure we would have the grill repaired. Because of the terrible unresponsive service of Traeger we took our money and purchase a Green Mountain Grill.
I've been BBQing and pit smoking for many years. About 4 yrs ago I tried out pellet grilling with an import brand, and had to rebuild and replace parts for 3 yrs until it was no longer worth it! I started looking at the YS640 about a year ago, and finally pulled the trigger on buying one. No gimmicks, No hype, this is the finest backyard pellet grill/smoker and wood fired sear machine on the market. The YS640 would also be right at home on the competition circuit as well. As many other reviews have stated, if your thinking about buying one, just do it. You will not be disappointed. Shes built like a tank and holds temp very consistently. From start to finish the staff at ATBBQ has been outstanding and professional, the unit arrived in only 1-1/2 weeks and was packaged securely on a pallet. Great American made product, and great customer service have made this one of the best purchases we've made in years, Thank you.
Pit Boss Wood Pellet Grills are filled by all regular BBQ wood pellets. The computerized control board lights the grill and permits you to set the cooking temperature from 180° to 500°F. Fan constrained convection cooking takes out the requirement for a rotisserie and makes an adaptable situation for grilling, simmering, smoking, braising and preparing. The Pit Boss 340 has 340 sq. in. total cooking surface with porcelain covered cooking grids. With complete structural quality and strength, the Pit Boss 340 is made to last.
Camp Chef has already been mentioned several times on this list. It's a venerable company that makes up in quality what it lacks in the name recognition of a Traeger or Weber. Their Deluxe Pellet Grill is built to reach and hold ideal temperatures for smoking. An internal system syncs pellet delivery to temperature instead of simply feeding in fuel when it begins to run out. This ensures a clean, consistent cooking experience. A removable ash can makes clean-up a snap as well.
Dealers are happily selling these while Traeger is aware per 1-800 call that they need to replace thousands of drip pans/heat exchangers on units that have been shipped because the ones in the units shipped allow heat to fluctuate widely. Traeger recommended NOT USING THIS BRAND NEW GRILL until I receive the replacement part which they will not receive until the last part of August and they will not commit to expedited shipping when they finally ship.
A few other mentionable features are that it has a highly durable temperature proof textures powder coat finish, it features auto start. The REC TEC Wood Pellet Grill accommodates temperatures from 180 degrees Fahrenheit to 500 degrees Fahrenheit with 5 degrees increment. This amazing temperature control features let you be in control of how much heat you want to cook your food in, without having to worry about it getting dry or burnt. This low increment allows you to cook delicate meats like fishes and seafood as well! It smart grill tech makes sure that the temperature you set is always consistent and constant. It also has an “Extreme” smoke feature from the 180 to 250 degrees Fahrenheit setting that intensifies the smoke in the grill.
We have reviewed the best pellet smokers on the market today after doing our extensive comparative research. However, there were some hidden gems that could not make it to our top 10 product list because of one reason or another e.g. due to their high prices, unavailabilities in some regions, and other factors. Also, some just failed to get in our top 10 list only because it was a top 10 list and not a top 20 list. Regardless of the reasons, here are a few honorable mentions that failed to make it to this top 10 best pellet smoker review, but are still worthy in their own rights:
My wife and I purchased this over the weekend. Been wanting this grill for a while. $349.99 includes cookbook, 3 years warranty +costco visa warranty. They also had the lil tex and the other bigger grills at reasonable prices. Links are for the locations for their "roadshow" in order to capture the prices. Technically doesn't come with the cover but I convinced the rep to throw one in.
As a new and nervous cook or just a busy one, it is always a struggle to get the results you want without having to tend to a grill or stovetop all day long. Luckily, Pellet Grills offer a convenient solution. These foolproof devices allow you to truly set it and forget it. Whether you crave perfectly grilled spare ribs or smoked pork butt, Pellet Grills allow you an unprecedented degree of control over the temperature and cooking style you want. What’s more, Pellet Grills are a terrific way to infuse your food with the real flavor of wood smoke, whether it be hickory, mesquite or maple. Unlike gas grills, the flavor is right there in the fuel with wood-pellet grills.
Traeger invented the original wood-fired grill over 25 years ago in Mt. Angel, Oregon, and continues to lead the industry as the worlds #1 selling wood-fired grill, perfected by decades of mastering the craft of wood-fired cooking. Fueled by 100% pure hardwood pellets and controlled with a digital controller, means from low and slow to hot and fast grilling, you'll fire up deliciously consistent results every single time. The Texas Elite 34 packs a huge punch with 646 sq. in. of grilling area, new wider legs for added stability, and an upgraded Digital Elite Controller. It combines powerful, wood-fired convection performance with simple operation. So invite the neighbors and taste the wood-fired difference.
PG24 by Camp Chef is the best choice for any expert smoker. Its reasonable price and amazing features make it a good prolonged investment. It comes with lots of nifty features that facilitate, smoking, grilling and searing in your backyard. For all these reasons, in our pellet smoker review, we consider this smoker as the top choice for the serious BBQ buffs.
Their behavior is sometimes counterintuitive. The hotter they get, the less smoke they produce, and at their top settings, they don't produce much smoke at all. This is good for when you are baking cakes or pies or doing dishes that don't need smoke. But down under 250°F, they produce plenty of mild, elegant smoke. And even though the fuel is wood, it is hard to oversmoke with a pellet smoker. Burning wood on a charcoal grill produces much more intense smoke flavor.
Many people misunderstand a pellet grill of consuming a large amount of power for its working. But it is not even remotely true. While it is true that a pellet grill will use up a good amount for power initially, but it only uses that to come to temperature and form. Once it is ready and in form, it power consumption drops so dramatically that some pellet grills use almost as little power as a light bulb; an ideal choice for keeping power costs to a minimum.
The Rainier is also hearty as hell. It survived banging around in the bed of my truck for four years. And I didn’t exactly baby it, cramming it into the limited storage space in my truck with paddles, helmets, and all manner of gear. But I never worried that it wouldn’t fire up to cook another meal. Once, one of the stubby rubber legs popped off as I was pulling the Rainier out of my truck. The stove sat crooked for a weekend, but I eventually found the leg and simply screwed it back on.
Another pellet smoker from industry leaders Traeger. The Lil Tex Elite is an upscaled Junior Elite, and whilst it’s still a good quality smoker and grill with a powerful burner and excellent heat output, plus all of Traeger’s usual electronic gizmos. There’s just not enough of a difference between this and the Junior Elite, especially not when you consider the increased price tag, which is disappointing.
Joe Traeger designed and developed pellet grills back in 1985 and he patented the design one year after. But these didn’t go into full commercial production until 1988. Because of the patented design, Traeger held a monopoly in the pellet grill market for twenty years. But being a small family-run company, they did not diversify and kept supplying their products only to a select network of stores.
Bought a Traeger Timberline 850. A lot of money but it's a great smoker. It has WiFire so you can cook based on their recipes right from your iPhone. The problem is with their recipes that aren't built into their app. Nobody proofreads the things so many of them are useless. Just one example - Santa Maria Tri-Tip: smoke for 4-5 hours. At what temperature? 165 F, 250 F, or 500 F? It makes a bit of a difference ! I suspect they pay people to write, and post recipes so the can say they have thousands of (what are actually useless) recipes.
My brother said his Traeger blanket saved pellets in cold weather, so after talking to him I decided to order one. Used it for the first time today. The blanket went on easily & fit the grill perfectly. The temps this a.m. was below 0 when the meat started smoking. So far so good! The grill hasn't extinguished itself, a problem we always had when cooking in the cold, the temp of the grill is cooking like it does in the summer, & the meat is smoking beautifully. If you Traeger in cold winters this accessory is a must have!
In 1982 Traeger Heating in Oregon began experimenting with a furnace that would burn wood pellets made from compressed sawdust, a byproduct of the area lumber mills, and before long introduced a home heating system that they sold mostly locally. Since furnaces sold mostly in cold months, before long they began experimenting with a grill that would burn pellets, too. Eventually they created a device with an auger to feed the pellets and a blower to help them burn.
The Ortech has two knobs. The large one, the "Cook Control" has settings for: Off, Smoke, 180, 225, 250, 275, 300, 325, 350, 375, and High. One smoker manufacturer says that the "Smoke" setting is about 160°F and "high" is about 525°F, but both can vary due to ambient temperature, humidity, fuel type and quality of the smoker. Another knob, a teensy weensy knob to the right of the LED screen looks more like a push button. Labeled "SMOKE" and called the "Smoke Control Knob", it is meant to turn, not push, and it controls the pellet feed rate with auger on/off sequences indicated by "P settings". The P settings range from P0 to P15.
WOW, that’s all I got. What an amazing piece of cooking equipment. I’ve owned mine now for a little over a year, and to be honest, each time I use it, I learn something new about it. I’ve cooked on Traeger’s and owned several Bradley smokers. But nothing compares to the versatility of the Yoder. This thing is well made (its heavy) and it cooks flawlessly. The worst thing about it is the need to empty the ashes, and it’s not that big of a deal. I will say, invest the money and buy the heat diffuser with the access door. It makes removing the ashes so much easier. Ask yourself this question, how many different flavors of propane can you use on your grill. Because with all of the different wood options for this, it’s almost limitless. Make the investment, you won’t be sorry
Hi – my husband and I are really interested in a pellet smoker. We came across some when we were at a fair and are trying to find more information about the Traeger brand because the price seems affordable compared to all the others you mentioned. You started out talking about the Traeger but never gave any feedback on it? Little help please:) Thanks!
However, with a pellet smoker, you can ensure that new pellets are being fed into the fire automatically, ensuring that it burns for longer and while it burns, it imparts with its flavors. It doesn’t need to be soaked and fed into a burning pile of coal to work. Above that, sawdust, when separated by the heat and being burned, gets a larger surface area to burn with and thus sends out a bigger burst of flavor per pellet.
Use of the P settings in smoke mode is easy to understand. But one can also use them as a dual function feature in cook mode. Remember, in cook mode the auger idles when the temperature is correct, but the P settings continue to function in idle mode. Ortech recommends the P2 setting as the default idle rate in cook mode. However, as one gains experience, the P settings can be used to improve the grills performance. For example, when using high temperature settings, select P1 or P0 to reduce auger off time and maintain strong, steady heat. If you have trouble hitting low temperatures on a sweltering day, increase the P setting to increase auger off time. It does not have a significant effect on smoke production. The basic rule remains: Low heat = more smoke, high heat = less smoke.
Decided that moving these beasts was a little challenging so I bought a Backwoods Party 10 years ago and loved it. But basically have about worn it out. And as I got older I don’t enjoy getting up at 2 AM and then having to get up every couple of hours, after the 45 minutes of getting it ready at 2 AM, to check it and feed it. I also bought a smaller lightly used Open Range, The Good One. Used their recommended method the first time I cooked with it and hated the Q off of it so bad most of it was wasted, wife hated it too and the son ate most of it. It was extremely ash/strong smoke flavored!