Hey Todd – what pellet grill do you have? Also, by short cooks, how long are you talking? Have you looked at the burn pot? If it’s overfilled, you may need to vacuum it out, along with the interior of the cooker. Then, put 10 or so pellets into the burn pot and start it up again. See if that helps. There should not be much if any ash in the food chamber area or on the food. At least not in my experience.
The first thing you notice about yoders its the quality! They are testosterone, precision, heavy duty machines. Yoders cut the learning curve from novice to celebrated cook in less than a year, because they allow you to focus on the cooking instead of tending the fire which can take you lots of time. The only issue I have with mine is that the fan vibrates inside making a wierd noise, so I have to open the cooker and re-atach or re-instal the velcro strap that keeps the fan from vibrating. If this works, I will return to edit my review to 5x3 stars. However, the support team sent me everything I need to conduct the process my self; no complains here.
If you live in an area where wood furnaces are used (not like down here in FL where a few heat strips will do the trick), you may also be familiar with pellet furnaces. In short, pellets compressed from sawdust and wood shavings fill a hopper and are then fed into a burn pot using an electric auger system. The auger, which is basically a long screw, delivers pellets to the burn pot based on the speed dictated by the unit’s thermostat.
Now comes the best part about pellet smokers: they can conveniently do all these three. Coming with a large cooking space and a lid, the top rated pellet smokers would allow you to keep them open or closed, depending on what results you are looking for. With a dedicated space for putting your charcoal, you can use it as a charcoal grill, smoker or a barbecue. Or you can use it like a kitchen oven using the direct fire from the firepot. Finally, it does what it was made for – pellet smoking. Using small hardwood pellets running over the firepot in a corner, this smoker uses a fan to distribute the heat and smoke throughout the grilling area. This indirect heat ensures that the food is slow-cooked and smoked over long periods of time.
PG24 by Camp Chef Pellet Grill also brings along a digital controller which you could use to set your desired temperature and at one point the heat in the chamber will be automatically adjusted. It allows meat to be smoked for hours at a temperature of 150 degrees F. You could increase temperature to 500 degrees F for searing and grilling. With convection, the cold and hot areas of the grill can be replaced with even heat.
One of the fun features this grill offers is that it’s WIFI enabled (controlled or monitored through an iOS or Android app). Sense-Mate, a thermal sense that constantly monitors the grill temperature, keeps you up to date on the status of your grill and your food! The digital controlling really lets you micro-manage your cooking, as you can adjust it a degree at a time. You can also program a series of temperatures and then sit back and enjoy your day while your food cooks! (Yes, you can also control it manually as well.)

The small burn pot is covered with a large deflector plate that absorbs the heat and spreads it out below the cooking surface making them essentially wood-fired convection ovens. Flare-ups are a thing of the past. You need to keep the plate clean because it is right below the food and if you leave sauce and grease on there, it can smolder and leave soot on your food. Carbon buildup will also diminish its heat transmission.
So back to the Internet for one last attempt on making a decision on the smoker that is of great quality and can also fill my need grilling needs as well. I am almost sold on the Rec Tec, but I’m curious about the Grilla Grill Silverbac. It’s a little smaller than RT and metal is a gauge off from the RT. It doesn’t run off a PID system but a digital controller and is priced at $699. I do like the underneath storage of the Grilla and the second tier cooking grates.
Pellets are made from different woods, each of which imparts a distinctive flavor to the meat. Hickory, oak, maple, alder, apple, cherry, hazelnut, peach, and mesquite are among the flavors available. For more about pellets, read my article, The Science of Wood. There is a pretty good forum for people who have pellet cookers at PelletSmoking.com and of course our Pitmaster Club has a lively discussion on them with many active users.
Overall, I think you would be happy with the smaller smoker / grill. I really like what Green Mountain grills has done with the Davy Crockett model, and that is the unit I have personally. That said,Rec-Tec makes a great product, and some people prefer the cart stand it comes with rather than the fold up legs that Green Mountain grills uses on the Davy Crockett modeling. Either choice would be good for you if you are looking for a smaller unit. I am of course speaking about the mini version of the Rec-Tec. The larger version is excellent as well.
!function(e){function n(t){if(r[t])return r[t].exports;var i=r[t]={i:t,l:!1,exports:{}};return e[t].call(i.exports,i,i.exports,n),i.l=!0,i.exports}var t=window.webpackJsonp;window.webpackJsonp=function(n,r,o){for(var s,a,l=0,u=[];l1)for(var t=1;tf)return!1;if(h>c)return!1;var e=window.require.hasModule("shared/browser")&&window.require("shared/browser");return!e||!e.opera}function a(){var e=o(d);d=[],0!==e.length&&u("/ajax/log_errors_3RD_PARTY_POST",{errors:JSON.stringify(e)})}var l=t("./third_party/tracekit.js"),u=t("./shared/basicrpc.js").rpc;l.remoteFetching=!1,l.collectWindowErrors=!0,l.report.subscribe(r);var c=10,f=window.Q&&window.Q.errorSamplingRate||1,d=[],h=0,p=i(a,1e3),m=window.console&&!(window.NODE_JS&&window.UNIT_TEST);n.report=function(e){try{m&&console.error(e.stack||e),l.report(e)}catch(e){}};var w=function(e,n,t){r({name:n,message:t,source:e,stack:l.computeStackTrace.ofCaller().stack||[]}),m&&console.error(t)};n.logJsError=w.bind(null,"js"),n.logMobileJsError=w.bind(null,"mobile_js")},"./shared/globals.js":function(e,n,t){var r=t("./shared/links.js");(window.Q=window.Q||{}).openUrl=function(e,n){var t=e.href;return r.linkClicked(t,n),window.open(t).opener=null,!1}},"./shared/links.js":function(e,n){var t=[];n.onLinkClick=function(e){t.push(e)},n.linkClicked=function(e,n){for(var r=0;r>>0;if("function"!=typeof e)throw new TypeError;for(arguments.length>1&&(t=n),r=0;r>>0,r=arguments.length>=2?arguments[1]:void 0,i=0;i>>0;if(0===i)return-1;var o=+n||0;if(Math.abs(o)===Infinity&&(o=0),o>=i)return-1;for(t=Math.max(o>=0?o:i-Math.abs(o),0);t>>0;if("function"!=typeof e)throw new TypeError(e+" is not a function");for(arguments.length>1&&(t=n),r=0;r>>0;if("function"!=typeof e)throw new TypeError(e+" is not a function");for(arguments.length>1&&(t=n),r=new Array(s),i=0;i>>0;if("function"!=typeof e)throw new TypeError;for(var r=[],i=arguments.length>=2?arguments[1]:void 0,o=0;o>>0,i=0;if(2==arguments.length)n=arguments[1];else{for(;i=r)throw new TypeError("Reduce of empty array with no initial value");n=t[i++]}for(;i>>0;if(0===i)return-1;for(n=i-1,arguments.length>1&&(n=Number(arguments[1]),n!=n?n=0:0!==n&&n!=1/0&&n!=-1/0&&(n=(n>0||-1)*Math.floor(Math.abs(n)))),t=n>=0?Math.min(n,i-1):i-Math.abs(n);t>=0;t--)if(t in r&&r[t]===e)return t;return-1};t(Array.prototype,"lastIndexOf",c)}if(!Array.prototype.includes){var f=function(e){"use strict";if(null==this)throw new TypeError("Array.prototype.includes called on null or undefined");var n=Object(this),t=parseInt(n.length,10)||0;if(0===t)return!1;var r,i=parseInt(arguments[1],10)||0;i>=0?r=i:(r=t+i)<0&&(r=0);for(var o;r
In the second year, the grill quit working. The auger turns and the heating rod gets hot but the grill shuts itself off within minutes. I think it is the controller but I've had the same experience as others: emails and phone calls to Traeger's customer service are unanswered. My wife just wants to return it to Costco but I'd rather fix it. Given the lack of response and the poor quality of the electronics, I'm starting to come around to my wife's point of view.
If you’re gonna set it and leave it to do the magic, you’re going to have to be careful, too. A major contributor to how long you can leave a smoker is how many wood pellets the pellet hopper holds. Pellet smokers run the gamut in how much fuel they use per hour, with anywhere from half a pound to two pounds of pellets being standard. Always check how much the model you’re looking at holds, and make sure that it’s going to last long enough, especially if you plan on leaving your smoker to cook whilst you do other things, especially if you’re going away from home. It’s simple math, and better that than coming home to a bunch of chargrilled ashes.

In addition to providing savings, using an oak base also creates consistency. Different types of wood have different densities, burn at different rates, and produce different amounts of heat and smoke. For instance, cherry burns faster than hickory, so using 100% cherry you’d go through more pellets than if using 100% hickory. The addition of oak allows every flavor to burn at a similar rate and with a similar heat output, providing consistency from cook to cook.
I’ve been grilling and smoking for many years and throughout all those years I have burned through many expensive grills. Four years before I purchased the 640 I got on the pellet smoker wagon and started my research. Finally when my daughter was getting married she ask me to cook for the wedding and gave me the perfect excuse to finally get a smoker I wanted. So getting back to the research and after 3 months of comparing I settled on the YS640. I wanted a grill, at my age, to be able to pass down to one of my kids. It was big investment but like I’ve learned in life, you get what you pay for “most” of the time. I have had this grill now, September 2018, will be 4years now. I have no regrets and would do it again. I’ve had some minor corrosion issues and after an email was promptly sent the matching paint to clean it up. I spent the time to do it right and today, a month later, today my grill looks brand new. Honestly nothing like this can be left to take care of itself. Maintenance like anything else is required. But I know this will most likely be my last grill. Thank for a great product and great follow up service. Smoke Shack.....
The flame broiler uses a digitally controlled burn system. Its Digital Control Center lets you set the temperature ranging from 170F to 600F with ease. The desired temperature is set and maintained through an electric auto-start and fan-forced air mechanism. These, in addition, give that flavorful smoky taste to all of your foods. The auger automatically feeds pellets into the smoker, so you can pretty much let it take care of everything.
Does anyone know how to set up a pellet grill? Since pellet grills are a bit less common than a regular conventional gas grill, we had to conduct a bit of research and realized that pellet grills are as easy to set up, they just have more components. The components of the grill include a lid, which is designed to cover the contents of the grill as well as keep the heat in. Other than that, the ‘hopper’ is known as the area of the grill where an individual places the wood pellets and the grill drips the pellets onto the fire to keep the heat going.
One of the most outstanding features of this smoker is its digital thermostat controller. It is also small enough to be used for family gatherings but large enough to be used for tailgating parties. With it’s 292 in.² of cooking space, you can cook a lot at one time. The entire cooking surface is 15 x 20″. It is made from steel and has a porcelain coated grilling grate.

Just finished my first smoke on the YS640, ribs and chicken thighs. This machine is amazing. It couldn't be simpler to use. The chicken was the best I have ever tasted. The ATBBQ team was great, with fast shipping and they threw in some extras. I could not be happier and can't wait for years of great food off the YS640. Don't hesitate to buy this cooker or to order from ATBBQ.


If you get it that BBQ is more than burning hotdogs on a propane grill, you could likely benefit from The BBQ Beat podcasts. Kevin interviews the best Pitmasters in the country. They share their knowledge, stories, and experiences. There is something to be learned in each podcast. So if you're serious about your bbq, check out these podcasts. They are time well spent.

With over 375 reviews, this product had an impressive review rate. On its first 22 days, it got its first 10 positive reviews. Ten days after, it got its 2nd set of 10 positive reviews, and its 3rd set of 10 positive reviews after seventeen days. Online reviews have shown that, just like us, customers have been satisfied with the overall performance of this smoker from Traeger.

Vista Outdoor is a leading global designer, manufacturer and marketer of consumer products in the growing outdoor sports and recreation markets. The company operates in two segments, Shooting Sports and Outdoor Products, and has a portfolio of well-recognized brands that provides consumers with a wide range of performance-driven, high-quality and innovative products for individual outdoor recreational pursuits. Vista Outdoor products are sold at leading retailers and distributors across North America and worldwide. Vista Outdoor is headquartered in Utah and has manufacturing operations and facilities in 13 U.S. States, Canada, Mexico and Puerto Rico along with international customer service, sales and sourcing operations in Asia, Australia, Canada, Europe and New Zealand. For news and information, visit www.vistaoutdoor.com or follow us on Twitter @VistaOutdoorInc and Facebook at www.facebook.com/vistaoutdoor.
Editor-in-Chief Sean McCoy is a life-long outdoorsman who grew up hunting and fishing central Wisconsin forests and lakes. He joined GearJunkie after a 10-year stint as a newspaperman in the Caribbean, where he learned sailing and wooden-boat repair. Based in GearJunkie's Denver office, McCoy is an avid trail runner, camper, hunter, angler, mountain biker, skier, and beer tester.
Pit Boss Wood Pellet Grills are filled by all regular BBQ wood pellets. The computerized control board lights the grill and permits you to set the cooking temperature from 180° to 500°F. Fan constrained convection cooking takes out the requirement for a rotisserie and makes an adaptable situation for grilling, simmering, smoking, braising and preparing. The Pit Boss 340 has 340 sq. in. total cooking surface with porcelain covered cooking grids. With complete structural quality and strength, the Pit Boss 340 is made to last.
This unit will not let even a single pellet go to waste. No need of worrying whether you’re out of pellets or not. You can carry pellets at a maximum of 20 pounds, with the digital thermostat ensuring the pellets are being used properly. This saves you loads of cash and gives you smoking food simultaneously without wasting time in refilling pellets.
Most old-timers will tell you that a buildup of soot and grease will improve the taste of your food. This does not prove true, in fact, it’s not good for you and can even be dangerous. At Grills Forever we want your grilling experience to be the best and safe. Therefore, before any cooking session, always clean your grill to optimize its performance and prevent any off-flavors. Check the grease pans or collectors before smoking because the collector could be full and overflow, starting a fire. If there is a grease chute then clean it for sure.
love your article and got lots of good info from it….i do have a question tho that i didnt see an answer to…..do pellet grills have to use just pellets?….i have 3 acres full of oak branches that could be shredded. my question is can a pellet grill use home shredded wood chips to burn and cook with or is it mandatory that the fuel be in the pellet state?….would be great if i could find a good use for all these fallen branches….
The MoJack has huge barrel with lots of cooking space. With the 24 inch model, you are going to have 418 in.² to cook on. You will easily be able to read and monitor the temperature with the LED digital temperature control. This model has a bottom storage rack, which makes a great place for you to put extra pellets or tools that you will use for cooking.
Yo, Kevin! Hope that you can soon review one of my all-time favorite purchases, the Traeger Li’l Tex Elite Smoker/Grill. After using it for a couple of months, I gave away my two year old gas-grill to my grandson. We’ve done chicken, turkey, pheasant, lamb, all kinds of beef, pork and sausages including some wonderful ribs and brisket. Our Easter Rib Roast turned out terrific as did the chunks of assorted sausages that we did for another family get-together. I was never a big fan of grilling until we got our Traeger. Both Traeger and the web-sites like yours are full of great recipes and ideas.
Hey Oscar, based on what I think and my discussion with my buddy Shane Draper of Draper’s BBQ, you’ll probably only need to run 14 hours for a brisket cook – given the convection nature of your pellet grill. You’ll probably go about 1 lb per hour or a little less – depending on the weather and other variables you mentioned. Again, pellet cooking is a little bit give and take where you’re getting ease and a more set it and forget it cook experience in exchange for some additional fuel use.
Although I marked price high. I would buy it again, tomorrow. I was a novice. I had never smoked anything when I bought this. It is amazing and if you asked my friends and family I should have opened a bar & grill. It's grills better than any gas grill u can buy. The YS640 only gets better with time you get good at using it. It's the best cooker on earth. If your considering paying over $800 for a cooker. Spend the money... you will not regret it. My cousins have Traegers.. and they smeared by them. One weekend at my cabin one has ordered his the other don't have the money yet. I have used it a minimum of 2 days a week and have already got my money out of it by not ruining meat. The guys at Yoder have a monopoly. No one makes a cooker that could stand up to it. THANK YOU YODER. YOU HAVE MADE SOME GREAT HOLIDAY MEMORIES FOR ME AND MY FAMILY. Remember if your on the borderline don't know if it's worth a little more. By the 12th month of owning it. You will look at your wife or girlfriend and say "I'm so glad I spent a little extra and got that. It's beautiful.
Brought it home and set it on my prep table with the controller in a cubby hole with all intentions of building a cart for it later. So I have made a killer rib eye on it and tried to burn it down with a couple rib eyes cooking at 600 F. Gotta figure out a little better method of catching drippings as they will catch on fire and you have a runaway! But you can make a great rib eye. Ribs, every set has turned out awesome, everything from low and slow to a high temp cook process on them. Probably made 8 racks of great ribs. Wasn’t impressed with the hamburgers on it but will try again later. Made a pretty good brisket but used Rudy’s rub as I like their store sandwiches and I don’t have the method down. Next one will be back to salt and a touch of pepper. Chicken thighs (thighs are the perfect chicken part for Q, their rather uniform thickness makes getting them all consistent and cooked even a slam dunk) with a light coat of mustard and Tony Chachere’s lightly sprinkled is to die for. Simply squeeze them when they should be close and if the juice is clear, no pink or red they are perfect. If you cook the juice out, well they make decent tasting blotter paper 🙁 Pretty much killed a spatchcocked turkey for Thanksgiving, good thing the wife made an over baked one too. It did make great gumbo though as does the blotter paper chicken if you ruin any thighs or the whatever chicken. Also have a pile of hot links I put on at 180 for 2 to 3 hours. They are great for reheat with sauerkraut and roasted pabs or in the gumbo. Hot links should be a staple, ha ha! Gotta try my great pulled pork on it and we do Prudhomme pizza sauce on a Brown Eyed Baker crust and this Pro should rock it!
I say almost idiot proof because I still make stupid mistakes when I'm cooking and I like to blame it on the pellet grill once in a while. The unit is extremely easy to use for a novice such as myself. I just fill the hopper with my favorite wood pellets, set the temperature and add my food. I have owned this unit a little over a year and everything from the first burger I cooked until the smoked pork chops I just had for dinner has turned out really, really well. I find myself wanting to either smoke or direct grill everything. We have cooked pizza, turkey breasts, tri-tips, pork butts, burgers, salmon, cookies, brownies, chicken wings, drum sticks, pork chops, ribs, cornbread, vegetables, meatloaf and many other things. Nobody ever complains. LOL I have used it in all types of weather all year long. Once I learned how to use the damper (didn't take long) the heat stays where I want it and remains relatively stable even on the coldest days. I would buy this unit again and I would recommend it to others.

Typically, most portable grills would give up certain features just to maintain their portability, but this wood pellet grill from Traeger actually had more than what other top grills have to offer. Out of all of our features, it managed to tick 85% off the review. Its digital controls, versatile cooking features, and decent cooking space (perfect for outdoor adventures) all make it our best portable pick.
My wife and I purchased this over the weekend. Been wanting this grill for a while. $349.99 includes cookbook, 3 years warranty +costco visa warranty. They also had the lil tex and the other bigger grills at reasonable prices. Links are for the locations for their "roadshow" in order to capture the prices. Technically doesn't come with the cover but I convinced the rep to throw one in.
Thank you all for a great site and an informative discussion. I am a newbie to smoking and presently have a charcoal grill for when I have more time and a gas grill for a fast meal. Its time to replace my gas grill so I am looking at alternative options. Is a pellet grill overkill, or a timely expedition, if I want to grill a couple steaks or chicken breasts during week nights? I’d also be interested in smoking larger hunks of meat (and ribs!) less often, but am wondering if a pellet grill can cover both? How long does it take a pellet grill to get to temp (e.g. 450°)? With the indirect heat, can you get char marks on your meat? Thanks in advance for the info!

The smart-smoke technology in this grill uses an automatic electric feed system that is able to maintain a constant temperature from 180 to 450 degrees and has a hopper that can hold up to 20 pounds of pellets for extended cooking time. The digital control also handles igniting the pellets while fan-forced convection results in even cooking all around, much like rotisserie-cooked foods.


Hey Tom! First, thank you so much for commenting on this article. I hope it’s proved useful to you and helping you make your pellet smoker buying decision. I took a look at the smokers you mentioned in your comment, and they appear to be similar in build to those made by Yoder. I can verify that Yoder does exceptionally good work with both the build quality and the heavy gauge steel Construction of their smokers. I don’t know much about the manufacturing practices of the smokers you mentioned. I do like the fact that their controller automatically dropped down to a warming temperature after your food reaches the programmed temperature setting. That’s a feature that I’ve only seen in higher-priced pellet grills like the Memphis Pro Series that I talk about in this article. However, more grills are starting to utilize this in the programming aspect of their controllers. In any case it’s a great feature. To be honest with you I’m not sure that the auger mechanics are going to be all that different between smokers. I’m sure there are differences, but I don’t feel that they are dramatic enough to offer a distinct selling Advantage for the manufacturer. If you haven’t looked at them yet, you might consider taking a look at the Traeger Pro Series pellet grills. You can’t find it on Amazon, but you can find them at different retailers listed on the main Traeger site. A friend of mine has one major competitions using the pro series models.
Personal review of the Traeger: The auger fed the pellets after the fire pot went out making a large pile up which caused it to catch fire and burn up my grill. I had to use a fire extinguisher to put out the flames and prevent my house from catching fire. I sent Traeger the description of damages with photos. After much waiting and no response from the management team regarding my Traeger grill we gave up. The service team was very responsive but lacked any authority to make decisions to fix the grill. We worked with the service team for awhile having a different person each time respond and request information and photos that were already provided. Then, we got passed up to the management which is highly ineffective because we never heard from them, even after an email requesting an update. We really did like our Traeger grill and had high hopes that since it was under warranty and caught fire due to a failure we would have the grill repaired. Because of the terrible unresponsive service of Traeger we took our money and purchase a Green Mountain Grill.
If you are looking for the perfect spacious grill for home cooking, then this Traeger grill is yours for the taking. This is the most sold and famous model of Traeger grill in the market currently. It uses different kinds of hardwood pellets to smoke, grill, braise, bake, roast and barbecue different flavored dishes. Besides, it has a compact design that saves on storage space. It is built to last with sturdy steel construction with a powder coat finish. Additionally, it has a non-stick surface that makes it easier to clean and maintain the grill grates. Moreover, it is 418 square inches, enough for 16 burgers, 5 racks of ribs and 4 whole chickens.
Every outdoor cooking enthusiast wants an affordable pellet smoker that has all of the key features that even a high-end unit would have. In most cases, this is just a dream and a result of false advertising, because most impressive smokers typically cost a hefty sum of money. The Z Grills Wood Pellet Grill and Smoker claims to be a reasonably-priced smoker that offers top-of-the-line features, and many users have agreed with those claims. With this pellet smoker review of the Z Grills Wood Pellet Grill and Smoker, we’ll find out if it really does what it claims to do.
I had to cancel my order today. I called this morning, however no one at their office could provide a satisfactory answer or response to my order. I actually was asked to provide a second copy of the invoice pink slip which I had already done so. Very disappointed with your company's sales rep that sold me the smoker at the Timnath Colorado store location. She guaranteed that the grill would be shipped out in three days and I would receive it before Easter, my daughter's birthday weekend for a party.

It lowers its temperature by 5° Fahrenheit Increments by lowering the feed rate of the pellets and raises the temp by increasing the feed rate. As for thermostatically controlled grills, the thermostat cycles heat on and off like with the refrigerator as required by your given setting. Some digital temperature controls are so advanced they even include a WiFi setting.
I have a pro series Traeger. Both casters broke with minimal use. Bought new casters from Traeger. Neither one fits correctly and were very difficult to install. Casters came without instructions, so I had to guess. I went to u tube and found that people had to build a whole new leg assembly just to fit on new wheels that were not made for this smoker. I do not want to spend four hours of metal work to simply replace the casters that Traeger should have gotten right in the first place. Can of worms! Take that Traeger!
This smoker comes with two cooking settings: hot and fast, and low and slow. Its Digital Elite Controller makes setting the temperature a breeze — all you have to do is turn the dial to your desired temperature, and you can leave it for the rest of the cooking process. This smoker can reach the temperature of up to 450 degrees Fahrenheit. The digital display on top of the grill lets you monitor the heat conveniently.

Pellet grills preheat quickly, so you can start cooking almost immediately, and the pellets are available in a number of woods, for different smoke flavors. The smoke has a subtle wood-fired flavor with less of the acrid flavor that comes from standard wood or charcoal. For the maximum smoke flavor, it’s best to cook at a temperature lower than 250 degrees, while higher temperatures cook faster with less smoke.