Most pellet smokers are wood-burning ovens: great for ribs, turkey, brisket, and pork shoulders, but not so great for grilling steaks and burgers. The FEC PG series was one of the first lines of pellet burners to offer a sear station, a cast iron cooking grate right over the fire pot where the wood pellets burn. It isn't the best setup for searing, but it's better than most other pellet searing schemes. The real beauty of the Fast Eddy's design is that it produces meat with a deep mahogany finish, much like a competition-grade offset smoker. It also has two upper-level heat zones, for a total of four distinct temperature zones.

A pellet grill is an outdoor cooker that runs on electricity. It uses wood pellets as fuel to cook as well as smoke and flavor the meats. A pellet grill is a combination appliance of grills, smoker, oven and more. It can be used to sear, smoke, grill, roast and even bake! A pallet grill can be used to cook almost all types of meats and proteins. It also accommodates larger quantity and size than a normal indoor appliance. This is what makes a pellet grill so special, its versatility and convenience of use.
My budget range is $1200-$1500. The same as the cost of the XL Primo or BGE. I’ve looked at the Rec-Tec. They look like a great deal. I did notice that they were made in china. Also read they assemble them in Ga. I have concerns with the durability of the lower priced ones. I looked at the Fast Eddie PS 500 also. Now that one is cool. Those are the two I have looked at. The Yoders are getting above what I want to spend.
The hook rack works great and is a must. The Towel holder works ok but does not work well if there a some wind blowing by. Wants to unroll the towel just enough to make it a possible fire hazard by the gind unwinding the towel rool enought that it can flip up over the wind gaurd and get in the flames. I have to remove it from the camp stove if there is any wind to avoid this problem.
Decided that moving these beasts was a little challenging so I bought a Backwoods Party 10 years ago and loved it. But basically have about worn it out. And as I got older I don’t enjoy getting up at 2 AM and then having to get up every couple of hours, after the 45 minutes of getting it ready at 2 AM, to check it and feed it. I also bought a smaller lightly used Open Range, The Good One. Used their recommended method the first time I cooked with it and hated the Q off of it so bad most of it was wasted, wife hated it too and the son ate most of it. It was extremely ash/strong smoke flavored!

I have used Bradley, Masterpiece, Green Egg, New Braunfels, Oklahoma Joe, Weber and now Traeger. So there is some experience in these comments. The “set it and forget” it is a misnomer and should not be used with Traeger (or any smoker/grill.) With Pellet Drive before you buy Read up on Er codes. The worst is when the fire pot fills up with pellets because the fire can’t keep up with the auger push and the whole cook is ruined or delayed. You have to pull everything out and basically start over while your expensive prime brisket is trying to be saved in the oven. Doesn’t matter what the weather is or wind conditions. Doesn’t matter if you stare at it and stir the hopper continuously. It will happen. Customer support at first was well you are at fault (didn’t leave the lid open on fireup for exactly 2 to 4 minutes or didn’t vacuum out the firepot between every cook) which is crazy. Finally, after so many calls over the past 6 months they are trying to make it right. Problem is, DO NOT believe the “set it and forget it.” That does not exist with any good cook. I have replaced the controller the fan and now getting a new probe. Do not waste your money. Unless someone out here in BBQ land can give me a recommendation on a product that won’t do this stay away from Pellet Drive?


The completed transaction enhances Vista Outdoor's position within one of the camping market's most attractive categories, complementing its already broad portfolio of 50 brands in shooting sports and outdoor recreation. Wholesale dollar sales in the camping category grew at a 6% Compound Annual Growth Rate (CAGR) from 2010 to 2015 (source: Sports & Fitness Industry Association). Camp Chef's sales growth has been fueled by a strong product development pipeline and user-friendly products.
The Champion Competition Pro Wood Pellet Grill and Smoker by Louisiana Grills takes outdoor cooking versatility to all new heights. A total cooking area of 3432 sq. in. (8718 sq. cm) and fully integrated multi-chamber smoking cabinets, the Champion Competition Pro is designed to be a show stopper. With direct and indirect flame grilling in the main barrel, hot smoking in the lower smoke cabinet, and cold smoking in the upper smoke cabinet, the Champion Competition Pro is the ultimate grill for the outdoor barbecue enthusiast. This grill revolutionizes grilling in three different ways: the digital control center and lid thermometer allows for precise temperature control of a dynamic range of 60°F-600°F (15°C -177°C) for grilling and smoking, the use of all-natural hardwood pellets allows you to enjoy the amazing wood flavor with the single push of a button, and a programmable meat probe that works together with the digital control center to regulate temperature.
Sometimes, the ideal pellet is something that costs a little over $1 for quality but you can still save money by buying them in bulk (like in 40 pound bags). Half a pound of pellets per hour is consumed on the smoke setting that’s about 175° Fahrenheit. Meanwhile, you can burn 2.3 pounds of pellet within an hour by setting the temperature at 450° Fahrenheit (this is an average on many of the pellet smokers mentioned above).
The Rec Tec Bull is built for serious smoking. The stainless steel chamber doesn't have paint that will chip or peel, and the built-in Wi-Fi technology allows you to monitor your cook from anywhere in the house. And with two meat probes you'll have more flexibility when cooking different types of meals. The 40-lb. hopper and interior LED are features the backyard pros will love.
I’ve had the chance to use one the the Traeger Grills Pro Series grills now for some time, and I find it to be a great pellet grill. They really beefed up the chassis of this model, with a stronger, wider-stance sawhorse base, larger wheels, a nice strong side lift bar, and an upgraded Digital Pro Controller with Advanced Grilling Logic that keeps temps steady, but allows for a temp swing of about 15 degrees. I mention the temp swing here as a positive, rather than a negative. By allowing a tiny bit of temperature fluctuation, I find the grill actually puts out a bit more smoke throughout the cook as pellets are fed in to regulate temps.
Explicitly designed as a tailgate smoker with maximum portability and accessibility, the Davey Crockett does what it does really well. It’s small, but it’s so easy to move and runs off of damn near any power source, so if you want a wood pellet smoker you can take literally anywhere with maximum portability and style, this is the one. That’s why in my opinion, this is the best pellet smoker out there for the money.
It has a cooking area of 800 sq. inches and a hopper capacity of 20lbs. While that just would be fine for regular smoking, this product needs some supervision and pellet refilling for longer smoking sessions. It does not have a Wi-Fi enabled control system, though it does come with a digital control system to provide you some ease of control while cooking with this product.
The unique TRU-infrared technology cooks meat in an even way and helps to retain moisture. The great thing is there are no flare-ups. There’s a roasting basket for ribs, poultry, and other meat. The roasting basket can hold up to 25 pounds. The cooking area were grilling can be done has 180 in.². You can adjust the temperature, which ranges from 9000 to 18,000 BTUs, in the smoker box in order to add flavor.

If you don't buy this cooker and spend more than $600 on any cheap thin steeled cooker. By year 2 you will realize you paid for quality that lasts. I joke that no one would steal it because it weighs so much. But it's my baby and it's double locked. I promise you in a year you will look at your wife or family and say "That's the best purchase I ever made!" It's impressive, no one makes a better product. If u buy Traeger or any other cooker. In 3 years you will regret not spending the money on a luxury machine. Yoder is the best of the best. Yoder is who the other guys want to be. I would buy it again tomorrow! Don't have regrets. You won't regret this purchasem
What’s more, as Pellet Grills are electric-powered and regulate their own fuel intake, they are a far more foolproof option than other smokers and grills which may require a large amount of maintenance and care during the cooking process. Wood pellets themselves are also incredibly versatile. Aspiring smokers can experiment with a whole array of wood varieties in order to explore the flavors that each lends to meat.

My budget range is $1200-$1500. The same as the cost of the XL Primo or BGE. I’ve looked at the Rec-Tec. They look like a great deal. I did notice that they were made in china. Also read they assemble them in Ga. I have concerns with the durability of the lower priced ones. I looked at the Fast Eddie PS 500 also. Now that one is cool. Those are the two I have looked at. The Yoders are getting above what I want to spend.
Personal review of the Traeger: The auger fed the pellets after the fire pot went out making a large pile up which caused it to catch fire and burn up my grill. I had to use a fire extinguisher to put out the flames and prevent my house from catching fire. I sent Traeger the description of damages with photos. After much waiting and no response from the management team regarding my Traeger grill we gave up. The service team was very responsive but lacked any authority to make decisions to fix the grill. We worked with the service team for awhile having a different person each time respond and request information and photos that were already provided. Then, we got passed up to the management which is highly ineffective because we never heard from them, even after an email requesting an update. We really did like our Traeger grill and had high hopes that since it was under warranty and caught fire due to a failure we would have the grill repaired. Because of the terrible unresponsive service of Traeger we took our money and purchase a Green Mountain Grill.
I store it in the Camp Chef cover. It takes about a minute to pull the cover off, install the gas cylinder and side tables, move it into cooking position on my deck, and light the burners. It doesn't take much longer to clean up. After getting the griddle back up to high temperature for cleaning, the active work of squirting, scraping and wiping down takes just a couple of minutes. After cool down, removing the gas tank and side tables (which fit nicely on top of the griddle for storage) and putting the cover on takes another a minute.
Hi – my husband and I are really interested in a pellet smoker. We came across some when we were at a fair and are trying to find more information about the Traeger brand because the price seems affordable compared to all the others you mentioned. You started out talking about the Traeger but never gave any feedback on it? Little help please:) Thanks!
Let's just say I really love to cook! Especially BBQ. I've had the YS640 a couple months now and can't say enough great things about it! I've grilled ,smoked and high temp roasted with excellent results! After week's of comparing and watching videos I know I made the right decision. There's just no comparison to the Chinese makes and the over priced stainless steel models. I considered the MAK smokers but at double the price couldn't justify it. For the price and USA build quality there isn't anything that can touch the Yoder!
Kevin, appreciate your reviews and insights. I am currently looking for my first pellet cooker which will be primarily used for camping, therefore I will likely purchase a portable unit. Your review on the GMG Davy Crocket answered some questions for me. I was initially contemplating the Traeger Junior Elite and GMG Davy Crocket, but after doing some homework I’m now considering the Rec Tec Mini as well. I can purchase the Traeger and GMG now for $350 and the Rec Tec for $500. My dilemma is that I (like many others) take very good care of my gear/equipment, so whatever I purchase, I expect to get a great deal of use out of. With that said, making the wrong decision could be a 7-10 year mistake. There are aspects of each that I like, I guess my question is whether spending another $150 on the Rec Tec, in your opinion, would be worth it to you? I understand if you would rather stay away from specific recommendations, and if that is the case, any other thoughts you have would be appreciated.
Well, if you get yourself a wood pellet smoker not only you can enjoy such an event in the summer, but also continue doing the same in the winter. Today, pellet smokers often come with the “turbo heating technology” that can help you fire up the grill even in the winter. Go get yourself a pellet smoker and don’t let something as trivial as seasons, limit your enjoyment. Because a smoking warm piece of marbled, top quality fatty meat is best enjoyed on a cold night.

So far this smoker is fabulous! There is a learning curve, and this is not a "set it and forget it" smoker. You have to make sure you don't run out of pellets as the smoker will shut down. Tried a pork butt, but I wasn't watching it close enough, so I had to finish it in the oven. Still delicious. Next made some boneless skinless chicken breasts which turned out wonderfully.


Rec Tec has always been known for making advanced Rec Tec wood pellet grills coming in at a higher price. However, some of the popular models come in smaller sizes, like Trailblazer 340 or Bullseye 380. However, compared to their capacities and features, the products in our top ten lists would be better choices. So, among its products, the RecTec Bull 700 is the only one that falls in our Honorable Mentions.

Pellets look like rabbit chow. They are about the width of a pencil and as long as a couple of erasers. If they get wet they turn into a pile of sawdust. The beauty of pellets is that they have none of the additives and fillers in charcoal briquets, so they combust almost completely. Almost zero ash. The pellets provide the heat as well as flavor. No need to add wood chips. Surprisingly, they do not produce overly smoky food. If anything, the food is undersmoked to some people because the combustion is so complete.

Pit Boss Wood Pellet Grills are fueled by all natural BBQ wood pellets. The digital control board ignites the grill and allows you to set the cooking temperature from 180° to 500°F. Fan forced convection cooking eliminates the need for a rotisserie and creates a versatile environment for grilling, roasting, smoking, braising, searing and baking. The 820 features a Flame Broiler as standard; this adds the option to grill directly over an open flame when direct heat is needed. The Pit Boss 820 features a large 820 sq. in. total cooking surface: 580 sq. in. main and 240 sq. in. removable upper rack. With complete structural strength and durability, the Pit Boss 820 is made to last.
Personal review of the Traeger: The auger fed the pellets after the fire pot went out making a large pile up which caused it to catch fire and burn up my grill. I had to use a fire extinguisher to put out the flames and prevent my house from catching fire. I sent Traeger the description of damages with photos. After much waiting and no response from the management team regarding my Traeger grill we gave up. The service team was very responsive but lacked any authority to make decisions to fix the grill. We worked with the service team for awhile having a different person each time respond and request information and photos that were already provided. Then, we got passed up to the management which is highly ineffective because we never heard from them, even after an email requesting an update. We really did like our Traeger grill and had high hopes that since it was under warranty and caught fire due to a failure we would have the grill repaired. Because of the terrible unresponsive service of Traeger we took our money and purchase a Green Mountain Grill.
I think a lot of reviewers here don't have enough experience in pellet grilling to recognize how many features are packed into this unit for the money. I'm not going to talk about the usual advantages of pellet grilling in general in this review (i.e., clean flavor, "set and forget", less ash,). Instead, I'm going to focus on what makes this one uniquely better than the other grills in it's class.

The Z Grills Wood Pellet Grill and Smoker comes with Smart Smoke Technology, which lets you set and forget your grilling. It accurately sets and maintains the desired temperature using an automated electric feed system, heating your unit from 180 degrees F to 450 degrees F. We’ve gotten used to smokers taking around 30-40 minutes to heat up, but with this unit, it took only 20 minutes for the temperature to settle in!

This pellet grill has a 440 square inch cooking surface and weighs 73 pounds. It measures 36 by 18 by 39 inches in dimensions and is made out of durable steel and heavy duty 16 gauge steel construction. It has a dial-in control with an LED read-out. Its temperature reaches from 180 degrees to 500 degrees Fahrenheit. It also comes with a meat probe. This Pit Boss is a worthy name to be in our pellet grill review’ list.
You’re concerned with ongoing costs for fuel and power: The wood pellets used with Traeger grills are more expensive than propane or charcoal. You can expect to spend $1 to $3 per grilling session using wood pellets. Propane is far less expensive to operate in a grill, while charcoal fits somewhere in the middle of the cost range. And beware of cheap pellets from third-party manufacturers that contain softwoods like pine. They burn much faster than hardwoods, so the end cost won’t be that much different because you’ll use more of them. And they can introduce unwanted chemicals and contaminants to your food. You will also have some electrical power costs with these Traeger pellet grills.

If you don't buy this cooker and spend more than $600 on any cheap thin steeled cooker. By year 2 you will realize you paid for quality that lasts. I joke that no one would steal it because it weighs so much. But it's my baby and it's double locked. I promise you in a year you will look at your wife or family and say "That's the best purchase I ever made!" It's impressive, no one makes a better product. If u buy Traeger or any other cooker. In 3 years you will regret not spending the money on a luxury machine. Yoder is the best of the best. Yoder is who the other guys want to be. I would buy it again tomorrow! Don't have regrets. You won't regret this purchasem


This is a nice article for people new to pellet grill/smokers. Like jennifer, we have a vermont cast ing cast iron gas grill that has ‘rotted out’ internally. Calls to vermont cast ings has resulted in ‘we no longer support, make or sell parts for grills made before 2008’ and other run arounds. As a result we are looking for other options. We like the cast iron grills and grill heat but are considering other options, (Webber, Pellet, gas).
Just putting a stamp on your info and recommendations. The Pro is definitely a Pro! Consistent, excellent temp control, juicy and great flavor. Smoke ring, some of my ribs are pink all the way through and dripping with juice. Smoke profile, good, not over powering. I have used 45# of hickory so far, 20# of cherry and a few pounds of apple and pecan. Have not tried anything but Lumberjack but that will be the next experiment. I have tried the smoke tube and it is ok. I was worried about getting an ash or bitter taste as the smoke is fairly heavy and a little acrid smelling if you let it burn from bottom to top. So I lay it down and light on my wife’s Weber gas grill side burner and get the whole thing burning good and then blow it out. If it smells acrid your meat will get some of that taste. Starting the tube this way it is still going an hour later.

Barbecue was not his first career. He earned a BA from Columbia College in Chicago and studied at the Cleveland Institute of Art and the Dana School of Music. He has been involved in every aspect of film, video and music production. He edited the 1991 Academy Award nominated documentary, "The Mark of the Maker" and "Universal Hotel", which is part of a permanent exhibit at the Dachau Memorial Museum.
Operation of your Pit Boss Deluxe Wood Pellet Grill is easy. Simply load the pellet hopper with your favourite all-natural hardwood pellets and turn the dial to your desired pre-set temperature. Within minutes, the grill automatically lights the pellets, and adjusts itself to your desired cooking temperature between 180° to 500°F. The grill can maintain that temperature all day, granted there’s always pellets. It’s that easy. Experience real wood-fired flavor with Pit Boss.
The Woodwind is a Pellet Grill for the connoisseur. Along with a high price tag come all sorts of fancy extras, from a specially constructed 'sear box' to a lever-operated cleaning system for removing wood ash. It's roomy too, with over 500 square inches of cooking space so whether you're cooking for one or smoking several racks of ribs at the same time, the Woodwind will get the job done.
Now comes the best part about pellet smokers: they can conveniently do all these three. Coming with a large cooking space and a lid, the top rated pellet smokers would allow you to keep them open or closed, depending on what results you are looking for. With a dedicated space for putting your charcoal, you can use it as a charcoal grill, smoker or a barbecue. Or you can use it like a kitchen oven using the direct fire from the firepot. Finally, it does what it was made for – pellet smoking. Using small hardwood pellets running over the firepot in a corner, this smoker uses a fan to distribute the heat and smoke throughout the grilling area. This indirect heat ensures that the food is slow-cooked and smoked over long periods of time.

As people learn about pellet grills, they quickly realize that there are a number of brands offering a variety of models. So how are they different? And how do you know which pellet grill is right for you? With more options than ever, shopping for a pellet grill can be confusing. In a market filled with grills that claim similar capabilities, it can be difficult to discern what separates one from another. However, if you know which factors to consider and what features to look for, choosing the best pellet grill for you is a whole lot easier.
Vista Outdoor is a leading global designer, manufacturer and marketer of consumer products in the growing outdoor sports and recreation markets. The company operates in two segments, Shooting Sports and Outdoor Products, and has a portfolio of well-recognized brands that provides consumers with a wide range of performance-driven, high-quality and innovative products for individual outdoor recreational pursuits. Vista Outdoor products are sold at leading retailers and distributors across North America and worldwide. Vista Outdoor is headquartered in Utah and has manufacturing operations and facilities in 13 U.S. States, Canada, Mexico and Puerto Rico along with international customer service, sales and sourcing operations in Asia, Australia, Canada, Europe and New Zealand. For news and information, visit www.vistaoutdoor.com or follow us on Twitter @VistaOutdoorInc and Facebook at www.facebook.com/vistaoutdoor.
Barbecue was not his first career. He earned a BA from Columbia College in Chicago and studied at the Cleveland Institute of Art and the Dana School of Music. He has been involved in every aspect of film, video and music production. He edited the 1991 Academy Award nominated documentary, "The Mark of the Maker" and "Universal Hotel", which is part of a permanent exhibit at the Dachau Memorial Museum.
I purchased a Traeger Lil Tex 22 yesterday. I “grilled” a whole chicken. It overshot the temperature by nearly a hundred degrees which wasn’t a bad way to crisp up the bird but I was afraid it was going to melt itself down so I shut it down. I was up by 5 this morning to smoke a pork butt for pulled pork sandwiches. My wife’s family is coming over for dinner tonight and time being a concern I fired up the “smoker”. It snowed 12 inches last night so the next hour I was shoveling my walks. Imagine my surprise when I checked on the Traeger and it had shut itself off . The meat was colt to the touch. I read through the instructions to make sure I started it up correctly and I did. I removed the meat and restarted the smoker. It smoked for awhile then quit. The temperature never got above 140. I called Traeger technical support twice and each rep gave me a different answer as to why it wasn’t working. After 3.5 hours I gave up on the Traeger for a more conventional method. I purchased the Traeger for the the set and walk away feature. It let me down!! It is 34 degrees outside today so I will wait until it warms up to try again. Should it fail me again I will sell it for scrap! So far I am not impressed. My wood smoker takes time but it is reliable.
If you live in an area where wood furnaces are used (not like down here in FL where a few heat strips will do the trick), you may also be familiar with pellet furnaces. In short, pellets compressed from sawdust and wood shavings fill a hopper and are then fed into a burn pot using an electric auger system. The auger, which is basically a long screw, delivers pellets to the burn pot based on the speed dictated by the unit’s thermostat.
×