After about 10-15 hours of cooking, you should remove the burn cup and dump the ash. If the ash builds up it can prevent ignition. Ash also accumulates in the bottom of the unit, but doesn't impact cooking. A vacuum cleaner with a hose makes short work of it. Only a few manufacturers, such as Blaz'n Grill Works and Camp Chef have a slide out combustion cup that makes cleanup much easier, but you still have to get underneath the deflector occasionally and suck out fly ash that has scattered around the lower part of the grill body.
Great reviews. I have been lately looking into pellet poopers. I currently own a large Big Green Egg and a Pit Barrel Grill. My Egg has limited space. On the PBC (Pit Barrel Cooker) I can cook a ton of food as it uses hanging meat method. But it has zero temperature control on it. A set lower vent and that’s it. You have to adjust the lid to get the temps up. I have adjustable rings for my Egg that allows for increased capacity. Eggs are great smokers, grills and ovens. I do have a FireBoss temp controller for the Egg which will allow a set it and forget operations. Wifi controls also. With that being said, I am looking for increased capacity in my cooks. I was seriously considering a XL Primo Oval or a XL BGE. Then I found these pellet poopers. After reading this blog and other reviews I found some limitations. One the lack of smoke flavor. Now with my Egg I add chunks of wood into the lump for smoke flavor. Same with the PBC. The PBC has different smoke flavor as the fats and juices from the meat drip on the hot coals which ignite (according to PBC’s website) and produce a smokey flavor in the meat. I’ve read two ways to increase the smoke flavor in Pellet Poopers. One is to start at a lower temp for a few hours, then crank it up to cooking temps. Two is the smoke tubes or Mojo Bricks. My question is do these techniques work? One review on the smoking tube said that they really didn’t make that much of a difference. Another issue was for grilling and the lack of direct heat. Grill Grates would eliminate this concern correct? My understanding of Grill Grates is that they provide a way to direct grill in an indirect environment. That’s a limitation with both of my cookers. The Egg can Indirect or Direct grill. Not both. Yes I can remove the indirect piece and set up the Egg for direct grilling, but you risk burnt fingers even with welders mitts on. Wouldn’t the Grill Grates on a Pellet Pooper solve this problem? Allowing you to slow cook that steak to say 10 degrees shy of your temp range then sear it on the grill grate for the a couple of minutes on each side to get it to your desired temp range? Or go the other way, sear first for a few minutes per side then indirect cook it to the desired temp?
This is a nice article for people new to pellet grill/smokers. Like jennifer, we have a vermont cast ing cast iron gas grill that has ‘rotted out’ internally. Calls to vermont cast ings has resulted in ‘we no longer support, make or sell parts for grills made before 2008’ and other run arounds. As a result we are looking for other options. We like the cast iron grills and grill heat but are considering other options, (Webber, Pellet, gas).
As the launcher of the pellet smoker trend, it’s only natural that the innovative Traeger Pellet Grill Company would perfect its pellet grill technology and come up with some of the most affordably priced smokers around costing $300 upwards. It’s the Ford Motors of the pellet grilling world and many a pellet griller on the market to date owes the existence of their industry to this one company.
When you think of a portable smoker and grill, you think about basic features. But with the Tailgater by Traeger Grills, you get more than what most portable grills have to offer. At 300 sq. in., this portable grill is enough to cook decent and succulent dishes for small groups. It can even reach to a maximum 450 degrees F, so you’re never limited when it comes to the type of meat you want to grill or smoke. We loved its EZ fold legs, which make it easier to throw into the car trunk, ready for the next adventure.
Turn it on to "Smoke" mode and use the P settings, or cook mode by selecting a temperature. When you select smoke or a temp setting you start the ignition sequence. The fan, igniter and auger motor turn on. The fan stays on until the smoker is turned off. The auger motor continuously delivers pellets to the red hot igniter rod in the firebox for two minutes under normal conditions. Then the igniter rod shuts off and the pellet fire burns with only the assistance of the auger and the fan.
You then simply select your desired temperature via the digital controls and relax, safe in the knowledge that the temperature will stay steady and there won't be any dreaded hot or cold spots. This consistence is achieved through the efficient temperature control system and automated auger. This ensures a deep smokey flavor is embedded in your meat every time.
Hey David – in my opinion, you’re going to find hot spots in any entry level pellet grill/ pellet smoker. I include GMG, Rec-Tec, Traeger, etc. When you start moving into the higher pellet smokers/grills – Memphis Grill, MAK, etc, you can minimize these to some extent. If you experience higher heat on one side, put the thicker cut of meat (pork butt, point of brisket) near that part.
Hey Corry – GMG and Traeger have shown that they support their brands very well of late. In many cases, they both provide parts support even when warranty limits run out. If you’re considering a Traeger, I’d urge you to go with their Pro Series 22 or 34. Sounds like that’s what you’re probably looking at where they are concerned if you’re looking at a dealer.
Products listed as Out of Stock are currently not in stock at the store(s) being viewed. Note that in some instances, very limited inventory may be available in stores, but because of small quantities we are unable to reflect the availability online. Please remember to check back – if or when inventory is replenished and available, this will be reflected online.
Kevin- I’m in the process of researching to get my husband a grill for Christmas. I’m torn between the 820 you mentioned above and the Traeger Pro Series. As far as I can tell they are basically the same except that you get a larger cooking area on the pit boss for the same price you pay for a small cook space in a traeger. I would like to spend around $600 on the grill but would possibly go up to $800 and want 500 sq in cook space or greater. Which do you prefer? Pit Boss, Traeger or another brand?
As time passed, a thermostat was added to the equation, and the production BBQ smokers fueled by pellets working in “set it and forget it” fashion was in full force. From this point, several manufacturers of pellet grills began to pop up, with a few key names like Yoder Smokers, Mak Grills, Green Mountain Grills, and Fast Eddy’s Cookshack grills being among the most notable.